2004 TOYOTA HIGHLANDER Complaints

I PURCHASED A TOYOTA HIGHLANDER 4DR 4WD 4ECT AS A PREVIOUSLY OWNED VEHICLE WITH A PREVIOUSLY OWNED VEHICLE WARRANTY. AFTER OWNING AND USING THE VEHICLE FOR A FEW MONTHS WHILE DRIVING IN A TRAFFIC SITUATION, THE RIGHT SIDE REAR BRAKE SUDDENLY LOCKED UP INTERMITTENTLY ACCOMPANIED BY SWERVING, BY PANEL VSC LIGHT FLASHES AND AN AUDIBLE WARNING. THIS SITUATION FORTUNATELY OCCURRED NEAR OUR RESIDENCE ON DRY PAVEMENT. BY DRIVING VERY SLOWLY WE MANAGED TO GET THE VEHICLE TO A SAFE LOCATION. IT WAS THEN TOWED TO A LOCAL TOYOTA DEALER WHERE IT WAS INSPECTED AND THE FOLLOWING DIAGNOSIS OR SIMILAR WAS PROVIDED: CUSTOMER STATES THAT THE VSC LIGHTS ARE COMING ON AND THE BRAKES ARE LOCKING UP, YAW RATE SENSOR IS OUT OF CALIBRATION. RECALIBRATED YAW RATE SENSOR. THE VEHICLE WAS RELEASED TO US AS REPAIRED. THE PRECISE SAME VSC FAILURE SITUATION OCCURRED ON OCTOBER 11TH OF THIS YEAR AND AGAIN WE WERE LUCKY TO HAVE BEEN IN A REASONABLY SAFE LOCATION AND DRIVING UNDER GOOD ROAD CONDITION WHEN IT HAPPENED. THE VEHICLE WAS PICKED UP AND TOWED AGAIN TO THE DEALER FACILITY FOR ANALYSIS AND REPAIR. WE RECEIVED THE DIAGNOSIS: ?ELECTRICAL REPAIR, CUSTOMER STATES THAT THE VSC LIGHTS ARE COMING ON, AND THE BRAKES ARE LOCKING UP, YAW RATE SENSOR IS OUT OF CALIBRATION. RECALIBRATED YAW RATE SENSOR?. I WAS TOLD BY TELEPHONE THAT ?THE PREVIOUS REPAIR LASTED TWO YEARS?. ANY REASONABLE PERSON WOULD CONSIDER THAT THE POTENTIAL USEFUL LIFE OF THIS VEHICLE SHOULD EXCEED TWO ADDITIONAL YEARS. FURTHERMORE, THE FAILURE COULD POTENTIALLY REOCCUR IMMEDIATELY. AFTER BEING TOLD IT WAS TEST DRIVEN AND PRONOUNCED SAFE TO DRIVE I THINK THAT THIS IS AN UNSAFE SITUATION WAITING FOR ANOTHER EVENT TO OCCUR AND THAT AN ACCIDENT COULD RESULT FROM ANOTHER INSTANCE OF THE VSC SYSTEM FAILURE. THE PROBLEM WAS NOT PROPERLY LOCATED OR PROPERLY REPAIRED IN EACH OF THE TWO OCCURRENCES. A PROPER REPAIR OF THE VEHICLE AFTER THE FIRST EVENT WOULD HAVE PREVENTED THE SECOND. *TR

OUR SUV STARTED SERIOUSLY SKIDDING ON THE ROAD SURFACE WHILE DRIVING, CHECK THE TREAD AND FOUND INSIDE AND OUTSIDE OF TIRES EDGES BALD, AND CENTER OF TIRE ALSO POOR TREAD. SO FOR THE SAFETY OF MYSELF AND FAMILY I HAD ALL 4 TIRES REPLACED. *TR

2004 TOYOTA HIGHLANDER BRAKES ENGAGED WHEN ACCELERATOR WAS DEPRESSED. CUSTOMER STATES THAT HE WAS IN A PARKING LOT HIT THE ACCELERATOR AND THE BRAKES APPLIED, AND THAT MADE THE ENGINE STALL. HE WAS UNABLE TO START THE VEHICLE. *KB THE DEALER FOUND THE STEERING ANGEL SENSOR WAS NOT OUT PUTTING CORRECTLY WHICH CAUSED THE VSC TO ACTIVATE. *JB

2004 TOYOTA HIGHLANDER WITH AWD AND 4 CYL. VEHICLE IS LEAKING TRANSMISSION FLUID AT 67,500 MILES. DEALERSHIP SAY THAT TOYOTA WILL NOT HELP WITH THIS PROBLEM AS IT AS THE WARRANTY EXPIRED AT 60,000 MILES. I BOUGHT THIS VEHICLE DUE TO THE EXPECTED RELIABILITY OF A TOYOTA PRODUCT, BUT IT APPEARS THAT TOYOTA DOES NOT STAND BEHIND THEIR PRODUCT. MY OTHER VEHICLE IS A LEXUS RX 300 WHICH I LOVE, BUT I WILL BE HARD PRESSED TO BUY ANOTHER TOYOTA PRODUCT IN THE FUTURE AFTER THIS EXPERIENCE. *TR

