2007 SUZUKI VZR1800 Complaints

TRANSMISSION POPPING OUT OF SECOND AND SOMETIMES 3RD GEAR. HAPPENS VERY OFTEN AND GRINDS IN MOST GEARS. I HAVE HAD TO DEALERSHIP AND WAS TOLD BY SERVICE ADVISOR THAT MY CABLE WAS ADJUSTED PROPERLY AND IT'S A NORMAL CHARACTERISTIC OF MY BIKE. AFTER VISITING FORUMS IT SEEMS TO BE AN ONGOING PROBLEM. *TR

THE MOTORCYCLE TRANSMISSION WILL JUMP OUT OF SECOND GEAR INTO NEUTRAL WHEN ACCELERATING. *TR

MY SUZUKI M109R LEAKS OIL FROM THE LEFT HAND SIDE AIR FILTER. THE DEALER SAID IT WAS OVER FILLED AND HE HAS CHECKED THE LEVEL TWICE AND STILL IT LEAKS. IT IS UNSAFE BECAUSE THE OIL IS GOING EVERYWHERE. *TR

2007 SUZUKI M109R (VZR1800) LE AFTER SHIFTING INTO 2ND GEAR, AND ACCELERATING, THE MOTORCYCLE SEEMS TO BE MISSING THE GEAR OR SLIPPING THE GEAR. THIS CAUSES THE MOTORCYCLE TO SHAKE VIOLENTLY AND CAUSE THE RIDER TO ALMOST LOSE CONTROL. AFTER DOING RESEARCH, THIS SEEMS TO BE A KNOWN ISSUE WITH THESE BIKES FOR HAVING FAULTY SHIFT FORKS. SUZUKI NEEDS TO STEP UP AND FIX THIS ISSUE AS THIS CAN BE EXTREMELY DANGEROUS. *TR

TL* THE CONTACT OWNS A 2007 SUZUKI VZR1800 MOTORCYCLE. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT NOTICED THAT AFTER SHIFTING IN GEAR AND DEPRESSING THE ACCELERATOR PEDAL, THE MOTORCYCLE LUNGED FORWARD. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER NINE TIMES FOR THE IDENTICAL FAILURE. THE DEALER PREVIOUSLY REPLACED THE CLUTCH WHICH DID NOT CORRECT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 500. THE CURRENT MILEAGE WAS APPROXIMATELY 6,300.

TL*THE CONTACT OWNS A 2007 SUZUKI VZR1800 K7 MOTORCYCLE. THE CONTACT STATED THAT THE TRANSITION FROM FIRST GEAR TO SECOND WAS UNUSUALLY ROUGH. THE DEALER STATED THAT THE ROUGH SHIFTING WAS NORMAL AND COULD PROVIDE NO FURTHER ASSISTANCE. THE MANUFACTURER WAS CONTACTED AND ALSO ADVISED HIM THAT THE SHIFTING WAS NORMAL FOR HIS MODEL VEHICLE. THE FAILURE MILEAGE WAS 10,000.

REAR BRAKE ROTOR RIVETS ARE REALLY LOOSE,AND THE REAR BRAKE ROTOR YOU CAN MOVE IT. *TR

TL*THE CONTACT OWNS A 2007 SUZUKI VZR 1800 M109R. WHILE DRIVING THE VEHICLE AND SHIFTING INTO SECOND GEAR THE VEHICLE CHANGED GEARS WITHOUT WARNING ON IT'S OWN. THE DEALER STATED THAT THE GEAR SHIFTING MALFUNCTION WAS CAUSED BY A HARD SHIFT. THE VEHICLE HAS NOT BEEN REPAIRED DUE TO THE REPAIR COST. THE CONTACT IS CONCERNED ABOUT THE SAFETY RISKS SINCE THE GEARS SHIFTING AT WILL COULD CAUSE A CRASH TO OCCUR. THE FAILURE MILEAGE WAS 14,000 AND THE CURRENT MILEAGE WAS 14,800.

