2003 TIFFIN ALLEGRO Complaints

SUDDEN LOSS OF BRAKES ON A DOWNHILL GRADE. HAD TO PULL TO SHOULDER AND SCRAPE ALONG UNTIL SLOWED ENOUGH TO STOP WITH PARKING BRAKE. CALIPERS FROZE CAUSING BOIL OVER OF FLUIDS THAT BURNED BRAKE HOSES AND SENSORS.

TL* THE CONTACT OWNS A 2003 TIFFIN ALLEGRO BAY RV EQUIPPED WITH A WORKHORSE W22 CHASSIS. WHILE DRIVING 65 MPH, THE REDUCE POWER WARNING LIGHT ILLUMINATED AS THE RV STALLED. THE CONTACT WAS ABLE TO RESTART THE RV AFTER SEVERAL MOMENTS. THE CONTACT STATED THAT THE FAILURE WOULD RECUR INTERMITTENTLY ON A REGULAR BASIS. THE RV WAS TAKEN TO A DEALER TWICE AND THEY WERE UNABLE TO DUPLICATE THE FAILURE. THE FAILURE PERSISTED AND THE RV WAS TAKEN BACK TO THE DEALER. THE DEALER THEN REPLACED THE THROTTLE BODY MODULAR BUT TO NO AVAIL. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 28,000. UPDATED 03/07/11*LJ UPDATED 09/16/11

TL*THE CONTACT OWNS A 2003 TIFFIN ALLEGRO 31DA MOBILE HOME WITH A WORKHORSE CHASSIS W22. WHILE DRIVING APPROXIMATELY 60-65 MPH HE ENGAGED THE BRAKES AND HE COULD SMELL SMOKE. HE STATED THAT WHEN THIS HAPPENED HE HAD TO ALLOW THE BRAKES TO COOL OFF IN ORDER TO CONTINUE DRIVING. HE RECEIVED TWO RECALL NOTICES AND WORKHORSE HAD NOT FOUND A SOLUTION FOR THE RECALL REPAIR. THE FAILURE OCCURRED INTERMITTENTLY. THE CONTACT STATED THAT HE WAS THE SECOND OWNER AND THE FORMER OWNER STATED THAT THE BRAKES WERE PREVIOUSLY REPAIRED. HE REFERENCE RECALL NHTSA CAMPAIGN ID NUMBER: 09V110000, SERVICE BRAKES, HYDRAULIC. THE APPROXIMATE FAILURE MILEAGE WAS 28,000 AND THE CURRENT MILEAGE WAS 37,000.

IN 2008 FULL LOSS OF BRAKE FUNCTIONING IN OUR 2003 ALLEGRO MOTORHOME WITH A WORKHORSE CHASSIS GOING UP HILL. WE HAD MOTORHOME TOWED TO SERVICE CENTER. WORKHORSE REFUSED TO TAKE RESPONSIBILITY CLAIMING IT WAS MY HUSBAND WHO HELD THE BRAKES ON TO LONG. HE IS A PROFESSIONAL CEMENT TRUCK DRIVER AND THIS IS NOT THE CASE. THE BRAKE PADS SHOW NO WEAR THEY WERE JUST BURNED WHEN THE BRAKE SYSTEM FAILED. WE PAID TO HAVE ALL BRAKE SYSTEMS REPLACED, BUT NOW ARE AFRAID TO DRIVE THE COACH BECAUSE AFTER RECEIVING THE RECALL NOTICE IT MAY HAPPEN AGAIN AND WE ARE IN FEAR OF OUR FAMILIES SAFETY. WE CONTINUE TO MAKE PAYMENTS ON A MOTORHOME WE ARE UNABLE TO USE DUE TO SAFETY ISSUES WORKHORSE IS UNABLE TO REPAIR. *TR

TL*THE CONTACT OWNS A 2003 TIFFIN ALLEGRO RECREATIONAL VEHICLE. WHILE DRIVING LESS THAN 60 MPH, THE BRAKES FAILED. THE CONTACT DEPRESSED THE BRAKE PEDAL AND IT EXTENDED TO THE FLOOR. HE WAS ABLE TO MANEUVER THE VEHICLE OFF THE ROAD AND CONTINUED TO PUMP THE BRAKES. THE BRAKES FINALLY BECAME OPERABLE AFTER SEVERAL ATTEMPTS. HE LATER RECEIVED A RECALL NOTICE STATING THAT THERE WAS A RECALL ON HIS UNIT. THE REMEDY OFFERED A NEW DESIGN ON THE BRAKING UNIT; HOWEVER, THE PARTS WOULD NOT BE IMMEDIATELY AVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 10,000. UPDATED 06/23/09. *LJ THE CONSUMER STATED THE BRAKES ON THE RV HAVE FAILED TWICE. UPDATED 06/23/09.*JB

