2007 TOYOTA FJ CRUISER Complaints

The contact owns a 2007 Toyota FJ Cruiser. The contact stated that the driver's side seat belt failed to retract, causing the contact to have to manually put the seat belt in place. The contact stated that the failure recurred several times and progressed where the seat belt would not retract. The contact discovered NHTSA Campaign Number: 13V098000 (Seat Belts) and the dealer was contacted, and it was confirmed that the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 191,700. The contact stated vehicle has been repaired, and this case may be closed.

The fj cruiser is a common issue for rot/ rust on the frame of the vehicle, I have clean the frame often during the winter months and my frame is continuously rusting and rotting the frame of the vehicle I have decided to not drive the vehicle till the frame is either replaced or repaired due to the safety concern of driving it on the road, numerous others have same incidents of the holes in the frame due to rust the manufacturer did not put any kind of corrosion treatment on the frame to stop this from happening the frame flexes when accelerating and is not safe for anyone to including my passengers or other people on the road

The contact owns a 2007 Toyota FJ Cruiser. The contact stated that the front driver’s side seat belt retractor and locking mechanism was inoperable, failing to secure the driver as needed. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 13V098000 (Seat Belts). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 100,000.

The gas tank strap rusted so the gas tank was hanging low. I fixed the problem myself

I own a 2007 FJ Cruiser with very low mileage (below 80,000). It has a terrible carriage rust problem. I thought I'd had it remediated, finally, after endlessly searching for someone to address it. Dry ice treatment and undercoating were applied recently. I replaced the wheels and tires, as well. All seemed well and it passed inspection. But, then the power steering started stiffening. So I had that attended to. The mechanic then told me the rack and pinion and a plethora of other issues were happening due to rust and corrosion - at an additional $$$$$$ cost. So far, this summer, I have spent close to $5,000 to resurrect this vehicle. I can't afford to invest anymore or justify doing so. I am looking to sell. But first I am investigating the FJ class-action against Toyota. I understand this class-action was denied in part last year in California. I plan to check any legal status that might still exist. My hope is that Toyota will acknowledge the problem with the FJs, recall and FIX the problem or at least reimburse me all my repair/remediation expenses. I know they won't do anything unless there is a lot of pressure and outcry to do so. Although, my FJ spent the first 16 years of its life in NJ (which many claim is the cause and of course is plausible - I don't disagree but not to this degree), it was not driven that much, garaged and well cared for. I did not really notice the rust issue until January 2021 when I took it to the local Toyota dealership. I think I was taking it there for an oil change. They were surprised that I'd driven it there because the brakes were so bad. I had it towed home and spent the next many months searching for someone to fix it. No one wanted to touch it until this summer 2023. The gentleman who dry iced and coated informed me about the lawsuit. I never received any kind of notice (thus far) from Toyota about any recall. So now I am garnering information and investigating the best I can. My FJ looks brand new except for frame corro

I was driving down the street after filling up my fuel tank. I drove approximately 1/2 mile when I heard a sound, felt a clunk and stopped immediately. My fuel tank was hanging down on the ground. I called AAA and requested a flatbed and to bring a strap. He did not bring a strap and when my truck arrived at the mechanic the fuel tank had completely separated from the vehicle. The other complaint I have is the rusted frame. I purchased this vehicle used. I did not notice that the tube before the rear axle which holds suspension supports to the frame were completely broken off and separated from the rusted out frame that has failed. It has been welding but the rusted frame is very difficult to weld to.

Frame rust prematurely affecting integrity of the rear lower control arm mounts. Back half of frame almost completely rusted through requiring a full frame replacement.

Our 2007 FJ Cruiser when brought in for annual inspection has been deemed unsafe for use due to crack in frame due to corrosion. The vehicle has no other mechanical issues and runs as if new. We invested in 5 new tires and now find ourselves possibly having to purchase a new vehicle. We witnessed all the other Toyota vehicles frames being replaced due to the recall regarding insufficient undercoating and excessive rust. We inquired if our vehicle was included and if there was reason for concern and were told No. We also own a 2010 Prius which we purchased new. We had no reason to question the validity of the answer. Years later we are grateful we did not experience any incident and crack was discovered before one happened. We now want to know why we did not get a replacement as did all the other models.

Rust is inherently bad on these vehicles. The other day i heard a weird noise under my truck driving down the road. As if I flung a rock up and hit a spring or something. To my dismay, I noticed the fuel tank hanging. One of the straps rusted to the point that it broke allowing the fuel tank to droop.

I recently purchased the used 2007 Toyota FJ with 101,000 miles. During maintenance and inspection, it was found that the fuel tank straps are rusted out and need to be replaced. The rear brake lines are rusted out and need to be replaced. The frame is severely rusted out and failing at the factory welds. I was referred to submit a report and investigate filing a class action lawsuit against the manufacturer for negligence, as this is apparently a known issue. I am hoping that the will reach someone that is able to help all the owners with the same issues as this should be recalled and repaired to prevent unnecessary injury or death. This is a huge financial burden for those expecting a quality vehicle that will be safe. Failing brakes, loose gas tanks and weakened frames are recipe for disaster.