2007 TOYOTA FJ CRUISER Complaints

FRAME IS ROTTING AWAY JUST AS THE TACOMA FRAMES DID IN THIS TIME FRAME OF MODEL YEAR. AFRAID THE VEHICLE WILL SOON BE UNFIT TO DRIVE DUE TO SAFETY CONCERNS. GAS TANK STRAPS ARE ALSO ROTTING FROM UNDER THE VEHICLE. THIS HAS COME TO LIGHT WHEN I WAS DRIVING DOWN A CITY STREET AND MY GAS TANK STRAP BROKE CAUSING THE TAKE TO DROP FROM THE BOTTOM OF THE VEHICLE

FRAME COMPLETELY RUSTED AWAY FROM BODY OF CAR. ENGINE AND EXTERIOR BODY ARE IN PERFECT CONDITION DUE TO THE RUSTED OUT FRAME TOYOTA CLAIMS THE CAR IS UNSAFE TO DRIVE AND THEY WILL NOT TOUCH IT. SEE ATTACHED . THE FRAME LOOKS LIKE A PASTRY WOULD AS IT FLAKES AWAY IN LAYERS UNTIL THERE IS NOTHING LEFT.

A TOYOTA DEALER INSPECTION OF THE UNDERCARRIAGE FRAME OF MY TOYOTA FJ CRUISER, REFLECTS THAT THE VEHICLE IS NO LONGER SAFE TO DRIVE. THE VEHICLE HAS ALWAYS BEEN MAINTAINED BY THE DEALERSHIP AND IS OTHERWISE IN GOOD CONDITION. THE RUST IS SEVERE IN THE FRAME PILLARS, JOINTS AND ATTACHED COMPONENTS. IN THE EVENT OF AN ACCIDENT, THE VEHICLE WOULD NOT PROTECT PASSENGERS BECAUSE THE FRAME WOULD QUICKLY DISINTEGRATE. THE TOYOTA DEALER STATED THAT UNLESS TOYOTA ISSUES A RECALL THE COST TO REPLACE THE FRAME IS AT LEAST $15,000.

WHILE DRIVING NORMALLY AND LESS THAN 10 MILES PER HOUR, THANKFULLY ON A REGULAR, PAVED, LOCAL ROAD WITH LITTLE TRAFFIC, THE DRIVER SIDE REAR SUSPENSION SPRING SEAT AND STABILIZER BAR ATTACHMENT POINT ON REAR AXLE SUDDENLY, UNEXPECTEDLY, AND WITHOUT WARNING JUST TORE APART AND OFF OF THE AXLE HOUSING TO WHICH IT WAS MOUNTED AND THE RESULTING SHARP AND HEAVY METAL EDGED PARTS COMPLETELY SHEARED OFF A BRAKE LINE RELEASING ALL HYDRAULIC BRAKE FLUID AND CAUSING THE IMMEDIATE LOSS OF ALL NORMAL BRAKING ABILITY. THANKFULLY NOBODY WAS INJURED, BUT THE CAR CAN'T BE DRIVEN AT ALL NOW, BECAUSE IT HAS NO BRAKES AT ALL, OTHER THAN THE MECHANICAL EMERGENCY BRAKE, AND BY USING TRANSMISSION "BRAKING." LOTS OF RUST UNDER CAR SINCE WE BOUGHT IT USED FROM DEALER IN MORRISTOWN NJ, APPARENTLY DUE TO LOW QUALITY STEEL USED IN INITIAL CONSTRUCTION AND APPARENT LACK OF ADEQUATE FACTORY ANTI-RUST TREATMENT OF FRAME AND OTHER UNDERCARRIAGE PARTS. INTERIOR AND PAINTED TOP BODY PARTS SHOW NO RUST ISSUES. HOWEVER, THE UNDERSIDE, IS FULL OF LOTS OF RUST. THIS IS APPARENTLY A WELL-KNOWN, VERY COMMON PROBLEM WITH TOYOTA FJ MODELS. IT IS VERY DANGEROUS, AND IT SHOULD BE ADDRESSED BY TOYOTA IMMEDIATELY! I'M MAKING PLANS TO HAVE THE CAR TOWED TO A LOCAL TOYOTA DEALERSHIP FOR INSPECTION AND POSSIBLE REPAIRS. FINALLY, AS FAR AS I AM AWARE, THIS CAR HAS NEVER DONE ANY SIGNIFICANT OR TAXING "OFF-ROADING."

