2019 TOYOTA COROLLA Complaints

The contact owns a 2019 Toyota Corolla. The contact stated that while driving at various speeds, the steering wheel became difficult to turn in either direction. The hazard, power steering, and LDA warning lights were illuminated. The message "Lane Departure Alert Malfunction - Visit your Dealer" was displayed. The contact stated that when the LDA was deactivated, a red power steering warning light was intermittently illuminated. The vehicle was taken to a local dealer, where a battery replacement was performed. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the same local dealer; however, the vehicle was not diagnosed or repaired due to the cost. The vehicle was towed to a local independent mechanic, where it remained for further investigation. The manufacturer was not made aware of the failure. The failure mileage was approximately 1,488.

While the vehicle was parked and powered off, a fire originated inside the driver seat area. There was no collision, no aftermarket electrical equipment installed, and no heated seat or accessory usage at the time of the incident. The vehicle was stationary when the fire began. The fire damage was concentrated within the driver seat assembly, consistent with a suspected electrical failure involving seat wiring, seat-mounted components, or associated harnesses. This is not consistent with owner misuse or external ignition sources. The insurer (Allstate Insurance Company) declared the vehicle a total loss but declined further fire-origin or electrical defect investigation. The vehicle is at risk of being sold or dismantled through a salvage auction, which would destroy critical evidence related to a potential manufacturer defect. The vehicle is currently listed on Copart (Lot# 99091095 highlighted as ‘Run and Drive’) I have completed a Power of Attorney (HSMV 82053) per Allstate requirement, along with a limited conditions notification for evidence preservation however Allstate is refusing to accept the conditions stating their intent to sell it as salvage. This incident presents a serious safety concern involving spontaneous ignition within the passenger compartment. Similar failures pose a risk of injury, death, or property damage, particularly if ignition occurs while occupied. I am requesting that NHTSA review this incident for potential electrical system or seat assembly defects and preserve this complaint as part of any pattern or trend analysis involving Toyota vehicles.

My 2019 hatchback clutch failed Clutch Release Bearing and Slave Cylinder Assembly is leaking. Toyota part # 31400-19027

rattle in transmission. Car hesitates to accelerate randomly leading to unpredictable acceleration sometimes. Transmission is failing.

All 2019-2022 Toyota Corolla 6 Speed Manual Transmission cars are affected. The slave cylinder is a defective part that fails prematurely anywhere between the 20,000-70,000 mile range. The slave cylinder on this car is made out of plastic and is located inside of the transmission, when the slave cylinder fails, it leaks brake fluid all over causing the car to lock into gear and not be able to shift which is a major safety risk when there is no signs of failure. My car locked up in the middle of a busy highway and had to be pushed off the side of the road. Not only is this a safety risk, but since the part is located inside of the transmission, which is not normal, it leaks brake fluid all over the clutch and flywheel, which will all need replacement. The dealership quotes between 4-5 thousand dollars to repair, and is not covered under warranty. Toyota knows that this part is a defective part because the new models received an updated slave cylinder made out of metal, rather than plastic, but no cars have been recalled. The car was towed to my local dealership and it is currently being worked on. The incident was reported to Toyota Corporate and a case was opened to investigate this issue. Every single model made between those years are effected and has caused thousands of people to be left with an expensive repair that is unavoidable.

I believe the break booster on my 2019 Toyota Corolla is defective. This caused my stopping distance to increase significantly, making it difficult to control my vehicle and putting myself and other drivers at risk. There were no warning lamps or messages or other symptoms prior to the start of the issue on October 10, 2025. I quickly took my car to a local mechanic the next day who said I had an issue with my brake booster. To make sure this was the issue I followed up and went to a Toyota dealership for a diagnostic. They initially told me that "all brake systems components were functioning normally at this time" and that all I need to do was to change the break fluid. I did this, but the problem persisted. I then returned to the Toyota dealership for a second diagnostic. This time they noted that the brake master cylinder and brake booster are loosing pressure internally and need to be replaced. When I googled this I saw that some 2019 Corolla (and other hybrid) vehicles were included in a 2019 recall for a brake booster pump that could fail, leading to a loss of braking assist, similar to what I was experiencing. I brought this up with the Toyota brand engagement center. They said there was no recall at this time on file, but that they would put me in touch with a representative who would manage my case (case # 251015000598). The representative would not pick up my phone calls. I was not able to speak with him. After many calls, a different representative spoke with me and told me that the case was already closed and that the assigned representative said he had explained to me why. This is not true as I had not had the chance to speak with him. I am concerned that Toyota has not given my break booster pump due diligence and is dismissing my legitimate safety concern and I would like to report this safety problem to the NHTSA.

Manual transmission intermittent failure to/rough to engage first gear and reverse. Clutch slave cylinder high rate of failure/total failure of manual transmission. Transmission incidents happen at least once per day.

Faulty slave cylinders , that lead to more damage such as the clutch & flywheel and

At approximately 66,200 miles, the slave cylinder on the clutch started failing. It will be dropped off at the dealership tomorrow afternoon for repair, hopefully driven under its own power. The clutch feels spongy and friction point is unusual. This puts others’ safety at risk because the clutch could fail, causing the car to lurch forward from being stopped, and puts my safety at risk because the car could break down at any time when it finally completely fails. There are no warning lamps, just a clutch prematurely failing. This is a very common problem with the manual transmissions in this model. I purchased a Toyota for reliability, and this part should not fail for several hundred thousand miles, if ever. There needs to be a recall on these cars.

I have a 2019 Toyota Corolla hatchback and the headlight went out. Instead of replacing the bulb Toyota has made it so you had to purchase the entire unit which is called a headlight assembly unit and that’s in the thousands of dollars the LED lights are supposed to last the lifetime of the car so it makes it really unsafe to drive at night Currently my passenger side light has gone out and like I said it’s in the thousands to replace it so I’m unfortunately not in a position where I can do that and now my driver side light is starting to flicker and starting to cut out. There’s no way to just replace a bulb you have to replace the entire unit which is in the thousands of dollars it makes it very unsafe to drive at night. And Toyota has stated that the LED lights should last the entire life of the vehicle if not longer.