2010 TOYOTA HIGHLANDER Complaints

FROM A STOP WITH A TURN IN EITHER DIRECTION ON ANY SERVICE IN ANY WEATHER, AN AUDIBLE NOISE AND JOLTING VIBRATION TELEGRAPHS THROUGH THE STEERING WHEEL. FEELS LIKE A LOOSE PART THAT MAY SEPARATE IN THE STEERING ASSEMBLY AND RENDER THE VEHICLE UNCONTROLLABLE. FIRST RAISED WITH MOMENTUM/ FOWLER TOYOTA OF TULSA 6/14/14 WITH REFUSAL TO REPAIR AS A WARRANTY CLAIM @ 41430 MILES (DEALER WOULD NOT NOTE IN SERVICE CHECK-IN BUT PROMISED TO INSPECT). RAISED AGAIN WITH JIM NORTON TOYOTA THAT WOULD NOT INSPECT WITHOUT THE PAYMENT OF A $100 INSPECTION FEE @ 60459 MILES. NOT SURE OF SAFETY IMPLICATIONS BUT CONCERNED THAT FAILURE OF THE STEERING SHAFT COULD OCCUR. NO REPAIR MADE TO DATE SINCE WARRANTY AND/OR SAFETY ISSUES COULD NOT BE RESOLVED. NOTED SIMILAR COMPLAINTS IN OTHER NHTSA COMPLAINTS FOR 2010 HIGHLANDERS.

TL* THE CONTACT OWNS A 2010 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER TO RECEIVE A RECALL REPAIR FOR NHTSA CAMPAIGN NUMBER: 14V743000 (SEATS), BUT THE REMEDY DID NOT PROVIDE A PERMANENT REPAIR. THE DEALER WOULD ONLY DISCONNECT THE HEATERS WITH COPPER STRAND HEATING ELEMENTS. THE CONTACT HAD EXTENSIVE BACK PAINS AND USED THE FEATURE DAILY TO PREVENT THE BACK PAINS. THE CONTACT INDICATED THAT WITHOUT THE OPTION OF THE SEAT HEATER, SHE WOULD EXPERIENCE BACK PAINS WHILE OPERATING THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE.

OPEN-DOOR WARNING KEEPS POPPING IN THE DASH WHEN DRIVING, AS WELL AS THE LIGHT INSIDE INSIDE THE CAR (CONSISTENT WITH AN OPEN DOOR). THE PROBLEM STARTED AT FIRST AS THE CAR WOULD BE TURNING AT VERY LOW SPEED. IT HAS GOTTEN WORSE OVER THE NEXT 2 WEEKS AND NOW HAPPENS ALMOST ANYTIME THERE IS A BUMP IN THE ROAD, OR WHEN CORNERING, AS WELL AS WHEN HITTING THE BRAKES, EVEN GENTLY. I CHANGED ALL THE DOOR SENSORS BUT IT DID NOT MAKE ANY DIFFERENCE.

DRIVER DOOR LOCK QUICK WORKING. COULD ONLY UNLOCK WITH KEY OR BY CRAWLING OVER PASSENGER SEAT. TOOK TO DEALER AND WAS TOLD IT WAS ACTUATOR. THEY FIXED FOR ALMOST $600. LESS THAN MONTH LATER PASSENGER DOOR LOCK DID SAME THING. CALLED DEALER AND WAS TOLD I WOULD HAVE TO PAY TO GET IT FIXED. LET IT STAY THAT WAY UNTIL MAY 2015. LOCAL MECHANIC FIXED FOR LITTLE OVER $300. ABOUT 2 WEEKS LATER, DRIVER DOOR LOCK WILL NOT UNLOCK AT TIMES WHEN IT WILL NOT, THE KEY NOW WON'T WORK. HAVE TO CRAWL ACROSS PASSENGER SEAT TO UNLOCK I HAVE NUMEROUS COMPLAINTS ON INTERNET ABOUT THIS ISSUE. ACTUATORS NEED RECALLING BB

