2018 TOYOTA HIGHLANDER Complaints

The contact’s daughter owns a 2018 Toyota Highlander. The contact stated that while operating the vehicle, there was a clunking sound coming from the front driver’s side of the vehicle. The vehicle was taken to the local dealer, and the owner was informed that the struts needed to be replaced. The vehicle was not repaired. The vehicle was later driven to a local tire and battery service center who inspected the vehicle and informed the owner that the front control arms were rusted and needed to be replaced, and that the front axle was cracked. The vehicle was not yet repaired. The daughter was informed that the vehicle was unsafe to drive. The manufacturer was not yet contacted. The failure mileage was 101,000.

Transmission failed at 65,000 miles right after the warranty expired. Cost to fix is $8,000. This is an epidemic issue with Toyota Highlanders built from 2017 to 2023. Tried to get dealer to cover but they said they refuse. They said that Toyota Corporate settled by paying all dealerships for potential repairs due to this issue, however all funds have been depleted. Basically no help at all. Pursued issue with Toyota Corporate for several weeks of escalations and appeals. In the end they completely refused to offer any solution other than for me to pay out of pocket. This issue should have been a nationwide recall due to the systemic failure on thousands of Toyota Highlanders. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My car had around 52,930 miles on it when the transmission suddenly went out and left me stranded in [XXX]. I always took my car to the North Hollywood Toyota dealership regularly, twice a year since I bought the car for regular service maintenance. When I was quoted nearly $7,000 to replace the transmission, I sold the car. Why would a 2018 Japanese car with such low mileage and in great condition suddenly have transmission problems? Something doesn’t add up. I had to get towed home. I’m wondering if other Toyota Highlander owners have experienced unexplained transmission problems as well. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Complaint: I am writing to report a transmission defect in my 2018 Toyota Highlander AWD (UA80 8-speed automatic transmission). Prior to the check engine light illuminating, I noticed a burning smell coming from the vehicle. Subsequently, the following fault codes were retrieved: •P0741 – Torque Converter Clutch Circuit Performance/Stuck Off •P2714 – Pressure Control Solenoid “D” Performance/Stuck Off •P2757 – Torque Converter Clutch Pressure Control Solenoid Circuit Performance/Stuck Off These symptoms are consistent with the known defect described in Toyota’s Customer Support Program ZJC (POL19-04), which acknowledges a manufacturing defect involving an improperly bent washer tab inside the UA80 transmission. However, my VIN was not included in the covered vehicles under this program, despite experiencing identical symptoms. I am also aware that multiple class action lawsuits were filed in December 2025 against Toyota alleging the company knowingly concealed this defect from consumers for years. I am requesting NHTSA to investigate whether Toyota’s CSP ZJC coverage should be expanded to include additional affected VINs, and to consider issuing a mandatory recall for all vehicles equipped with the defective UA80 transmission.

Transmission failure (whining noise similar to the well-documented issue with UA80F 8-speed transmissions). I reported the noise and requested a specific diagnosis at approximately 95k miles --- no warning lamps/warnings were visible, just noticeable noise while driving without the radio on. On May 22, 2026, Torrington Toyota confirmed that the transmission was failed, but vehicle is drivable. As I purchased a Toyota Extended warranty, Toyota has approved the order of a remanufactured unit, which is on back order, so repair date is TBD/unknown. I lack confidence in the long-term viability of remanufactured unit, as this UA80F transmission continues to have issues, and will cost me $12k+ after the warranty expires, in the likely case that the remanufactured unit fails. There should be a long-term fix to this expensive issue.

The transmission went on my 2018 Toyota Highlander. The other day as I was driving on highway, lost power as I was driving in neutral. I went from 70mph to 10 or less mph, would not accelerate. All of a sudden all warning lights. Check AWD, check engine light came on, many messages at once. There were no warning lights displayed prior to this. I was able to get off an exit. Could not move the car anymore was not in a safe area, called police for assistance. The car was towed to an independent service center who confirmed it was a transmission issue.

UA80F Transmission failure at 100k miles for the 2018 Toyota highlander SE. No warning lights, engine noise (high pitched whine while driving). Took to the dealer and was told the transmission needed to be replaced.

First symptom I noticed was the car smell while it was running. I used a device to see what codes of any would pop up on a scan. It came up with codes tying into the fuel system. I then went to go fill up on gas couple days later and when going to start it back up it wouldn’t start. When it did start it would say engine losing power or steering losing power and then just shut off. I then looked up what that usually means and it made me look towards the alternator. I was told by a mechanic an easy way to see if your alternator was good was to start car and while running disconnect the negative on battery and if it stays running the alternator was still good. So I did that and it stayed running. I then looked up recalls for my vehicle and seen everything it was describing for the fuel system seemed to be happening. I am now filling this form out to get my vehicle looked at and fixed. I have a wife and 2 young daughters that we drive to school. It is not safe to be driving and hoping that us and others on the road will get to there destination safely.

The contact owned a 2018 Toyota Highlander. The contact stated that while driving at 35 MPH, occupied with her children in the rear passenger seats, the contact was attempting to merge onto the intersection, and a state trooper failed to yield at 55-60 MPH vehicle crashed into the front driver's side of the vehicle, causing the whole front end of the vehicle to detach from the vehicle. The contact stated that no air bags were deployed in her vehicle. The contact stated that she and her children sustained injuries, however under direct legal advice, she cannot disclose this information. Medical attention was required. The contact stated that a police report was filed. The contact mentioned the vehicle was towed to a collision center where it was declared destroyed. The manufacturer was not notified of the failure. The approximate failure mileage was 140,000.

Currently at 113k miles. VIN # is not on the recall or extended warranty list for transmission issues, shift lag has been noticed way before 100k miles. vehicle is making squealing noise on drive, and when gas petal is press. Since no recall, but per research, I may have a faulty transmission that is left out of the Customer support program zjc, t-SB-0160-18.