2021 TESLA MODEL 3 Complaints

Front Seatbelt On March 13, 2026, at approximately 7:51 PM EST (23:51 UTC), the driver of a 2021 Tesla Model 3 was killed in a head-on collision on SR 741 in Warren County, Ohio. Two people died in this crash — the Tesla driver and the driver of the oncoming vehicle. Tesla's own telematics data (provided to the family post-crash) reveals that the driver's seatbelt unlatched at Row 5115 / 23:51:03.269 UTC — exactly 14.15 seconds before the collision. The driver was actively driving at the time, as confirmed by 66 separate steering torque readings between the seatbelt unlatch and the crash, ranging from -1.59 Nm to +2.15 Nm in constantly alternating directions — the signature of active lane-holding. The seatbelt released on its own while the driver was actively steering based on tesla data at approximately 66 mph. No rational driver unbuckles their seatbelt while driving 66 mph on a busy two-lane road. The telematics data proves continuous active driving before, during, and after the seatbelt event. The seatbelt failure is a separate and independent defect from the Emergency Lane Keeping (ELK) system failure that caused the collision (which is the subject of a separate NHTSA complaint). Even if the collision was unavoidable, a functioning seatbelt may have saved the driver's life. The seatbelt failure independently contributed to the fatality. The following data is from Tesla's own telematics file provided to the family: Timestamp (UTC)RowEvent 23:51:03.269 5115 Driver seatbelt status changes from LATCHED to UNLATCHED 23:51:03.269 – 23:51:17.420(row 5115–5311)66 steering torque readings confirm active driving (-1.59 to +2.15 Nm) 23:51:17.4205311ELK system activates (separate defect) ~23:51:19.0—Head-on collision — driver unrestrained — two fatalities Pattern of identical complaints from other 2021 Model 3 owners (ODI 11713076, 11738583, 11684327)

Component: Lane Support System — Emergency Lane Keeping (ELK) Part of standard Autopilot safety suite (not FSD) activated without valid lane detection data and pushed the vehicle into the oncoming lane of traffic on Ohio State Route [XXX]. The system then aborted mid-intervention (LSS_STATE_ABORT), leaving the driver in the oncoming lane. The resulting head-on collision killed both drivers — the [XXX] Tesla driver and the driver of the oncoming vehicle. Two people died because of this ELK malfunction. Tesla's own telematics data confirms the following sequence: 5At 23:51:17.420 UTC, the Lane Support System activated Emergency Lane Keeping (LSS_STATE_ELK). 6At 23:51:17.652 UTC (232 milliseconds after activation), the system logged ALC_UNAVAILABLE_NO_LANES — confirming it had no valid lane detection data during the intervention. 7At 23:51:17.755 UTC (335 milliseconds after activation), the system logged LSS_STATE_ABORT — the system cancelled itself mid-intervention. 8During the 335-millisecond intervention, the vehicle's steering angle reached -16.79 degrees leftward and lateral acceleration measured +1.200 m/s² leftward — both confirming the vehicle was pushed into the oncoming lane. 9The driver responded with the largest steering torque (-5.08 Nm rightward) and largest rightward steering angle (+19.50 degrees) recorded in the entire telematics file — confirming he was actively attempting to recover. 10 The head-on collision killed both him and the driver of the oncoming vehicle. We requested additional telematics data from Tesla through the Tesla app. A forensic expert has examined the vehicle's ECU motherboard— missing critical fields including continuous yaw rate, high-resolution steering data, ELK steering commands, and lane detection confidence scores. A subsequent request for additional data produced an error message and Tesla has not provided further data. This crash is the exact behavior under PE25012. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The high voltage battery on my 2021 Tesla Model 3 Standard Range suddenly failed without any prior warning or gradual degradation. The vehicle was consistently achieving approximately 180 miles of range per full charge. Overnight, the battery charge was restricted to approximately 30% capacity, reducing usable range to roughly 30 miles. No warning signs or symptoms appeared prior to this failure. The failure was sudden and immediate. The vehicle displayed the alert "Maximum Battery Charge Level Reduced / OK to Drive, Schedule Service." The battery has been confirmed by a Tesla Service Center as having an internal fault. The only remedy offered by Tesla is full battery replacement at a cost of approximately $9,000 to $14,000 depending on the option selected. This failure poses a safety risk as the severely limited range can result in the vehicle becoming stranded unexpectedly, particularly during highway driving or in areas without nearby charging infrastructure. The failure occurred approximately 6 months after the battery warranty expired with no prior indication of degradation, suggesting a potential defect in the battery unit. The vehicle has been inspected by a Tesla Service Center and the fault has been confirmed. The component is available for inspection upon request.