INFORMATION CENTER IS FLASHING OVERHEADLIGHTS, AUDIBLE WARNING BELL, VISUAL WARNING LIGHTS FLASH ON DRIVERS DISPLAY, UNABLE TO LOCK VEHICLE. THIS IS ALLL DUE TO THE TAILGATE REGISTERING AS OPEN WHEN IN FACT IT IS CLOSED. IF YOU UNPLUG THE SENSOR, IT WILL NOT ALLOW ACCESS INTO OR OUT OF THE REAR DOOR. IT HAS NOW STARTED TO NOT ALLOW THE VEHICLE TO BE LOCKED - SAYING THERE IS A DOOR OPEN (REAR). IF YOU GO AROUND AND INDEPENDENTLY SLAM DOORS ONE AT A TIME AND THEN TRY TO LOCK WITH THE REMOTE AFTER EACH, IT WILL EVENTUALLY ALLOW U TO LOCK AFTER SLAMMING PASS FT. DOOR. THE IS A NOTABLE PROBLEM FOR THIS SERIES AND IS BECOMING QUITE PREVALENT . DEALER SAYS DON'T KNOW WHAT IS CAUSING IT. INDEPENDANT MECHANIC SAY IT IS DOOR ACTUATOR - WHICH IS EXTREMELY EXPENSIVE.

DRIVER SIDE SUN VISOR WON'T STAY IN UP POSITION. HANGS DOWN IN VISION LINE OF DRIVER TALLER THAN 5'. THE REPAIR WILL COST CLOSE TO $200!

TL* THE CONTACT OWNS A 2010 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHEN THE VEHICLE WAS STARTED, THE AIR BAG WARNING INDICATOR ILLUMINATED INTERMITTENTLY. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE IT WAS DIAGNOSED THAT THE PASSENGER SIDE AIR BAG MODULE WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 25,000.

ACCIDENT OCCURRED IN SOUTHBOUND LANE OF I-95 AT THE DILLON, SC EXIT ON 6/14/14. NORTHBOUND TRAILER LOST A TIRE/RIM DUE TO MECHANICAL FAILURE AND IT CROSSED THE MEDIUM AND IMPACTED OUR VEHICLE BLOWING THREE (3) AIRBAGS. THIS MODEL AND YEAR DID NOT INITIALLY HAVE TAKATA AIRBAGS INSTALLED DURING PRODUCTION. IT IS UNKNOWN, TO DATE, WHETHER THE REPLACEMENT AIR BAGS INSTALLED BY GRIFFIN TOYOTA AT ROCKINGHAM, NC WHERE MANUFACTURED BY TAKATA AND POSE A DANGER TO OCCUPANTS IF ACTIVATED. THE TAKATA AIRBAG PROBLEM DID NOT GET PUBLIC ATTENTION UNTIL THE OCTOBER & NOVEMBER, 2014, TIMEFRAME. I CONTACTED GRIFFIN TOYOTA STATING MY CONCERN IN JANUARY, 2015 AND WAS TOLD THAT THERE WAS A POSSIBILITY THE REPLACEMENT WERE MANUFACTURED BY TAKATA AND COULD BE DEFECTIVE. I HAVE SUBSEQUENTLY CONTACTED TOYOTA CUSTOMER SERVICE AND REPORTED SAME (GIVEN CASE NUMBER [XXX]) AND THEM REFERRED ME TO THE LOCAL TOYOTA DEALERSHIP (CHARLES BARKER TOYOTA IN VIRGINIA BEACH, VA). THIS DEALERSHIP CONTINUES TO "STRUGGLE" TO GET THE INFORMATION FROM THE TOYOTA HEADQUARTERS IN CA TO DETERMINE WHETHER THE AIRBAGS SHOULD BE REPLACED (THAT IS, IF TAKATA REPLACEMENTS WERE INSTALLED AFTER THE WRECK) TO ENSURE THE OCCUPANTS SAFETY. PLEASE INVESTIGATE TO DETERMINE WHAT POTENTIALLY DEFECTIVE AIRBAGS (MANUFACTURED BY TAKATA) WERE INSTALLED IN THE JUNE-JULY 2014 TIMEFRAME. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

