2022 SUBARU OUTBACK Complaints

Windshield suffered a large stress crack while parked overnight. Came out to an 18” stress crack in the morning. A long, single, curved crack with no point of impact. Later in the day, still while parked, the stress crack extended half the width of the windshield. Took the car to the dealership and was informed that the windshield is not covered under warranty.

In the two years I have had this vehicle, I have had to replace the windshield twice. The first time, a pebble hit the windshield and a 6-8 inch crack immediately appeared, The crack increased in size over days and nearly went across the whole windshield. Because this was a few months after purchase, Subaru replaced it. Now in March 2024 and another pebble hit the windshield, this one so small i didn't even see it and a 8 inch crack immediately appeared. The crack increased in days as well. Subaru would not cover it and told me to go through my insurance. I waited to get it repaired and during this time another pebble hit the glass. Again, another 6-8 inch crack. Subaru refuses to take responsibility that this is a manufacturer issue. I've had 3 other Subaru vehicles and this never occurred.

I experienced a fuel leak while driving my car. It was leaking from the fuel lines in the engine bay. My fuel gauge was showing low and I had just refueled several days before. I didn't know it had a leak in the line. When I tried to put more gas in, the fuel ran out under the car. I had my car taken to the dealer where I had bought it less than two years ago. They called me and said it was a bad fuel line caused by squirrels biting the line. They said the insulation around the line had soy in its making which attracted them.I I got it back after a week. This is most certainly a safety hazard. They also said other makes and models have used these same components since 2010.

On 03Feb24, immediately following a 4-wheel alignment of my 2022 Subaru Outback Limited, my vehicle’s suspension feels unstable over patched potholes or rough/broken pavement. I can best describe the condition as similar to the movements felt while hydroplaning but it does it on dry road. It jerks side to side; 3 or 4 times; in rapid succession; just enough to command the driver’s full attention. The condition happens periodically at highway speeds. I’m afraid my vehicle might lose grip and crash. I have brought my vehicle in twice to my local Subaru dealership for inspection. The mechanics have been able to witness the condition. A few measures were taken to remedy the condition including, vehicle re-alignment, installation of one shock absorber on the rear suspension to no avail. The mechanic report, issued 10Apr24, states the condition may be due to the brand new tires installed on 19Feb24. However, this assessment is inconclusive and requires expensive trail and error tied to buying a new set of tires. The condition started on the OEM tires and still occurs with the new set of tires. The condition began 03Feb24, immediately following it’s first ever 4-wheel alignment at the dealership. I have been trying to get this fixed since then. The condition persists as of the date of this writing. On 16Apr24, I submitted a formal complaint through Subaru of America web form.

My brakes failed as I was pulling up to a curb as I attempted to break to put my car into park my breaks failed to engage. My vehicle is also equipped with emergency braking system that did not engage my vehicle crashed into and through a 7/11 while I was breaking the entire time manuall! The vehicle would not stop and did not stop until it hit the back wall of the store inside.

The contact owns a 2022 Subaru Outback. The contact received notification of NHTSA Campaign Number 23V755000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Thermal control valve became inoperable at less than 40,000 miles. Engine shut down and began to overheat. Part is known to easily fail by Subaru. Has been examined by dealership. All warning lights came on at once, and cruise control and Eyesight were disabled. NHTSA Recall Number 23V755000 We have been on the list for this recall repair since 12/28/2023, we were told when we scheduled the service appointment for the TCV that the dealership was not doing any more recall repairs any time soon as they could not get parts.

Windshield cracked when vehicle was traveling at a slow rate of speed, in the rain while on an on/off ramp. It has already been repaired. Crack went across the windshield right in my line of vision. The dealer examined the car and stated that at some point, the windshield was hit and that it just eventually cracked. There was no warning prior, I had not noticed any nicks prior to the crack.

While on highway 880 north bound. A rock was thrown towards our windshield while going through construction zone.

While parked and without impact from any object, the windshield cracked causing visibility issues for the driver leading to unsafe driving conditions for those inside and outside the vehicle. The problem is a common issue among many Subaru vehicles. The issue has been reported but not yet inspected. There were no warnings before the issue appeared.