2022 TESLA MODEL Y Complaints

I am writing to formally raise a serious concern regarding the functionality of Tesla’s Full Self-Driving (FSD) system. On May 11th, while the vehicle was operating under FSD, I experienced an unexpected disengagement of the system, which then reengaged on its own without any input from me. This erratic behavior caused the vehicle to hit the garage door and resulted in a crash.

While in Full Self Driving mode in my Tesla, it was making a right turn into a parking lot when it suddenly violently accelerated. Before I could gain control it crossed the parking lot entrance, climbed the curb, and came to rest on a lawn in front of a business. Luckily no one was hurt. It appears the car will be totaled by the insurance company at the completion of their investigation.

Model Y (VIN: [XXX]). On XXX, I brought my vehicle to Tesla Service for replacement of the front wheel hub assembly and paid approximately $1,000 for the repair. Shortly after picking up the vehicle, I noticed abnormal knocking and clicking noises while turning the steering wheel. Because I was concerned about the safety of the vehicle, I sought a second opinion from an independent repair facility. On XXX, the independent shop inspected the vehicle and found that two wheel hub mounting bolts had not been properly tightened and that one mounting bolt was completely missing. The repair invoice states that the vehicle was being operated in an unsafe condition and that continued operation could have resulted in wheel hub failure and a serious accident. The shop corrected the condition by replacing the missing bolt and properly tightening the wheel hub assembly. I incurred an additional expense of $284.47, which would not have been necessary had the original repair been completed properly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

When exiting the driver seat of the vehicle my left arm gets caught in the hinge of the back door. This has happen before. This time my arm was bruised bad and shoulder painfully wrenched. The pain was so bad I thought my arm was broken.

The heat pump failed after experiencing temperatures below 10 degrees fahrenheit. There was no warning until after the failure, when I received a notification that the climate system needed maintenance. All heating/cooling, including defrosting/defogging the windshield, is inoperable. The service center confirmed that this is a heat pump failure and requires a replacement of the entire system, and a Tesla employee indicated that this is a common issue in the first 6-9 months of this cooling system design. This is well documented across many forums, and there is a class-action lawsuit in Quebec, Canada related to this failure.

Bolts for front lower lateral links in suspension backed themselves out over time, eventually causing the suspension to suffer a total collapse and trigger a complete loss of steering authority.

On Feb 25, 2026 My 2022 Tesla model Y with only 25k miles on it suddenly stopped knowing where it was and almost drove me into a ditch. All cameras stopped working and the gps was stuck in the same wrong location. (Service Mode showed Primary DAS ECU shows "AP IN COREBOOT" and "Status: INIT." Secondary B shows nominal. Features unavailable. GNSS shows 0 satellites in open sky.) Tesla service said I was outside of warranty and “There is an internal processor issue with your autopilot system that will prevent updates from installing. The only solution is replacing the computer on April 9, 2026, 12:22,” I had had other computer related issues I brought up during regular service visits but weren’t recorded and I was told software updates would fix such as: delayed rearview camera upon startup, navigation volume resetting, headlights staying on for extended periods after exit, and lockout issues. I asked Tesla to document the specific failure codes which they never sent. They said “Tesla diagnostics are showing the primary Autopilot computer is not booting properly, which is preventing cameras, software updates, and related systems from functioning. Because the computer is not initializing, a firmware reinstall will not complete successfully. At this point, replacement of the computer is the required repair to restore normal functionality.” My car had a safety recall during its service appointment that they could not install software for unless I paid $3200 to replace computer. I had total loss of rearview camera (FMVSS 111 violation) and loss of Active Safety Systems (AEB/FCW), but Tesla refused to repair a federally mandated safety defect if I didn’t pay the full repair cost.

While driving, the vehicle displays a critical “Air pressure in tires very low — pull over safely” alert. When I pull over and inspect, the tire pressure is normal and there is no flat. The alert clears on its own after driving a few more miles. The vehicle has been serviced four times for this issue between February and May 2026 at Tesla service centers in Austin TX, Flower Mound TX, San Diego CA, and Los Angeles CA. The tire pressure monitoring sensors have been replaced three times (rear left twice, front left once). On the May 7, 2026 San Diego service visit, the technician documented the root cause as a low voltage issue with the sensor system. The issue continues to recur after each repair. A false critical safety alert that instructs the driver to pull over creates a safety risk because it trains drivers to distrust real alerts, and pulling over on highways carries its own risk.

2021built -2022 Model Y rear doors manual release door cable is really hard and impossible without tool to access. first removing the rubber pad is annoying because there is no lip sticking out to grab and remove easily, then it comes to the small plastic access to the manual door release cable, without tools it’s impossible to open, it would destroy finger nails and get cuts around fingers trying to open it. even after getting open the small access trim is still really hard to access the cable itself, cable is far from reach and not easy to grab and pull. access door is way to small to use 2 fingers. there’s no way people can get out in time not even for kids, i know 2023 model Ys have better rear door panel design to access the cable, Tesla need to have this replace ASAP.

The front driver-side lower control arm bolt completely fell off the vehicle while in motion at 5pm in a parking lot. The failure caused the front suspension to immediately collapse, resulting in the front driver side of the vehicle dropping and resting directly on the wheel. The failure was witnessed and confirmed by the roadside assistance tow truck operator. The operator had to temporarily jack up the car and fasten the bolt back into the control arm just to safely load the vehicle onto the tow truck. The vehicle is currently awaiting formal inspection and repair by an auto repair shop. The vehicle and the detached bolt were inspected at the scene by the tow truck operator dispatched through my auto insurance. An initial claim was reported to my auto insurance provider. It has not yet been inspected by Tesla yet. There were no warning lamps, error messages, or prior symptoms. The failure happened suddenly and without warning; I simply heard a loud noise, felt the vehicle physically shift and drop to the ground.