SUBJECT IS MY AND OTHERS 2007 SUZUKI BOULEVARD 109 MOTORCYCLE, 2ND GEAR DEFECT/FAILURE.I WENT ON THE WEBSITE OF M109RIDERS.COM AND DISCOVERED THAT THERE ARE SEVERAL OF THE SAME CASES AROUND THE COUNTRY AND ALL OF THEM ARE OF THE 2ND GEAR JUMPING OUT INTO THE NEUTRAL POSITION, WHICH I HOPE DOESN'T RESULT IN SOME ONE GETTING KILLED OR SERIOUSLY HURT. NOT TOO FAR FROM WHERE I LIVE,THERE IS A SUZUKI DEALERSHIP THAT HAS SEEN 7 OF THE SAME CASES OF WHAT I'M EXPERIENCING COME INTO THERE DEALERSHIP AND THE MECHANIC SAYS HIMSELF THAT SUZUKI IS REFUSING TO DO A RECALL IN FEAR OF HURTING THEIR FUTURE SALES OF THIS NEW MODEL BECAUSE OF THE 2ND GEAR DEFECTIVE/ FAILURE . I'VE PUT A FORUM ON M109RIDERS.COM ASKING IF ANY ONE ELSE WAS EXPERIENCING THE SAME THING I HAVE BEEN AND I RECEIVED AN OVER WHELMING OF EMAILS AND PHONE CALLS OF ANGRY AND LIVID MOTORCYCLE OWNERS OF THIS PARTICULAR MOTORCYCLE. I'VE RECEIVED CALLS FROM ALL OVER THE COUNTRY ABOUT THE 2ND GEAR JUMPING OUT OF GEAR THEN INTO NEUTRAL POSITION ON THIS MOTORCYCLE, WHICH IS VERY DANGEROUS FOR ANY ONE THAT EXPERIENCE THIS. THE BOULEVARD 109 FROM THE YEARS, 2006 1ST MODEL TO 2009 IS WHERE THE PROBLEM IS COMING FROM AND I'M ALSO BEING TOLD THAT SUZUKI IS WITH HOLDING THE RELEASE OF THE 2010 MODEL BECAUSE OF THIS VERY PROBLEM. I HOPE THAT SUZUKI WILL DO THE MOST RESPONSIBLE THING, WHICH IS RECALL, THESE MOTORCYCLES BEFORE SOME ONE GETS HURT OR EVEN WORST KILLED. I'M BLESSED WHEN MY 2ND GEAR FAILED ON ME AND THAT THE DRIVER OF THE TRUCK THAT ALMOST RAN INTO ME WAS A VERY EXPERIENCED DRIVER AND SWERVED OUT THE WAY OF HITTING ME. WE ( SUZUKI BOULEVARD 109 OWNERS ) ALL THANK YOU FOR LOOKING INTO THIS MATTER AND WE ALL HOPE THAT SUZUKI DOES THE RIGHT THING... *TR

I STOPPED FOR A SIGNAL LIGHT. THE CLUTCH ON THE MOTORCYCLE LOCKED UP AND WOULD NOT DISENGAGE. THE MOTORCYCLE SURGED FORWARD. I HAD TO KILL THE ENGINE BY USING THE EMERGENCY KILL SWITCH. I HAD TO HAVE THE MOTORCYCLE TRANSPORTED TO THE REPAIR SHOP. AFTER DISASSEMBLY, IT WAS DETERMINED THAT THE TUBULAR NUT ON THE (GEAR ASSY., PRIMARY DRIVE SKU: 21100-48G00) HAD BACKED OFF. THIS ALLOWED THE PRIMARY GEAR TO MOVE PREVENTING THE CLUTCH ASSEMBLY FROM OPERATING. I CHECKED THE INTERNET AN FOUND THAT MANY PEOPLE HAVE EXPERIENCED THIS PROBLEM. I WAS LUCKY THAT WHEN MINE LOCKED UP I WAS STOPPED AND WAS ABLE TO KILL POWER WITH THE EMERGENCY SWITCH. I WAS ALSO LUCKY IN THAT I WAS THE FIRST VEHICLE IN LINE AND DIDN'T REAR END ANYONE. IF THIS HAD OCCURRED WHEN I WAS MOVING I COULD HAVE HAD A SERIOUS ACCIDENT. I CALLED THE SUZUKI TECHNICAL HELP LINE ASKING FOR THE TORQUE SPEC FOR THE TUBULAR NUT. SUZUKI REFUSED TO GIVE IT TO ME. I WAS TOLD THAT I HAD TO BUY A NEW ASSEMBLY FROM A SUZUKI DEALERSHIP. THERE IS NOTHING WRONG WITH THE EXISTING COMPONENTS OTHER THAN THEY WERE NOT ASSEMBLED PROPERLY. THE TUBULAR NUT WAS NOT TORQUED PROPERLY. IF I BUY A NEW ASSEMBLY WHAT CHANGE HAS SUZUKI MADE TO PREVENT THE PROBLEM FROM OCCURRING IN THE FUTURE. I WANT SUZUKI TO COVER THE COST OF THIS REPAIR. *TR