IN JANUARY OF 2013, I TOOK MY HIGHLANDER INTO A DEALER'S SERVICE DEPARTMENT TO DIAGNOSE A PROBLEM WITH MY DRIVER'S SIDE FRONT AUTOMATIC LOCK, WHICH HAD COMPLETELY STOPPED WORKING AT AROUND 46,000 MILES. THIS MEANS I HAD TO PHYSICALLY PRESS THE LOCK AS NOT EVEN THE KEY WOULD WORK. I HAD TO OPEN THE PASSENGER SIDE DOOR, CRAWL ACROSS THE SEAT, & UNLOCK THE DRIVER'S SIDE DOOR IN ORDER TO GET IN MY CAR. I WAS TOLD BY THE DEALER THAT THE PROBLEM WAS THE DOOR LOCK ACTUATOR, WHICH WENT OUT, & IT WAS NO LONGER UNDER WARRANTY. RATHER THAN PAYING $575 AT THE DEALER, I FOUND A MECHANIC THAT ORDERED THE PART & REPLACED THE ACTUATOR FOR LESS THAN $400. LESS THAN THREE MONTHS LATER, AT JUST OVER 50,000 MILES & ONLY 2.5 YEARS OF OWNING THE CAR, THE FRONT PASSENGER SIDE ACTUATOR WENT OUT. NEEDLESS TO SAY, I HAD SOME WORDS WITH THE DEALER, & THEY AGREED TO DO A ONE-TIME "COURTESY" FIX, REPLACING IT AT NO COST. OVER THE NEXT FEW MONTHS, BOTH OF THE REAR DOOR ACTUATORS WENT OUT. NOT WANTING TO SPEND $800+ TO REPLACE THE ACTUATORS, I DECIDED TO LIVE WITH RISK & ANNOYANCE THIS CAUSED, HOPING THERE'D SOON BE A RECALL. WELL, HERE WE ARE IN MARCH 2015, & AT 87,000 MILES, GUESS WHAT? THE FRONT DRIVER'S SIDE ACTUATOR IS GOING OUT AGAIN. SEARCHING THE WEB FOR THIS ISSUE, I FOUND HUNDREDS OF SIMILAR COMPLAINTS FROM OTHER TOYOTA OWNERS, OVER A VARIETY OF MODELS & YEARS. THIS IS A HUGE SAFETY ISSUE & TOYOTA NEEDS TO RECALL ALL AFFECTED VEHICLES. I CAN COME UP WITH AT LEAST A DOZEN SCENARIOS WHERE THIS ISSUE COULD CAUSE SERIOUS HARM TO THE CAR'S OCCUPANTS. IF I CAN'T GET TO MY CHILD IN THE BACK SEAT BECAUSE I'VE BEEN IN A WRECK & DOOR IS LOCKED; IF I AM CAR-JACKED B/C THE DOOR WOULDN'T LOCK; IF I HAVE TO ENTER THROUGH THE PASSENGER'S SIDE TO UNLOCK MY DOOR AND X/Y/Z HAPPENS... I'VE ALREADY LOCKED MYSELF OUT DUE TO THIS ISSUE (CAR THINKS DOORS ARE UNLOCKED & WON'T WARN ME MY KEYS ARE INSIDE)! HELP! *TR

THE VISOR IS DEFECTIVE AND GETS STUCK IN A 45 DEGREE ANGLE POSITION. A WARRANTY REPAIR WAS MADE, BUT IT HAPPENED A SECOND TIME OUTSIDE OF WARRANTY. ALSO, THE PASSENGER SIDE VISOR DEVELOPED THE SAME PROBLEM, ALSO OUTSIDE OF WARRANTY. BASED ON THE POSITION OF THE VISOR AT A 45 DEGREE ANGLE, IF THERE'S AN ACCIDENT THE HEAD OF THE DRIVER OR PASSENGER WILL GO RIGHT INTO THE BRIM OF THE VISOR. THIS IS OBVIOUSLY VERY DANGEROUS AND SHOULD BE ADDRESSED BY TOYOTA. I BELIEVE TOYOTA NEEDS TO ISSUE A RECALL IMMEDIATELY BEFORE SOMEONE GETS SERIOUSLY INJURED OR WORSE. *TR