2024 TIFFIN ALLEGRO Complaints

Vehicle sways uncontrollably when passed by a semi. On several occasion it push me into the berm. It is known issue with the Ford chassis the vehicle sits on. We just purchased the vehicle a week ago and asked to return it but the dealer will not take it back. The vehicle is not safe to drive it its current state. To resolve it is going to take a considerable amount of money. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2024 Freightliner S2RV. The contact received notification of NHTSA Campaign Number: 24V669000 (STRUCTURE); however, the part to do the recall repair was not yet available. The contact mentioned that the vehicle was purchased with an open recall. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact had not experienced a failure.

The passenger seating area is contained within a slide out of the motorhome. This slide out crept out roughly two inches during 4 hours of travel. This indicates the slide out was not secured in place. This also makes the motorhome wider and the slide out could continue to move out. There are not warnings or other indicators that this situation existed. The slide out creep is a known issue by Tiffin, and by the part manufacture, Lippert. There are also other reports of the slide out issue on social media. Tiffin has also verbally acknowledged this is a known issue.

The contact owns a 2024 Tiffin Open Road RV. The contact stated that while driving approximately 65 MPH, the driver's side slide out room erroneously activated and extended out. The contact stated that the failure also occurred while the RV was parked and turned off. The contact also stated that shortly after obtaining the RV, it was discovered that hydraulic fluid was leaking from the RV. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The failure mileage was 300.

Similar to recall 22V-273 for older Tiffin Allegro Bays and Open Roads, our 2024 Allegro Bay slide room comes out 6-8" on it's own and has now started coming out while driving. Part supplier Lippert confirms it and says parts are being manufactured to address the problem. This has been an issue since purchase and the dealer, Tiffin and Lippert are all aware. There is no warning that the slide is creeping other than wind noise.

WHen filling the vehicle with gasoline, I observed leaking fuel puddling on the pavement below. I looked under the chassis and saw a stream of fuel coming from where the rubber hose that comes from the gas port ( where you put the nozzle from the pump in) connected to a metal pipe that goes to the gas tank under the vehicle. The clamp that was provided cannot be tightened to make sure that the rubber hose is secure over the metal pipe. The RV was purchased on OCt 27 2023, and this was observed today , Nov 23 2023