2021 SUBARU OUTBACK Complaints

I have has to replace the windshield 3 times in less than 3 years in my 2021 Outback. Only once was there a definite impact from a rock. In that case, the glass broke in 5 directions across the entire windshield. The other two times, I simply woke up to a huge crack. It seems that this is an extremely common problem with this model, and my insurance says they will drop me if I continue to make claims at this rate.

Eyesight driver assist went out rendering safety features inoperable. Touch screen also blanked out so unable to adjust a/c, navigation,radio etc. Car had been on long distance all hiway drive and at 7 hours systems failed. Weather was in the 60s, overcast and it was in the afternoon. Pulled into rest stop and turned engine off then restarted but still failed. Drove 2 more hours and next rest stop systems came back after letting car sit off for 10+ minutes.

I purchased a new 2021 Subaru Outback Onyx Edition XT in May of 2021. The headlights have been a continual problem and I cannot get a solution from the dealer. They are way too bright. It’s a safety hazard to oncoming drivers. I also believe it’s a personal security risk to me from angry drivers. And there's nothing I can do about it because I don't have my high beams activated. The headlights need to have two separate intensity settings, one for low beam and one for high beam, but they do not. Currently, the low beam and high beam use the same intensity LED. The switch between high and low beams does not change the intensity or brightness. It merely activates a motor that moves a metal plate. The plate acts as a shutter that changes the angle the lights shine so the driver has a broader field of vision. The intensity of the lights do not change. The high beams are always on even when not activated. No wonder oncoming drivers are flashing their high beams and getting angry. I have voiced my concerns to the Subaru dealer who checked my headlights and said they were properly aimed. I have voiced my concerns on the Subaru forum and found many other drivers are experiencing the same problem. Some people on that forum suggest re-aiming the headlights so they point lower. This does not solve the problem. Doing so limits visibility to a very short distance ahead of the vehicle creating a different safety issue, not being able to see objects, animals, or people in the roadway. FMVSS No. 108 requires 2 intensity settings for motor vehicle headlights. Subaru has not provided that and is in violation of that federal regulation. I am requesting that NHSTA exercise whatever regulatory authority it has to enforce this requirement including issuing a recall on the Subaru Steering Responsive Headlights. Watch 18:45 to 21:30 of this YouTube video to see the inner workings of these headlights: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The 2021 Outback XT which we purchased new on April 15, 2021, would not start on September 15, 2023. My spouse had a medical appointment that morning. On September 18, 2023, the vehicle would not start again. My spouse had a medical appointment that morning as well. This same problem occurred several months earlier. On the morning of May16, 2023 I called the dealership's service department for a service appointment. This was the first such incident and caught me totally by surprise. Here is a direct quote from the Service's Manager's May 19, 2023 email. " The tester/charger determined that your battery was healthy, had a good state of charge and accepted a good rate of charge and also held the charge. The battery has no fault, the drain was the issue determining replacement of your battery was unnecessary and not warrantable." The dealership service department manager went on to state "it (battery)required 3 hours and 45 minutes of charging". Following the May 16, 2023 service appointment the vehicle performed as expected until the morning of September 15, 2023. On September 19, the vehicle was again taken to the dealership for servicing. During this visit, a "new battery" was installed by the service department because they determined the existing battery failed their test. The service rep stated the “new” battery will fix the problem. Also, the service rep stated, when asked, that the Electronic Control Module was updated but the Data Communications Module was not replaced. Additionally, the rep stated, when asked, the “new” battery did not carry the normal warranty because it was installed under the vehicle’s existing 3-year warranty which expires on April 15 2024. This limited battery warranty makes no sense. Since the May 16, 2023 incident, we experienced emotional tension every time we have driven the vehicle, dreading it would not start when we needed the vehicle the most. We are 70+ and believed that we were purchasing a safe vehicle.

I was driving and suddenly 13 flashing lights and codes from check engine to loss of cruise control and RAB -dealer says it needs a new thermo control valve (thermostat). This failed part has been common on Subarus for 3 years-reported on internet and even to the point where a guy sitting next to me today with same car and year and same $1800 bill and diagnosis. Should be a recall. Part was redesigned in 2022 I read.

On Sunday, August 20, 2023 I was pulling into a parking spot in front of an Anytime Fitness at a local strip mall. As I applied the brake, the motor raced and accelerated driving me into a pillar outside of the fitness center. I was in shock, not understanding what had happened. Had I chosen to park one stall to the right, the car would have gone through the window of the business instead of the pillar. Considerable damage was done to the pillar and to my 2021 Subaru Outback, but I was not injured, and no one else was injured. I had the brakes checked at my vehicle service center and was told the brakes were functioning as they should be. The vehicle has not been inspected by the manufacturer, police, insurance representatives or others. No warning was provided by the vehicle. The crash occurred in two seconds.

Went out to car and windshield had a 6 inch horizontal crack in the beginning at the center of the frame the passenger side extending towards the driver side. There was no chip or point of impact noted. Appears faulty placement of windshield like on prior model class action.

With 22,000 miles my front rotor brakes need replacing and I don’t have a heavy foot! This is my 5th Outback and so my history vouches that I’m not a driver that wears down brakes or tires. When I did some online searching, there are a number of people posting with the same experience. Subaru knows there is a problem because they are quick to replace under warranty. But this is dangerous. In my case, the brakes were checked just a few thousand miles ago and the were “ very good”, scored 8. Fortunately a friend was sharing the driving on a long trip and they caught that there was a problem. I made a service appointment while we were on the road. Please investigate and have them come up with a better solution than resurfacing the breaks after just 22000 miles

When driving on Interstate Highway 44 at approximately 45mph the windshield suddenly cracked on the lower passenger side of the vehicle. There was minimal traffic at the time of the incident and the roadway ahead was clear.

The windshield has spontaneously cracked on 4 separate occasions. Subaru denies this is a defect and claims all have been caused by rock chips. This is not true. The cracked windshield has caused the vehicle on numerous occasions to slam on its breaks while traveling at 55 mph or greater as it “senses” a collision. This has nearly caused 3 accidents so far.