2006 TOYOTA 4RUNNER Complaints

THE FRAME AND SUSPENSION SYSTEM IS ROTTING DUE TO EXCESSIVE RUST. IT HAS 117000 MILES ON IT AND RUNS WELL OTHER THAN THE RUSTED OUT FRAME.

I WAS DRIVING MY 2006 TOYOTA 4 RUNNER ON HIGHWAY WHEN FRAME BROKE BY REAR TIRE CAUSING ME TO CRASH INTO THE MEDIAN. I HAD TOWED TOO REPAIR SHOP AND WAS NOTIFIED THAT THE WHOLE FRAME WAS ROTTED FROM RUST AND THE VEHICLE IS NO LONGER DRIVE ABLE. WHAT? IT RAN LIKE A CHAMP AND AND I NEVER HAD ANY PROBLEMS WITH IT. DID NORMAL MAINTENANCE LIFE WAS GOOD. THE ENGINE OUT LASTED THE FRAME. THAT IS JUST CRAZY APPARENTLY THE 2006 TACOMA, HIGHLANDER, AND TUNDRA THAT USED SAME FRAME WERE COVERED BUT TOYOTA SKIPPED THE 4 RUNNER. THE FRAME COMPLETELY SPLIT AND WAS CLOSE IN OTHER AREA. THERE MUST BE SOME RECOURSE.

TL* THE CONTACT OWNS A 2006 TOYOTA 4RUNNER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 2 MPH, AN ABNORMAL CLUNKING SOUND WAS HEARD. THE CONTACT STOPPED TO INSPECT THE VEHICLE AND BECAME AWARE THAT A SECTION OF THE PASSENGER'S SIDE WAS SUBFRAME FRACTURED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC BUT WAS NOT REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 131,000.*DT*JB

WHILE DRIVING MY 2006 4 RUNNER ON THE HWY. THE FRAME COLLAPSED BY THE REAR WHEEL AND I LOST CONTROL AS THE REAR END WAS "WAGGING". TOOK TO DEALERSHIP THEY WERE NOT OPEN OR UP FRONT THAT THIS IS A COMMON PROBLEMATIC DEFECT THAT TOYOTA HAS TURNED ITS BACK ON. THE TACOMA, HIGHLANDER, AND TUNDRA MODELS OF SAME YEAR WERE NOTIFIED AND RECALLED. THE 4 RUNNER OWNERS NOT EVEN NOTIFIED, VERY LUCKY THERE WERE NO INJURIES. TOYOTA NEEDS TO STEP UP AND TAKE OWNERSHIP.

CORROSION AND ROTTING OF THE FRAME. SIGNIFICANT AREAS ROTTING IN RIGHT FRONT FRAME TOWARDS FRONT BUMPER MOUNTING AREAS AND RIGHT REAR FRAME ON FRONT SIDE OF RIGHT REAR TIRE. RIGHT FRONT CONSIDERED A SAFETY ISSUE IN A FRONT END COLLISION. FRONT END VIBRATIONS