WHILE UPGRADING TO STEEL BUMPERS FROM THE FLIMSY PLASTIC CRAP MOST VEHICLES COME WITH THESE DAYS, FOUND SIGNIFICANT FRAME ROT. SOMEHOW THE FJ CRUISER IS NOT PART OF THE PREVIOUS TOYOTA RECALLS. I CAN ASSURE YOU THEY'RE AT LEAST AS SUSCEPTIBLE AS THE TACOMAS ET AL. I'M NOW ON THE HUNT FOR AN AFFORDABLE REPLACEMENT FRAME, WHICH SEEMS TO BE MERELY A PIPE DREAM. I LOVE THIS VEHICLE AND WILL DO WHATEVER IT TAKES TO REPAIR IT BUT, COME ON TOYOTA. THIS IS NOT WHAT THE MARKET EXPECTS FROM YOU!

FRAME IS RUSTING & CRACKED IN VARIOUS PLACES. GAS TANK STRAP RUSTED / CORRODED COMPLETELY OFF LEAVING GAS TANK SAGGING IN THE REAR. THIS HAS ALL HAPPENED OVER TIME.

CHASSIS HAS EXCESSIVE RUST. UPPER REAR CONTROL ARM MOUNT ON CHASSIS RUSTED OFF. CAUSING LOSS OF CONTROL WHEN BRAKING. REAR BUMPER SUPPORT HAS HOLE IN FRAME FROM RUST. BODY MOUNTS ARE RUSTING OFF FRAME. BRAKE LINES HAVE RUSTED AND LEAKED FLUID. GAS TANK STRAP MOUNT IS VERY COMPROMISED BY RUST. FRONT RADIATOR SUPPORT EXCESSIVE RUSTING NUMEROUS SOFT SPOTS AND HOLES. MAJOR FLAKING , AND DELAMINATION OF FRAME ALL OVER. TRUCK HAS 98,000 MILE ON IT IT IS A MANUAL 4WD. LOCATED IN MICHIGAN.

2007 TOYOTA FJ CRUISER. THERE IS WIDESPREAD AND SIGNIFICANT RUSTING ON THE FRAME AND DRIVETRAIN COMPONENTS. WELL-MAINTAINED, AND NOT LOCATED IN A SALTY ENVIRONMENT, NOR AN ENVIRONMENT WHERE THE ROADS ARE EVER SALTED. THIS VEHICLE IS UTILIZES THE SAME FRAME AS ANOTHER TOYOTA VEHICLE (4RUNNER), AND THAT VEHICLE WAS INVOLVED WITH THE FRAME-RUSTING RECALL DURING THE SAME TIME PERIOD THIS VEHICLE WAS MANUFACTURED.

THE FRAME OF MY 2007 TOYOTA FJ CRUISER IS HEAVILY RUSTED AND RUSTED THROUGH IN SEVERAL AREAS.

VEHICLE IS SHOWING EXCESSIVE RUST ON THE FRAME AND UNDER-BODY. I HAVE AN OLDER VEHICLE THAT ALMOST HAS NO RUST. RUST ON THE 2007 FJ CRUISER IS MAINLY ON THE FRAME JOINTS AND THE REAR AXLE. CAR WAS DAILY COMMUTER FOR ABOUT 5 YEARS AND THEN BECAME A LEISURE VEHICLE DRIVEN MAINLY ON WEEKENDS AND OUTINGS.