2007 TOYOTA FJ CRUISER Complaints

Frame is failing and fully corroded/compromised. Combination of very poor steel Toyota used in manufacturing (during these model years) combined with Toyota’s placement of air conditioning condensation drain above frame on passenger side has resulted in a corroded and corrupted frame with dangerous and deadly loss of structural integrity.

Rusted frame. The factory trailer hitch failed because of frame rot and dropped a travel trailer to the ground while towing. Luckily it did not cause an accident and I was able to get another vehicle to tow the travel trailer. I am part of a Facebook group for FJ Cruiser rusted frame owners. This is a common problem on FJ Cruisers and should have been a recall as Toyota did for similar vehicles of the same years that had the same rusted frame issues.

The frame on my 2007 FJ cruiser is rusting very badly. There are large holes in my frame and I have had one of my rear sway bars rust all the way off. I feel like at any moment my car could just fall apart and cause me to wreck.

The contact owns a 2007 Toyota FJ Cruiser. The contact stated upon inspection, the mechanic discovered that severe corrosion had formed on the entire undercarriage of the vehicle. Prior to the discovery, the contact stated that an unknown part had separated and detached from the vehicle in his driveway due to the corrosion. The dealer then took several pictures of the corrosion on the vehicle. The contact was warned by the dealer to not drive off road or use the vehicle to tow due to the failure. The manufacturer was notified of the failure and offered no assistance. The vehicle was not repaired. The failure mileage was approximately 70,000. Vin was not available.

The back portion of the frame is completely rusted out, has a rot hole, and cracked. It is the same problem that has been happening to similar year model Tacomas, Sequoias, and Tundras. The FJ cruiser now needs to be included in this recall for rusty frame issues. I'm not even in a rust belt state. I'm in Florida. A rear end accident could cause the whole vehicle to collapse and make kill passengers in the back seats. Tons of other complaints filed here. There's a facebook group "FJ Cruiser Rusted Frame Owners Unite". Vehicle has been inspected by insurance for repairs, may just get totaled out as of this writing. No warning symbols or lights.

recently purchased used from dealership. Excessive rust on lower frame and other components (transmission and power steering lines) as well as suspension. This is not a flood vehicle. Initially took it to Toyota for repairs of the lines and trans. The quote was too high, so I took it to local shops for repair. The local shops were surprised by the amount of rust. Trans was fixed but the shops refused to fix other components that attached to the frame because they fear they will cause more damage. Visited several FJ Cruiser forums and frame rust issues are incredibly common with the FJ, to the point where there are class action lawsuits. Toyota needs to step up and fix this issue for FJ owners!

Excessive rust on frame components from inside frame rails. Failure of suspension mounting points at the rear axel. Failure of the rear cross member and hitch due all due to excess rust.

Frame structural rust/ fuel tank strap rust On going problem with this one and many others

The contact owns a 2007 Toyota FJ Cruiser. The contact stated that the vehicle was taken to an independent mechanic to replace the gas tank trunk strap. The mechanic informed him that the undercarriage of the vehicle was extremely corroded and that the vehicle was not safe to drive. The local dealer was contacted about the failure and he was informed over the phone that the entire sub-frame of the vehicle needed to be replaced out of pocket. The vehicle was not yet repaired. The manufacturer was not made aware of the failure. The failure mileage was 81,875.

The contact owns a 2007 Toyota FJ Cruiser. The contact stated that upon taking her vehicle to an independent mechanic for an oil change, the contact was informed that the undercarriage was severely corroded. Due to corrosion, the contact was informed that the vehicle was unsafe to drive. Neither the dealer nor the manufacturer were notified of the failure. The vehicle was not repaired. The failure mileage was approximately 22,000.