THERE IS SIGNIFICANT AND SUBSTANTIAL RUST ON THE FRAME OF THIS VEHICLE. THERE IS MORE THAN ONE HOLE EATEN COMPLETELY THROUGH THE FRAME, ALONG WITH TERRIBLE SURFACE RUST THAT HAS EATEN THE FRAME SO THIN THAT ANY LIGHT TAP CREATES A HOLE COMPLETELY THROUGH. THIS HAS ALSO RUSTED THROUGH THE FUEL TANK STRAPS, AND OTHER VARIOUS SUSPENSION POINTS. THE SERVICE TECHNICIAN AT TOYOTA TOLD ME THE VEHICLE IS NOT RECOMMENDED TO STAY ON THE ROAD, AND DID NOT WANT TO SERVICE THE TIMING BELT DUE TO FEAR THAT OTHER COMPONENTS WOULD EASILY SNAP OFF BECAUSE OF THE AMOUNT OF RUST ALL OVER THE ENTIRE FRAME. THIS VEHICLE IS VERY SIMILAR TO MY 2010 TOYOTA TACOMA, AND SHARES SEVERAL RELATED PARTS AND PIECES. I AM FULLY AWARE OF THE RECALL FOR FRAME RUST ON THE TACOMAS, AND FORTUNATELY MY TRUCK WAS NOT DAMAGED. THIS VEHICLE IS TOO MUCH LIKE THE TACOMA TO NOT HAVE THE SAME CONSIDERATION OF HAVING THE SAME ISSUES. NO VEHICLE, MUCH LESS A VEHICLE ONLY 14 YEARS OLD SHOULD HAVE THIS BAD OF AN ISSUE, AND IT IS A WIDELY KNOWN PROBLEM IN THE TOYOTA ENTHUSIASTS COMMUNITY. THIS IS A NEWER VEHICLE FOR MY WIFE, AND NOW I AM BEING TOLD THAT IT IS TOO DANGEROUS TO DRIVE! FROM THE OUTSIDE OF THE VEHICLE, YOU WOULD NEVER KNOW THERE WAS ANY ISSUES AT ALL. BUT AFTER SEEING THE RUST AND HOLES, THE RUSTED THROUGH FUEL TANK STRAPS, I AM SHOCKED, DISMAYED, AND ABSOLUTELY SCARED TO LET MY WIFE CONTINUE TO DRIVE IT. PLEASE TAKE THE TIME TO REVIEW THESE CASES, AND SEE HOW THEY RELATE AS EXACTLY THE SAME SITUATION AS THE TACOMA AND TUNDRA FRAMES. I HAVE OWNED NUMEROUS TOYOTA VEHICLES THROUGH MY LIFETIME, AND TOYOTAS HAVE ALWAYS BEEN MY FAVORITE AND ABSOLUTELY AMAZING VEHICLES FOR ME. THIS IS DEFINITELY OUT OF THE NORMAL SPECTRUM THAT I CONSIDER WHEN I THINK OF, AND BRAG ABOUT THE RELIABILITY AND ALL AROUND ENJOYMENT I HAVE IN AND WITH MY TOYOTA AND LEXUS VEHICLES. THANK YOU FOR YOUR TIME AND HELP IN THIS MATTER.

I BOUGHT MY 4RUNNER NEW AND HAVE TAKEN METICULOUS CARE OF IT VIA THE DEALERSHIP I BOUGHT IT FROM, DOING AN OIL CHANGE EVERY 5000 MILES. NOW THEY TELL ME THE TRUCK SHOULD NOT BE DRIVEN SINCE THE FRAME HAS RUSTED THROUGH IN THE REAR. THE TRUCKS MAINTENANCE WAS DONE AT PRESTIGE TOYOTA MAHESH NJ 201-669-4525 SERVICE MANAGER IS ROBERT J TEUNISEN

FRAME IS RUSTING THROUGH ,I WAS HAVING WORK DONE AND THE MECHANIC POINTED IT OUT TO ME.

MY FRAME ON MY 4RUNNER IS SHOWING MAJOR SIGNS OF RUST A HUGE HOLE HAS FORMED RIGHT IN THE MAIN FRAME DRIVER SIDE. AND ANOTHER IN THE TRAILING ARM MOUNT ALSO DRIVER SIDE. IF MY TRAILING ARM SNAPPED LOOSE ON A DIRT ROAD IT COULD FLIP THE WHOLE CAR. IT'S ONLY 14 YEARS OLD NOW AND THIS IS WAY EXCESSIVE FOR THAT AGE AS MOST VEHICLES WILL DRIVE IN THE SALT BELT STATES FOR WAY LONGER. AS YOU KNOW THIS ISN'T THE FIRST FRAME ISSUE WITH TOYOTA. THEY REALLY SLACKED IN RUST PREVENTING. I NO LONGER FEEL SAFE DRIVING THE THING BECAUSE I DON'T KNOW WHEN SHE MIGHT JUST SNAP IN HALF OR WORSE IF I GET INTO AN ACCIDENT IT COULD JUST CRUMPLE LIKE A TIN CAN. THIS NEEDS TO BE FIXED. OTHERS HAVE SAID THEIR FRAME COMPLETELY SEPERATED IN HALF ON THE ROAD. THIS COULD KILL PEOPLE. THE PICTURE I PROVIDED IS OLD NOW THE WHOLE HAS WIDENED QUITE A BIT. I HOPE A RECALL HAPPENS SOON OTHERWISE IMNA HAVE TO PATCH IT.

VEHICLE IS SHOWING SIGNS OF CORROSION IN THE FRAME. THIS IS ESPECIALLY APPARENT ON THE WELD POINTS. RUE WILL EVENTUALLY CONSUME THE VEHICLE FRAME THIS MAKING IT UNDRIVABLE.