2023 TOYOTA COROLLA CROSS Complaints

ATTACHMENTS OF PICTURES FOR COMPLAINT NUMBER 11688637. [XXX] [XXX] . 2023 Toyota Corolla Cross The scanned pictures shows all the warning lights displayed on my vehicle. A NEW COMPUTER WAS INSTALLED YET IT CONTINUES TO REFLECT THESE LIGHTS. A NEW SWITCH ASSY, HOSE VENTILATOR, VALVE ASY, OI AND COMPUTER ASSEMBLY. CURRENTLY THE DEALER ORDERED INJECTOR SET, ALONG WITH SWITCH, PUSH. HONESTLY, THE PROBLEM CANNOT BE FOUND, PARTS WILL BE ORDERED CONTINUOSLY. THE DANGER WAS WHEN THE ENTIRE DASH BOARD WENT BLANK, WHILE ON THE HIGHWAY, THE VEHICLE LOST POWER AND THE TRANSMISSION STALLED TO SHIFT GEAR. I PULLED OVER ON THE SIDE OF THE ROAD AND CALLED THE CEO OF TOYOTA IN PUERTO RICO. I EXPLAINED TO THEM MY LIFE IS AT RISK. THEY DECIDED TO GIVE ME A RENTAL UNTIL THE NEW PARTS COME IN. PLEASE INVESTIGATE THIS MATTER. MY VEHICLE HAS A SERIOUS PROBLEM. IT HAS BEEN IN THE SHOP MULTIPLE TIMES FOR THIS ISSUE AND TOYOTA DOES NOT CARE IF I DIE OR LIVE. WHO KNOWS IF OTHER INDIVIDUALS IS HAVING THIS ISSUE. PLEASE INVESTIGATE THIS IMPERATIVE MATTER. THIS VEHICLE WILL BE TWO YEARS IN NOVEMBER 2025. VEHICLE COMPUTERS LAST IN EXCESS OF TEN YEARS. ALL THE LIGHTS BELOW STAYED ON FOR SEVERAL WEEKS. THE TECHNICIAN KEEP REMOVING THE BATTERY FOR RESETTING PURPOSES, WHEREAS ALL WARNING SIGNALS DISPLAYED ONCE MORE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I purchased a brand-new 2023 Toyota Corolla Cross LE on [XXX], in St. Croix, Virgin Islands, selling price, $31, 500.00 Early July 2025, I started the vehicle, and unexpectedly, multiple lights emerged on the dashboard screen per below, Exhibit 1 - Check Engine - Visit your dealer Exhibit 2 -Drive Start Control Malfunction - Visit your dealer Exhibit 3 - Parking Brake Malfunction Exhibit 4 - Secondary Collision - Brake System Malfunction Exhibit 5- Parking System Malfunction The vehicle was taken to Island Toyota on July 5th. The codes were cleared by removing the battery terminal. Two days later, the warning lights reappeared. After the technician performed diagnostic testing, I received a phone call to pick up the vehicle. The total cost of the ordered parts exceeds $2,000, which includes a computer. This vehicle is under warranty, particular vehicle IS NOT TWO YEARS OLD. This vehicle is a LEMON. I spoke with Carlos Rivera, a Customer Service Agent at Toyota of Puerto Rico. I notified him of this matter via phone calls, and he responded. He stated that his department is the warranty department, solely responsible for ordering parts for vehicles with warranties. He advised me to speak Ms Charla Green, the General Manager for Toyota St. Croix. Not quite sure why she never returns calls and is virtually unfeasible to speak with customers is atrocious. The front desk agents seems to be programmed to let you know Ms Green is not available and the supervisor, Ms Francis, seems uninterested in the daily chronicles with ones vehicle. The Entire department running blind while upper management is collecting hefty salaries. When the poor man cries out in distress, it’s a deep yearning for help and reassurance from the workers getting paid to help. While traversing on the [XXX], with a passenger in the vehicle, approximately, on [XXX], the instrument cluster display went BLANK, the vehicle lost power, slowed down, INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552

The contact owns a 2023 Toyota Corolla Cross. The contact stated that while driving 68 MPH, there was an abnormal sound like a gunshot coming from the sunroof. The contact stated there was a huge hole formed in the middle of the sunroof, and air was rushing into the vehicle. The contact discovered a large piece of glass behind her right ear; however, the contact was not injured because of the failure. The contact pulled over at the next rest stop and cleaned out the vehicle. Upon inspecting the glass, the contact discovered several hairline fractures and cracks around the edges of the glass. The contact believed that the failure was caused by excessive pressure and stress placed on the vehicle after extensive hours of driving. The contact stated that while driving for an extensive period at high rates of speed, the contact had to clear her ear passages because her ears were frequently filled with air. The contact notified the dealer and an independent mechanic about the failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 12,000.