BRAKE LOCKUP AFTER HARD STOP BEING REQUIRED. BRAKES WORKED CORRECTLY AND SMOOTHLY FOR OVER 100 MILES, BUT I HAD A SITUATION WHERE HAD I TRIED AND FINISH MY LEFT TURN (TWO LANE HIGHWAY) I WOULD HAVE BEEN HIT IN THE SIDE BY A SEMI-TRUCK THAT DECIDED TO PASS. I HAD THE LEFT TURN SIGNAL ON AND WAS DRIVING SLOW IN ORDER TO MAKE MY TURN WHEN I SAW THE SEMI, AT WHICH TIME I PULLED OVER TO THE RIGHT AND HIT MY BRAKES. I THEN DROVE APPROX. 2-3 MILES TO MY DESTINATION AND THAT IS WHEN THE BRAKES HEATED UP, AS YOU COULD SMELL THEM. *TR

TL*THE CONTACT OWNS A 2003 TIFFIN ALLEGRO RV. WHILE DRIVING APPROXIMATELY 40 MPH ON NORMAL ROAD CONDITIONS, THE VEHICLE FAILED TO SLOW DOWN WHEN THE BRAKE PEDAL WAS DEPRESSED. SUDDENLY, AFTER PUMPING THE BRAKES SEVERAL TIMES, THE VEHICLE CAME TO A COMPLETE STOP. THE ABS WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL AND REMAINED LIT UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION AND THEY STATED THAT THERE WAS BRAKE FAILURE. THE TECHNICIAN REPLACED THE BRAKE SYSTEM; HOWEVER, THE FAILURE RECURRED. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 03V149000 (SERVICE BRAKES, HYDRAULIC;SWITCHES:BRAKE WARNING), ALTHOUGH THE FAILURES WERE IDENTICAL. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 1,800 AND CURRENT MILEAGE WAS 9,600.UPDATED 01/09/09. *LJ UPDATED 01/12/09. *JB

TL*THE CONTACT OWNS A 2003 TIFFIN ALLEGRO BAY. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE PULLED TO THE RIGHT WHEN THE BRAKE PEDAL WAS DEPRESSED. ALSO, THE REAR BRAKES LOCKED UP AND SMOKE APPEARED. THE FAILURES OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY STATED THAT THE FAILURES WERE RELATED TO THE CALIPERS STICKING. THE VEHICLE WAS REPAIRED WITH THE REPLACEMENT OF FOUR CALIPERS. THE FAILURES WERE IDENTICAL TO THE ONES MENTIONED IN THE RECALL; HOWEVER, THE VIN WAS EXCLUDED. THE NHTSA CAMPAIGN ID NUMBER WAS UNKNOWN. THE FAILURE MILEAGE WAS 20,000 AND CURRENT MILEAGE WAS 43,000. *UPDATED 10/20/08 *BF UPDATED 10/21/08. *JB

DT*: THE CONTACT STATED WHILE DRIVING 15MPH THE VEHICLE STALLED TWICE. BOTH TIMES THE VEHICLE WAS TOWED TO THE DEALER WHERE THE FUEL PUMP WAS REPLACED.

DT: 2003 TIFFIN ALLEGRO BAY MOTOR HOME. THE MOTOR HOME LODT POWER AND SHUT DOWN. THERE WERE NO NO POWER STEERING OR BRAKES. WHILE DRIVING UP A HILL THE MOTOR HOME STARTED TO JERK. FOUND A PLACE TO PULL OFF THE ROAD AND THE ENGINE DIED. THIS WAS THE FIRST TIME AND THE SECOND TIME WHILE DRIVING FELT THE SAME TYPE OF MOTION IN VEHICLE, BARELY MADE OFF THE SIDE OF ROAD BEFORE EVERYTHING SHUT DOWN. CONSUMER HAD AN APPOINTMENT TO HAVE VEHICLE CHECKED. *AK