2021 SUBARU OUTBACK Complaints

When I bought my new 2021 Subaru on Sep. 27, 2021. It was twilight and the sales lady said it had a small rock chip in the windshield but they were going to fix it. Driving home, I saw the windshield had a spider web of cracks all over it. I took it back on Sep. 30 and they replaced the windshield. On Oct 31, I drove 660 miles. When I looked at the Subaru in the motel parking lot the next morning, the new 5-week old windshield had cracks. There was a rock chip where the cracks crossed. They were not spread all over but covered an area about 14" wide and 8" high. I didn't want to drive it but I had to get it back to the dealer. Later I saw the State of New Jersey had filed lawsuits against Subaru for cracked windshields on 2.5M vehicles. I felt sick and didn't know what to do. I found a "Service Bulletin" No. 12-192-12R dated 10/26/15. It was only for 2015-2016MY Legacy and Outback models and MY's but it described the crack issue and illustrated it. It was very limited. It just offered an extended warranty and one repair on specific models. I believe this is a serious Safety Defect because it is spread over a large population of vehicles and Subaru is not admitting any defect or safety problem. If this occurs on a trip, it's likely the driver will continue to drive to their destination with a dangerously compromised windshield. FMVSS 205 states that Glazing in Auto windows is to reduce injuries resulting from impact to glazing surfaces, to maintain transparency for visibility and minimize the chance occupants are ejected from the vehicle in a collision. It also appears the windshields do not meet Fracture Test 7 in SAE Z26 for tempered glass and multiple glazed units. The size of fragments observed in the spider-web patterns are 1" to 3" and more and likely weigh more than the 4.25 grams in the Fracture Test. In my 65 years of driving, I’ve never had a windshield crack like the two windshields cracked on my Outback in the period of five weeks.

Windshield developed a large crack for no apparent reason. There is no sign of an impact from an object. Vehicle was parked outside when outside temperature dropped overnight. Crack over 6” long appeared the next morning.

We purchased a new 2021 Outback Subaru 2 months ago. Three days ago, on 11/12/21, a crack appeared on the windshield overnight, while the car was parked on our driveway. Nothing hit our car while we were driving and there's nothing that stands above the car that could have fallen on it while parked at our house. The crack is linear and started on the very left side right above the driver's sight. It started at about 5 inches long and the next day was already extending almost halfway through the windshield length. We are highly suspicious that the crack is a result of a defective windshield specially after learning that Subaru has several lawsuits regarding this same issue. We had to stop driving the car in fear that the windshield may completely break at any time. My husband contacted Subaru twice and the representatives told him someone would soon contact him about the incident. Nobody contacted us for the next two days. My husband then called Subaru and they said it would cost $1,500 to fix it.

2021 outback purchased Feb 2021. Within 2 weeks the touch screen, which controls the cruise control, heating, all eyesight controls went blank. This causes cruise control at highway speed to quit, causing sudden deceleration at highways speeds. Sometime the screen reboots, most times it requires driver to pull car over to reset. This also controls GPS and Heating/Air. There have been times when I have working canines in the car and loss of air conditioner in summer months has been extremely problematic requiring pulling car off road to open windows to ventilate. Multiple trips to dealer, and open case with SOA results in no resolution, as there apparently is no fix. Recently 11/1/21 instructed when this happens to push my front defroster button five times after reboot to record codes. How distracting while driving is this? Feel like this is severely underreported as owners frustrated. Receiving dealer instruction to look at touchscreen while driving causes the cars alert function to activate saying “keep eyes on road”. Why are they advising this unsafe action? Recent software updates as late as last week of October installed and does not fix issue, verified by dealer service manager. Multiple incidents, recorded on my phone video, last incident occurred 7/12/2021.

Front window crack without being struck by rock or any other object in the second month of ownership.

The vehicle on board computer system periodically goes completely black (i.e., completely shuts down) disabling all of the operator controls (heater/fan/defrost controls, seat heater controls, temp controls, navigation, radio and other dash monitoring and informational controls, etc.). I am not sure of all features/functions that are lost because it happens when I am driving and I cannot investigate to see what all functions/indications I have lost. It remains out of service for a short period (the times of the shut down seem to have varied) of time and then comes on and reboots itself. Sometimes it comes back to where/when it shut down, and sometimes it just comes back to the initial ignition/start screen. This requires action by the driver (which is a safety concern because it requires the driver's attention and is distracting) to reset control settings. Navigation sometimes requires resetting an address because the computer lost its destination. This is dangerous. I just had the vehicle serviced for this issue and had a Subaru "FIX" installed - that apparently did not work. The problem still exists.

The contact owns a 2021 Subaru Outback. The contact stated that while driving at various speeds, the home screen on the center console would go blank without warning. Once while driving 65 MPH with the cruise control activated, the center console went blank and the cruise control deactivated with several unknown warning lights illuminated. The contact stated that vehicle abruptly slowed down due to the failure and the 360-camera feature failed to operate as needed. The dealer was notified and acknowledged the failure; however, they informed the contact that there was no remedy for the defect. An independent mechanic was also notified and provided the contact similar information as the dealer. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 11,000.

Windshield spontaneously cracked on passenger side at eye level after 5 months, 5,700 miles

The emergency braking forward collision system has deployed several times when it should not. In some circumstance the braking could result in the person behind me rear ending me. The main problem is that if the car detects another car directly in front of you, the system will sometimes deploy even if the vehicle is not in the same lane as you. I've had the emergency brakes deployed incorrectly in the following situations. I am driving in the left lane of a 2 lane road with a speed limit of 45 mph and the road is banking sharply to the left. Because of the sharp bank, a car was directly in front of me but in the right lane, so this is a normal non dangerous situation but the brakes deployed. I exited a parkway, the exit ramp banks sharply to the right as most exit ramps do. Directly ahead of me but off the road is a disabled vehicle. There is no danger to me as it is safely off the road, but the brakes were deployed. In both instances there was no one following close behind me but if there was, either situation could have resulted in them rear ending me. I have taken to disabling the emergency braking feature because I no longer feel safe using it. Unfortunately this takes 7 key presses to accomplish and it resets every time you turn the car on. I contacted Subaru customer service to complain, but got ridiculous suggestions, like just turn off the emergency braking when you expect to be driving with a lot of cross traffic. If not rectified, sooner or later that's going to cause an accident.

Your form would not allow me to chcek all applicable issues. I believe the computer system and brakes are the major issues. The start/stop system engaged when I was turning in the middle of an intersection. When driving at cruising speeds (foot on the gas pedal), the car suddenly felt as if the brake was being engaged. The forward and rear collision warning signals do not work. The blind spot warning does not work. There is grinding coming from the undercarriage at times (random), while my foot is on the gas. The car bucks for no reason. The battery is draining (less than 2,000 miles on the car). Sometimes I have to turn the ignition twice in the morning. I turn everything off when I get out of the car. My safety and safety of others is definitely at risk. What I didn't realize until recently is that prior to accepting the vehicle, the salesman must have turned the start/system off, because when I went for a test drive, the start/stop did not engage once and I drove in city traffic with multiple stops. Immediately upon diving off lot, the car stopped and I had issues. The salesman told me I had to get used to the start/sytem. This is a dangerous situation. My car is currently being looked at by the dealer.