2004 TOYOTA HIGHLANDER Complaints

Hello, I am the Buyer of the subject Vehicle, Upon doing my research, I found out several reports stating that The subject vehicle's 2.4L engine has manufacturing defect, that causes Head Bolts to get stripped/melt down in to oil causing Engine failures and Life threating risk in the middle of the road.

My car malfunctioned my tire locked up while I was driving on the high way causing me to spin out of control and skid all the way into a guard rail totalled my car out and not one air bag went off

The passenger airbag occupancy sensor in my car has stopped sensing a passenger has been stuck on "OFF" for the past 2-6 months (I believe) even when an adult is sitting in the seat. I don't know exactly when this problem began because there was never any warning light or error message which is a massive safety oversight since I could have been in accident with no knowledge that it wasn't working properly. The car is currently at the dealership and they are telling me it's $1300 to replace the sensor and that there is no way to bypass the sensor and just have it "ON" for the safety of my passenger. There is already a recall for this same system in newer Highlanders, but why is there no support for older Highlanders?

The contact owns a 2004 Toyota Highlander. The contact stated while driving at an undisclosed speed, the front bumper inadvertently detached. The vehicle was taken to an independent mechanic where it was determined that the front lower bumper covers had been attached with mounting tabs and that the bumper assembly had failed and needed to be replaced. The vehicle was not repaired. The contact was informed of an unknown recall. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 190,000.

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE AND PRESSING TO BRAKE PEDAL, THE PEDAL FAILED TO RETURN TO THE IDLE POSITION. THE VEHICLE STABILITY CONTROL MESSAGE DISPLAYED ON THE INSTRUMENT PANEL AND THE VEHICLE FAILED TO EXCEED 40 MPH. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WAS THEN DRIVEN TO THE LOCAL DEALER GROOVE TOYOTA LOCATED AT 5460 S BROADWAY, ENGLEWOOD, CO 80113 HOWEVER, THE CAUSE OF THE FAILURE WAS NOT YET DETERMINED. THE MANUFACTURER WAS NOT YET CONTACTED. THE FAILURE MILEAGE WAS 126,000.

WHILE TRAVELING THROUGH A HIGHWAY CONSTRUCTION ZONE MY CAR SUDDENLY BECAME HARD TO STEER, AND MY SPEED BECAME GREATER, TRIED TO (BREAK) DECELERATE THE CAR BEGAN SLIDING OUT OF CONTROL-PLOWING INTO THE ROAD CONSTRUCTION BARRIERS PART LODGED IN FRONT PASSENGER WINDSHIELD. THE CAR WENT THROUGH THE DITCH BECAME AIRBORNE THROUGH A ROD IRON FENCE SHATTERED THE REAR SECOND-ROW RIGHT SIDE WINDOW SPUN OUT , AND CAME TO REST JUST FEET FROM THE SOME PILEINGS. THIS IS THE INFORMATION OF MY DAUGHTER WHOM IS AN OUT OF STATE COLLEGE SENIOR AND VERY SHAKEN UP FROM THIS ORDEAL, THIS HER STATEMENT TO THE BEST OF MY KNOWLEDGE. POSSIBLY THE PLACEMENT OF THE 🚧 COULD HAVE BEEN A CONTRIBUTOR, AND THE UNCONTROLLABLE ACCELERATION. VEHICLE WAS BOUGHT USED A YEAR AGO. CAN YOU HELP UP LEARN WHY?

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING VARIOUS LOW SPEEDS, THE VEHICLE ACCELERATED RAPIDLY WITHOUT WARNING. UPON APPLYING MINIMAL PRESSURE TO THE ACCELERATOR PEDAL, THE ACCELERATOR PEDAL BECAME STUCK AND THE CONTACT'S VEHICLE CRASHED INTO ANOTHER VEHICLE, A DUMPSTER, AND ALMOST STRUCK A GROUP OF CHILDREN BEFORE COMING TO A STOP. IN AN ATTEMPT TO STOP THE VEHICLE, PRESSURE WAS APPLIED TO THE ACCELERATOR PEDAL AND THEN THE BRAKE PEDAL. THE VEHICLE FINALLY STOPPED AND WAS TURNED OFF. THE VEHICLE WAS ABLE TO BE DRIVEN TO THE CONTACT'S RESIDENCE. THE CONTACT STATED THAT THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED. THE CONTACT SUSTAINED SEVERE PAIN TO THE NECK AND BACK, WHICH REQUIRED MEDICAL ATTENTION. A DEALER AND THE MANUFACTURER WERE NOT MADE AWARE OF THE CRASH. THE VEHICLE WAS SUBJECT TO NHTSA CAMPAIGN NUMBER: 11V112000 (VEHICLE SPEED CONTROL). THE FAILURE MILEAGE WAS 170,000.

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE SEAT BELT ASSEMBLY MALFUNCTIONED AND THE FABRIC MATERIAL STRAP BECAME FRAYED AND SHREDDED AT THE BUCKLE LOCATION. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER (ATLANTIC TOYOTA IN LYNN, MASSACHUSETTS) AND MANUFACTURER WERE NOTIFIED, BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 150,000. *JS

THE TRANSFER CASE IS LEAKING AFTER ONLY 68000 MILES. THE LEAKING OIL DROPS OVER THE HEATED EXHAUST PIPE WHICH CAUSES FUME IN THE CABIN THROUGH AIR CONDITION AND FAN

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING VARIOUS SPEEDS, WHILE DEPRESSING THE BRAKE PEDAL, THE PEDAL TRAVELED TO THE FLOOR. THE TRACTION CONTROL, CHECK ENGINE, VSC, AND BRAKE INDICATORS ILLUMINATED. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 10V499000 (SERVICE BRAKES), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE CONTACT OBSERVED BRAKE FLUID LEAKING FROM THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 157,489.