VARIATION IN BRAKE PRESSURE. SOMETIME BRAKES FEEL FINE AND BRAND NEW AND OTHER TIMES, BRAKE ALMOST GOES TO FLOOR. *TR

ACCELERATION LAGS ALL THE TIME, BUT IS ESPECIALLY APPARENT WHEN "FLOORING IT" UPON FREEWAY ENTRY, PASSING, ETC. I SEE THAT THIS IS ONE OF THE MOST FREQUENT COMPLAINTS ABOUT 04 HIGHLANDERS. OVERALL, QUITE DISAPPOINTED IN MY OVERPRICED SUV. *TR

MOON ROOF BEGAN MAKING SLIGHTLY FUNNY SOUND ON OCCASION, THEN WAS FINE AND STOPPED MAKING NOISE, THEN VERY SHORTLY AFTER WARRANTY WAS UP IT STOPPED OPENING AND WON'T SHUT.*JB

THE STEERING SENSOR ON THE ANTI-SKID SYSTEM SHORTED OUT CAUSING THE ANTI-LOCK BRAKES TO ENGAGE WHILE THE CAR WAS IN MOTION. THIS CAUSED A VERY DANGEROUS SITUATION. CAR HAD TO BE PULLED OF TO THE SIDE OF THE ROAD IN A HEAVY TRAFFIC ENVIRONMENT. CAR COULD NOT BE DRIVEN WITHOUT THE ANTI-LOCK BRAKES ENGAGING. CAR WAS TOWED TO THE TOYOTA DEALERSHIP. I ASKED THE DEALER TO DISCONNECT THE ANTI-SKID SYSTEM, BECAUSE THIS SYSTEM WAS MORE DANGEROUS THAN THE PROBLEM IT WAS TRYING TO ADDRESS. THE DEALER SAID THAT WAS NOT POSSIBLE AND IF THE STEERING SENSOR WAS NOT REPLACED, THE CAR WOULD NOT BE DRIVABLE. IF A SENSOR IN A CONTROL SYSTEM FAILS, IT SHOULD NOT CAUSE A DANGEROUS DRIVING SITUATION. IF A SENSOR FAILS, THE BRAKES SHOULD NOT ENGAGE, THE SYSTEM SHOULD JUST BECOME INOPERABLE. THE LOGIC IN THEIR CONTROL SYSTEM IS FAULTY AND THE COMPUTER SHOULD BE RE-PROGRAMMED TO ELIMINATE THE PROBLEM. TOYOTA MOTORS WAS INFORMED OF THE PROBLEM AND THEY CHOOSE TO IGNORE MY COMPLAIN. THE DEALERSHIP REPLACED THE STIRRING SENSOR FOR A RIDICULOUS PRICE AND THE CAR IS ABLE TO MOVE FORWARD AGAIN WITHOUT THE ANTI-LOCK BRAKES ENGAGING. MY WIFE IS AGAIN DRIVING A CAR WHICH IS INHERENTLY UNSAFE. WE ARE CONSIDERING SELLING THE CAR BECAUSE OF THE ONGOING SAFETY PROBLEMS. *TR

I BOUGHT USED 2004 TOYOTA HIGHLANDER AND NOTICED A HEARD A THUMPING SOUND THAT COULD ALSO BE FELT IN THE STEERING WHEN TURNING THE STEERING WHEEL AT SLOW SPEEDS. HAD AN ACCIDENT A FEW MONTHS LATER, WHERE ANOTHER VEHICLE HIT MY FRONT LEFT WHEEL. THE THUMPING GOT WORSE SO I MENTIONED IT TO THE BODY REPAIR SHOP. THEY HAD IT TOWED TO A TOYOTA DEALER EVEN THOUGH I HAD DRIVEN IT FOR 6 WEEKS AFTER THE ACCIDENT, WHERE THEY WERE TOLD THAT IT WAS NORMAL WEAR , 85,000 MILE,) ON THE INTERMEDIATE STEERING SHAFT, AND IT NEEDED TO BE REPLACED AT A COST OF $380 +. THE DEALER SERVICE DEPARTMENT SAID IT WAS NOT ACCIDENT RELATED. I STILL HAVE NOT HAD IT REPAIRED. *AK

1 MONTH AFTER PURCHASING THE TOYOTA THE HESSITATION ON ACCELERATION BEGAN. I HAD THE COMPUTER PROGRAM FLASHED NUMEROUS TIMES. THE DEALERSHIP CLAIMED THEY HAVE DONE ALL THEY COULD. ENTERING HIGHWAYS OR TURNING CORNERS THE CAR STALLE D UNTILL THE THROTTLE GRABBED, AND THEN TOOK OFF. IT JOLTED THE BODY AND MADE DRIVING THE TOYOTA HIGHLANDER VERY DIFFICULT. *AK