2015 TESLA MODEL S Complaints

Tesla front right hand lower forward link failed at the ball joint (aluminum casting spilt open) Part #1041575-00-A, FRT FORE AWD LCA RH, Made in Canada. This happened while backing up on flat pavement without warning. The car has been well cared for, garaged, never damaged or abused and has less than 52K miles. It could have caused a life threatening accident if it would have happened at speed.

The front trunk flew open without any warning and smashed the front windshield. We could not see. We never received any info on recalls.

The contact owns a 2015 Tesla Model S. The contact stated that while driving at an undisclosed speed, the limited steering warning light illuminated, and the power steering was inoperable. The contact was able to take the next exit to find a safe location on the side of the roadway. The contact reset the computer and the power steering became operable. The vehicle was taken to the dealer and the vehicle was being inspected. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 160,000.

In 2016, approximately 18 months after purchasing my Tesla Model S, I was driving to work and brushed a curb on a tight city street. Upon arriving at my office parking garage, as I was parking and turning the steering wheel sharply to park in a space, my front right wheel fell off and the axle completely sheared off. Tesla blamed the incident on my curbing the wheel, which only caused light damage. However, more and more reports have come out recently (including this article: [XXX] ) which suggests that Tesla has known defects they are denying and blaming on customers. Not only did this cost me money out of pocket (more than just my deductible), but my insurer had to pay the full amount. Tesla admitted no fault and made me & insurance pay the full amount. I have multiple photos, but the Upload feature on this site is NOT working so I am unable to upload them but can provide them later as needed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The Model S, which was bought in 2015, had a sudden acceleration while I was trying to park near the entrance gate of the parking lot. The accident happened on May 25, 2023. Fortunately, nobody got hurt and the car was totaled. I feel strongly that this should be investigated, as this can be a very serious public safety issue. It was inspected by the insurance company. There were no warning messages prior to the failure.

The contact owns a 2015 Tesla Model S. The contact stated that while he, his wife, and his son were in the vehicle he had begun veering right pulling into the driveway, at approximately 5 MPH, he had begun slightly releasing the brakes when the vehicle suddenly accelerated at accelerated high speeds. The contact immediately depressed the brake pedal however the vehicle speed continued to accelerate. As a response, the contact attempted to maneuver the vehicle to avoid crashing into the garage. The contact crashed into a nearby tree, jumped the curb, and became airborne crashing into the side of the home. The driver's side of the vehicle crashed into the side of the home where the laundry room was located ricocheting hitting the kitchen and bedroom windows and eventually coming to a stop. Due to the home being on a slope, the vehicle ended up falling into a nearby embankment after coming to a stop. All air bags deployed. The vehicle was towed. The contact was informed by insurance the vehicle would more than likely be totaled however this had not been confirmed. A police report was filed. The contact received emotional distress, cuts, and bruising to their hands. arms and forehead. The contact also suffered from back pain. The contact's wife sat in the rear on the driver's side and received emotional distress, trouble breathing, bruising on their face, and bleeding in the mouth. Their wife also received neck, back, and head pain. The contact stated that their wife ended up falling to the floor of the vehicle as a result of the crash. The contact's son sat in the rear on the passenger's side and received emotional distress, and back and neck pain. All persons received medical attention on-site, such as cleaning the wounds and icing any bruising. They were advised to seek additional care, however, have not been able to do so as of yet. The crash caused damage to the wall and flooring structures, electricity, and water systems in the home. The vehicle had not been taken to the dealer. The cause of the failure had n

The hood (frunk) lid disengaged while driving at highway speed and obstructed the windshield. I had to make an emergency exit. The car did not indicate that the latch was released and it did not slow as the manufacturer claims will occur with this problem. I was not notified of the known recall for this defect. As of now, Tesla collision is not taking responsibility and sent me to a third party for repair of the hood.

While driving on the freeway, I thought I heard a rattling from the sunroof, and so I cracked the sunroof to 12% open, and then closed it again. The moment the sunroof closed, smoke with an electrical burn smell began billowing in through the air vents in the front of the car. We immediately opened the car windows to allow fresh air and exited the highway. Smoke continued to pour into the cabin while I pulled the car to the side of the road in a residential neighborhood. The car was parked within ~2 minutes of the smoke initiating. During this time, there were no warnings or hazards that I noticed on the dashboard. My family grabbed their immediate belongings and got out of the car, while I turned on the hazard lights, and also then exited the vehicle, popping the trunk of the car and the frunk to allow smoke to dissipate. The smoke didn’t seem to decrease after pulling to the side, nor opening and venting the car. After being at the side of the road for probably 1-2 minutes, a visible fire sprung up at the intersection of the hood/front windshield at which point I called 911. The fire quickly spread to consume the hood and cabin of the vehicle. Multiple explosions from the vehicle were seen and heard, sounding like gunshots at times, drawing many concerned neighbors from their homes. By the time the first responders arrived, the front of the car and cabin were largely consumed down to the metal framework, and the trunk had fallen shut and was also on-fire.

Driving my car and it completely gives out in the middle of traffic without any warning or alter almost causing an accident. When asked about the absence of alert they said I may or may not get one and I should be lucky it just cut off (randomly in traffic mind you) because if it didn’t it would’ve burst into flames. Being the Rear Drive Unit is the second most important part of the vehicle an alert should be given 100% of the time as no alert could cause injury to myself or other drivers. This means there are other Tesla drivers out there with a probable chance of their randomly car stopping without any control of the vehicle endangering lives. This oddly happens 60 days outside my 8 year warranty when I haven’t any issues at all and receive alerts for everything down to my fob key being low on battery. In addition the whole time they were just trying to convince to get a new one because they just happen to be running a limited time promo that I can transfer my free supercharging to a new vehicle if I purchased. A lot of people have reported (down to the day) of their car dying suddenly after warranty but no avail Tesla says they won’t goodwill repair my vehicle although I could’ve died or been seriously injured.

1)MCU1 flash memory failure in production from 2012 to 2018, part is available, but would require downing the car to remove/replace. 2)The symptoms of this failure include the loss of indicated gear state and reduced driver visibility from the loss of rearview camera, defrost/defog and exterior signal lighting which increases the risk of an accident. Driver display is black or booting up slowly during this time and the car can be put into gear and driven prior to the display showing DNR gear state making it a safety risk to anyone walking near the vehicle if it was accidently put into gear. 3)Issue was confirmed by Tesla and was told an update to MCU2 hardware at $2250 was needed at the customer (my) expense. The vehicle was under a full Tesla warranty, so I refused and asked them to fix this issue. Tesla Service cleared/freed up some memory but said the issue would return unless I paid to update to MCU2 hardware. The issue has returned as they stated. 4)Yes, by Tesla Service and Tesla Engineering. Both confirmed that this was a known issue with the MCU1 hardware in production from 2012 to 2018 and recommended that I (the customer) update the vehicle to MCU2 hardware for $2250. 5)There are no warning lamps or messages to inform the operator of an issue. Only the black driver display, but that doesn’t prevent the operator from putting the vehicle in gear. The symptoms start with slow driver display boot times and progressively get worse over time losing the rearview camera, defrost/defog and exterior lighting controls. The display lag becomes enough to be able to accidently put the car in drive or reverse without displaying indicated gear state on the dash making it a safety risk to anyone walking near the car.