On [XXX], at approximately [XXX], I was involved in a major collision in Northridge, California, while driving my 2023 Toyota [Model], VIN: [XXX] . While making a left turn from [XXX] to [XXX], my vehicle was struck on the driver’s side/front area. I was wearing my seatbelt. Despite the severity of the impact and heavy vehicle damage, the airbags failed to deploy. Component/System Failed: Airbag system (sensors and/or deployment mechanism). Vehicle is available for inspection upon request. Safety Risk: My safety was compromised because the airbag system did not activate to protect me from the crash forces. This left my head, neck, and torso unprotected, increasing the risk of serious injury or death. Injuries Sustained: Lightheadedness, neck pain, middle back pain, and episodes of forgetting words when speaking. Currently being evaluated in the Emergency Department. Reproduction/Confirmation: The issue has not been reproduced or confirmed by a dealer or service center. UNKNOWN if this is a recurring defect. Inspections: The vehicle has not yet been inspected by Toyota or a dealer. Police documented the incident, and insurance will inspect. The vehicle is available for manufacturer, NHTSA, or other inspections. Warnings/Prior Symptoms: No warning lamps, error messages, or prior symptoms before the failure. UNKNOWN if sensors or control module registered the crash but failed to deploy. Evidence: Videos and photos show this was a major crash with heavy damage, yet airbags did not deploy. I request a full investigation, disclosure of similar reports, and corrective action/recall if warranted. My legal counsel will also follow up with Toyota INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On [XXX], and again on [XXX], vehicle began beeping while driving on the freeway and flashing the following warning messages: 1) 12-Volt Battery Charging - System Malfunction - Stop in a Safe Place - See Owner's Manual 2) AWD System Malfunction - 2WD Mode Engaged - Visit your Dealer 3) Voltage Abnormality - Steering Power Low - Visit Your Dealer Vehicle shut down and lost power steering while driving on the freeway. My safety was put at risk as I could not easily pull my car over to a safe place due to the car losing power, not turning back on, and power steering turning off. This may have resulted in severe injury or death if I had not been able to eventually pull over. Additionally, the safety of others was put at risk as we were travelling at freeway-level speed, which may have resulted in other vehicles being unable to stop, and consequently crash, if my car had stayed in the freeway lane. Both times I had the vehicle towed to Beaverton Toyota Dealership (Address: 4300 SW Murray Blvd, Beaverton, OR 97005 / Phone: (503) 626-7200) to be inspected and serviced. The first time I was told it was a bad battery cell, which was replaced on 07/26/25. However, the same situation happened after this replacement on 07/27/25. Currently, vehicle is at Beaverton Toyota dealership being inspected. Vehicle was purchased at Wilsonville Toyota (Address: 9155 Boeckman Rd, Wilsonville, OR 97070 / Phone: (503) 582-9040). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I was driving on I-290 toward Chicago when traffic began to slow. I also began slowing down when I was suddenly rear-ended by the vehicle behind me at a high speed. My car sustained significant rear-end damage, including a crushed bumper and a detached exhaust pipe that was dragging on the ground. The other vehicle involved was totaled. Police arrived on the scene and determined the other driver was at fault. While waiting for the tow truck, multiple tow personnel commented that, based on the severity and location of the impact, the airbags should have deployed — but they did not. I did not receive any warning lights, alerts, or messages before or after the impact. I did not hit my head, but it was a real possibility given the force of the crash, and I believe this created a serious safety risk. I purchased this vehicle in large part due to its reputation for safety, and in this situation, I felt unprotected. At this point, the vehicle has not yet been inspected by a dealer or manufacturer, but the police and insurance companies have been involved. I am concerned that the failure of the airbag system to deploy represents a defect or malfunction in the safety system. I am willing to make the vehicle available for inspection if needed.

While driving at a moderate speed (june 7, 2025), multiple critical systems of the vehicle suddenly failed. Both dashboard screens (driver and center display) went black, and numerous warning lights appeared afterward, including oil pressure, engine, lane departure, tire pressure, and airbag (SRS) system malfunction. The vehicle accelerated involuntarily, the brakes did not respond, the steering became stiff, and the airbags failed to deploy upon impact with concrete and metal highway barriers. A "System Malfunction" and "SRS Airbag System Malfunction" message appeared. The police report attributes the crash to a vehicle system malfunction. Two days before the incident (June 5, 2025), the vehicle had been serviced by the dealer, and the electronic screen issue had been reported but not addressed. This failure put our lives at serious risk and demonstrates a catastrophic malfunction across safety-critical systems. Photos and documentation are available, and the vehicle is under insurance and legal review.

If raining you stop in red light the engine is shut off need to wait about 10 minutes and start again why they no recall this problem that dangerous

The contact owns a 2023 Toyota Corolla Cross. The contact stated while stopped at a red light, the contact heard a loud, consistent tone emanating from the vehicle, followed by the message "Low power steering" before the vehicle entered LIMP mode and shut off; however, the contact was able to restart the vehicle. The contact stated that after restarting the vehicle, the vehicle returned to normal functionality. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure but had observed an OBD code related to a failure with the mass airflow sensor. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 54,000.

I was at a red light with my windshield wipers on. I then heard several warning beeps with messages stating "steering power low", battery low, and then the steering locked. I tried to turn the wheel after the last message came up but the steering wheel was locked. I couldn’t accelerate. I had to park the car and turn it off and on again. This has happened twice now and Toyota says it is “fine”.