2017 TESLA MODEL X Complaints

Reproducible and sudden loss of indicated driving range at low state of charge (SOC) for 6 months. First documented occurrence on 9 September 2025 during my final service visit while the vehicle was still covered under Tesla’s 8-year unlimited-mile high-voltage battery warranty, at which time no corrective action was taken. After repeated documented low-SOC range collapses, back to service on 13 November 2025. Tesla acknowledged the fault, verified the condition with diagnostics and customer provided screenshots, and stated that CAN log data indicated the Battery Management System (BMS) was not calculating SOC correctly. Tesla replaced the BMS assembly under warranty as a continuation of the original issue and advised that the vehicle would need to be driven and charged for recalibration. Following this repair, I completed multiple full charge cycles to 100% and allowed time for recalibration. Despite this, the issue persisted with 100% reproducibility, with rapid loss of available range after driving and then parking when the vehicle indicated approximately 14–17 miles remaining. This condition resulted in a near-stranding event involving my family, including three young children, due to the unexpected loss of usable range without warning. I returned the vehicle again on 10 December 2025 to the Tesla Service Center in El Paso for the same unresolved issue. Tesla declined to perform low-SOC diagnostic or drive-down testing, instead stating the behavior was normal and required further recalibration despite prior calibration attempts and a failed warranty repair. Tesla has since stated that the vehicle is now out of warranty and has attempted to reclassify this unresolved condition as goodwill rather than treating it as a continuation of the original in-warranty defect. This condition presents a safety risk due to sudden and unexpected loss of usable driving range at low SOC, creating a risk of vehicle stranding.

During home charging using 40A, the 220 volt UMC connector started smoking and was melting. The charging appeared unaffected, and I caught it before it caught fire.

Power Steering Assist stopped working while on the road. A couple days later, power steering stopped working completely.

The autopilot ECU failed on my car per Tesla. There was no warning on the car that my safety features were disabled. This is also reported online as a common issue and Tesla is charging $2k to repair a safety computer. The computer was advertised as two chips as a failsafe but that was not the case as both failed on my car. I suspect this software updates broke the computer as well and not at fault from the customer

The contact owns a 2017 Tesla Model X. The contact stated that while driving at an undisclosed speed, the messages “Air Suspension Unable to Raise” and “Functionality May Be Restored on Next Drive” were displayed. The vehicle was not diagnosed or repaired by an independent mechanic or a dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 53,000.

I am reporting a safety concern related to the suspension system in my 2017 Tesla Model X. The front tires are rubbing against the wheel arch liner, especially when turning or driving over uneven terrain. I have not made any aftermarket modifications, and the vehicle has been maintained in accordance with Tesla’s recommendations. This issue appears to match the known problem involving front suspension fore link failures documented in NHTSA investigations and prior complaints for 2016–2017 Model X vehicles. While I have not experienced a complete suspension failure, the current symptoms are consistent with reported cases where the fore links weaken or fail, causing the wheel to shift and contact the fender liner, leading to tire damage, unusual noises, and potential safety risks. I have reported this to Tesla, but they have not acknowledged this as a known issue for my VIN. However, NHTSA previously identified over 400 instances of similar failure and recommended that Tesla expand their service bulletin to include more vehicles. This is a critical safety concern as it can lead to premature tire wear, loss of control, and further suspension failure. I am requesting that NHTSA review whether Tesla should issue a recall or cover this repair under a broader service campaign.

This is the THIRD YEAR in a row that the Suspension System on this vehicle has failed. This seems like it should be a basic feature of any vehicle - that it should have proper shocks and suspension. The problem is the repair this time is estimated to be at $4000, when we have already had this repaired twice for several thousands of dollars. We drive this car very gently, so there is not an issue of us abusing the vehicle. Also, in China, Tesla was forced to recall vehicles over this same issue: Tesla recalls nearly 50,000 Model S and X cars in China over faulty suspension We would like to know if any recalls will be issued.

Tesla Model X are already known to wear out the rear tires on the inside edge due to excessive negative camber, or wheels tilting inwards from the top. Lowering the suspension setting makes the wheels tilt in even further! This causes more the weight of the car to rest on the inner shoulder of the wheel. Driving this way quickly wears down the inside edge of the rear tires which can cause a sudden and unexpected dangerous blowout

The second-row seatbelt in my 2017 Tesla Model X does not retract, preventing proper restraint of a passenger. Tesla acknowledged the issue but refused to repair it, stating the vehicle is out of warranty. This is a failure of a federally mandated safety system and a clear safety hazard under FMVSS 209. I’m transporting children in this vehicle and cannot rely on this seatbelt to function.

The Monitor Screen in the middle of the car is not malfunction. It's not working. All the panels on the steering are also not work. the honk is not working. Nothing is working. It could be due to the internet connection.