My steering suddenly got extremely stiff on the highway while driving. There was a warning that assist will be reduced but no assist was present. I had to use all my strength to turn the steering and pulled into a parking lot with great difficulty. Then I reset the main computer and the power steering was functional again. I was lucky since the traffic was moving slower than usual but it could have been very dangerous and was a major safety concern.

On July 1, 2026, the vehicle was serviced by the manufacturer for GPS and camera malfunctions, and the vehicle computer was replaced. On the morning of July 2, 2026, during the first use of Autopilot after that repair, the vehicle experienced repeated serious driver-assistance malfunctions over a short period while traveling on a highway. While Autopilot was engaged, the vehicle repeatedly moved/steered toward the center of the road and near the path of a truck in an adjacent lane. The truck nearly struck the vehicle. The driver had to manually intervene to maintain control and avoid a potential collision. Video of the incident is available upon request and shows the truck and manual intervention. The vehicle was returned to the manufacturer service center the same day. The service center reviewed logs, performed an inspection/test drive, and stated that no hardware faults or issues were found and that the test drive was normal. However, the incidents were intermittent, occurred during highway Autopilot use, occurred the morning after a computer replacement related to GPS/camera systems, and were captured on video.

I was driving my car on full self driving. I press the brake to stop full self driving the car immediately accelerated and caused a crash.

The contact owns a 2021 Tesla Model 3. The contact stated that while the vehicle was set to Self-Driving Mode, the vehicle suddenly stopped abruptly without the brake pedal depressed. The contact depressed the accelerator pedal immediately to continue driving. The vehicle was taken to the dealer three times. The dealer reset the mirrors and sensors; however, the failure persisted. The vehicle had not been repaired. The dealer suggested that the contact purchase another vehicle. The manufacturer was not made aware of the failure. The failure mileage was unknown.

This is my fourth high voltage battery failure on this vehicle. Battery replacements occurred at approximately 13,000 miles, 60,000 miles, 96,000 miles, and now at 121,000 miles. The first failure occurred at 13,000 miles on a nearly new vehicle. During the second replacement a Tesla service technician verbally stated that 'the refurb process has vastly improved since your last battery' before retracting the statement when questioned, strongly suggesting refurbished units were installed in a vehicle under original warranty. Tesla has declined to cover the most recent failure citing warranty expiration, despite this being a documented recurring defect that originated well within the warranty period. The vehicle is currently inoperable due to high voltage battery failure. I was around 40 days outside of warranty with this last failure.

The outside part of the glove box is coming off. It could prevent air bags from working properly. It seems like the O ring glue holding it together has failed. It is available for inspection upon request. The issue is well known and is documented online. The issue has in the past been inspected by the manufacturer and requests an approximate $400 from the customer to fix the issue.

The forward-facing camera and Autopilot computer system on my 2021 Tesla Model 3 has failed. The dashboard first showed intermittent warnings that "Automatic Emergency Braking is currently unavailable" and "Adaptive headlight features are unavailable." Over several weeks the problem worsened from intermittent to constant, and the vehicle progressively lost its forward road visualization and all active safety features. Using the vehicle's Service Mode diagnostics, the Autopilot computer's Primary (A) processing node reports a "CRITICAL" status. The fault log records repeated alerts including dasMIA (driver-assistance system not responding), aebFault (automatic emergency braking fault), and fisheyeCamInitFault and fisheyeCameraStreamExit (forward camera initialization and stream failures). The cameras themselves are physically clean and unobstructed. Safety risk: the failure disables Automatic Emergency Braking and forward collision avoidance, lane-keeping/driver assistance, and the adaptive auto high-beam headlights. AEB is a critical crash-avoidance system; losing it leaves the vehicle unable to brake automatically for an imminent collision, and the loss of adaptive headlights reduces nighttime visibility. A Tesla service center inspected the vehicle, confirmed the diagnosis, and determined the Autopilot computer — a sealed, solid-state control unit — had failed and required full replacement at approximately $3,400. The vehicle is well under 50,000 miles. This failure appears consistent with the same car-computer power-component shorting failure for which Tesla issued a recall on its newer model-year vehicles. The vehicle and the failed component are available for inspection on request. The vehicle has not been inspected by police or insurance.