2002 SUZUKI XL-7 Complaints

DT: CONSUMER HAD CAR FOR 2 YEARS. ABOUT EVERY 5,000 MILES HAD TO CHANGE THE TIRES ON THE FRONT END DUE TO THEM WEARING OUT ON THE INSIDE OF THE TIRES. VEHICLE WAS TAKEN TO DEALER FOR FRONT END ALIGNMENT. FRONT END ALIGNMENT DID CORRECT THE PROBLEM. *TT

ON A RAINY WEDNESDAY MORNING, CAME TO A STOP SIGN SIGNALED TO MAKE A LEFT TURN UPON MAKING THE LEFT TURN THE CAR JUST ACCELERATED AND WENT INTO A WALL. CAUSING DAMAGE TO THE FRONT OF THE CAR

CONSUMER PURCHASED THIS VEHICLE ABOUT A MONTH AGO. SEVERAL DAYS AFTER PURCHASE THE SUSPENSION MALFUNCTIONED. THE VEHICLE WAS VERY DIFFICULT TO MANEUVER. THERE WAS AN INCIDENT WHERE CONSUMER CAME TO A 4 WAY STOP, AS THE CONSUMER WAS MAKING A RIGHT TURN, IT BROKE DOWN. THIS WAS DUE TO THE REAR AXLE SHAFT.*AK *JB

PROBLEMS WITH VEHICLE OVERHEATING.*MR THE VEHICLE ENGINE WOULD OVERHEAT OCCASIONALLY AND LEAK COOLANT. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE COOLANT, RADIANT, THERMOSTAT AND OTHER ENGINE COMPONENTS. TRANSMISSION FLUID LEAKED AND WHITE SMOKE COULD BE SEEN COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE'S ACCELERATOR PEDAL VIBRATED AND NOISE WAS HEARD COMING FROM THE ENGINE WHEN STARTING. THE TIMING CHAIN AND TENSIONER HAD TO BE REPLACED. *NM

BROUGHT VEHICLE TO ONE DEALER, MULTIPLE TIMES REGARDING ENGINE COOLANT EMPTY, OVERHEATING. FIRST DEALER STATED WAS BAD RADIATOR CAP. REPLACED, AND PROBLEM STILL OCCURRED. WENT TO THIS DEALER 3 TIMES FOR PROBLEM WITH NO RESOLUTION. FINALLY WENT TO ANOTHER DEALER, AND FOUND CYLINDER HEADS TO BE BAD, STATED PROBLEM COULD HAVE BEEN AVOIDED IF DIAGNOSED EARLIER. ORIGINAL DEALER WANTED FEE FOR DIAGNOSIS, EVEN THOUGH CAR STILL UNDER FULL WARRANTY. AFTER REPLACEMENT, ENGINE NOW MAKES CONSTANT TICKING/KNOCK AND PING NOISE WHEN DRIVING, AND MORE PRONOUNCED WHEN ACCELERATING. SECOND DEALER STATED UNABLE TO RECREATE PROBLEM, HOWEVER CONTINUES TO OCCUR EVEN 1 YEAR LATER. *JB

NHTSA RECALL 03V-512 000. ACCELERATOR CABLE CASING CAP: THIS RECALL WAS DONE ON JANUARY 22,2004. CONSUMER HAVE A CONCERN THAT THEIR VEHICLE WAS INVOLVED IN AN ACCIDENT ON JULY 9,2004, WHICH THE VEHICLE SUDDENLY ACCELERATED OUT OF CONTROL WHILE DRIVING OFF A GRAVEL PARKING LOT OF 5 MPH. CONDITION CAUSES THE VEHICLE TO HIT A PARKING VEHICLE BEFORE STOPPING. PLEASE PROVIDE ANY FURTHER INFORMATION. *LA

INNER FRONT BRAKE PADS FELL OUT OF THE BRAKE CALIPERS CAUSING THE CALIPER PISTON TO DIRECTLY CONTACT THE BRAKE ROTOR. THIS WORE DOWN THE ROTOR AND CALIPER PISTON CAUSING BOTH TO REQUIRE REPLACEMENT. THIS ALSO CAUSED BRAKING TO BE GREATLY REDUCED. *JB

KEY GETS STUCK IN CHAMBER, HAVE TO TURN KEY OFF SUPER FAST TO PULL KEY OUT. JIGGLING DOESN'T HELP MUCH. JUST SHEER FRUSTRATION THAT KEY WONT COME OUT

WHEN ON THE FREEWAY AND ACCELLERATING OVER 55MPH, A RATTLING-VIBRATIONS SOUND OCCURS. IT SOUNDS LIKE ITS COMING FROM THE 4WD STICK OR GEAR SHAFT AREA. THE CENTER CONSOLE WAS PULLED OFF AND CARPET AND WIRES WERE CHECKED TO SEE IF SOME THING WAS STUCK BUT NOTHING WAS FOUND.

WHILE PRESSING ON THE ACCELERATOR PEDAL THE PEDAL STUCK TO THE FLOOR. THIS CAUSED THE DRIVER TO STEP ON THE BRAKE PEDAL, AND PUT THE VEHICLE IN NEUTRAL. CONSUMER HAD CONTACTED THE DEALER ABOUT THIS ISSUE. HOWEVER, MECHANIC WAS UNABLE TO DUPLICATE THE PROBLEM. *AK