2004 TOYOTA HIGHLANDER Complaints

THERE IS A SULFUR SMELL WHEN I STOP OR BACK UP ON HILLS. THE DEALER SAID THAT THEY WOULD REPLACE THE CATALYTIC CONVERTER (PARTS ARE ON ORDER) AND THAT THIS WAS A DEFECT IN SOME VEHICLES. IF AN OWNER MENTIONS THE SMELL, THEY DO THE REPAIR UNDER WARRANTY. SHOULDN'T OWNERS BE MADE AWARE OF THE PROBLEM? *NM

NOTICED FREE PLAY AND A CLUNKING IN STEERING WHEEL @15,000 MILES. MORE PRONOUNCED ON TURNS WITH BUMPS. COMPLAINED TO DEALER ABOUT CONDITION AND THEY SAID IT WAS THE STEERING SHAFT HAD EXCESSIVE PLAY IN SHAFT JOINT. HAD TO WAIT OVER 1 MONTH FOR THE PART TO ARRIVE. STEERING SHAFT ASSEMBLY PART#45220-48150 WAS REPLACED. *JB

I OWN A 2004 TOYOTA HIGHLANDER V6. AT 45,000 MILES, I NOTICED A CLUNKING SENSATION IN MY STEERING WHEEL. LONG STORY SHORT, TOYOTA SAID IT WAS A FAILED U-JOINT AND HAD TO REPLACE MY STEERING COLUMN ASSEMBLY (PART # 45220-48150) AT A COST OF $490 TO ME. NOT COVERED BY 5 YR/ 60000 MI DRIVE TRAIN WARRANTY OR 3 YR/36000 MI EITHER. I LEARNED IN AN EDMUNDS.COM HIGHLANDER OWNERS' CHAT ROOM THAT I AM NOT ALONE. SEVERAL PEOPLE COMMENTED THEY HAVE THE SAME ISSUE. THE PROBLEM ALSO OCCURS WITH CAMRYS (WHICH HAS THE SAME CHASSIS). THE OTHER OWNERS COMPLAIN OF A LONG PART BACKORDER WHICH SOUNDS LIKE THIS MAY BE A WIDESPREAD PROBLEM. DOES THIS QUALIFY FOR A RECALL AND COULD I GET MY $490 REFUNDED IF SO? THANK YOU. *NM

I HAD A FLAT TIRE ON MY 2004 TOYOTA HIGHLANDER. MY HUSBAND AND I WERE GOING THROUGH THE TIRE REPLACEMENT STEPS AND HAD THE VEHICLE JACKED WITH THE MANUFACTURER PROVIDED JACK. AFTER REMOVING THE LUG NUTS, I WENT TO REMOVE THE FLAT TIRE FROM THE WHEEL STUDS. THE JACK POPPED OUT OF PLACE AND BENT, AND IS NOW UNUSABLE. WE HAD TO FIND A HEAVY DUTY JACK TO LIFT THE VEHICLE TO GET THE TIRE OFF AND PUT THE SPARE TIRE ON. SPARE WAS PLACED AND PROPERLY TIGHTENED. NOW, THERE IS A SCRAPING SOUND WHEN DRIVING THE VEHICLE AT ANY SPEED. I HAD FLAT FIXED AND WHEN TIRE COMPANY REMOVED SPARE, ONE WHEEL STUD FOR FRONT PASSENGER SIDE BROKE OFF. TIRE COMPANY SAYS THEY'VE SEEN THIS NUMEROUS TIMES WITH HIGHLANDERS; THE INTEGRITY AND/OR MACHINING OF THE WHEEL STUD APPEARS DEFECTIVE. *JB

I HAVE A 2004 TOYOTA HIGHLANDER WITH A 3.3L V6 AUTOMATIC TRANSMISSION. WITHIN THE FIRST WEEK OF DRIVING THE VEHICLE THAT WAS PURCHASED NEW FROM THE MANUFACTURER, I NOTICED THAT THE TRANSMISSION SEEMED TO HESITATE WHEN ACCELERATING AT LOW SPEEDS. THE PROBLEM PERSISTED AND I TOOK THE VEHICLE IN FOR SERVICE. THE DEALER SAID THEY COULD NOT REPRODUCE THE PROBLEM OR FIND ANYTHING WRONG. NOW THE CAR HAS ALMOST 20,000 MILES ON IT, I'VE TAKEN THE CAR BACK TO THE DEALER A FEW TIMES AS THE HESITATION HAS GOTTEN WORSE AND THEY CONTINUE TO TELL ME THERE IS NOTHING WRONG WITH THE CAR. I RARELY DRIVE THE CAR NOW SINCE I HAVE COME VERY CLOSE TO HAVING A MAJOR ACCIDENTS NUMEROUS TIMES. IN EACH CASE, I WILL TRY AND MERGE ONTO A FREEWAY. GOING UP THE RAMP (OR DOWN) AND ACCELERATING TO GET UP TO SPEED, THE TRANSMISSION WILL DELAY FOR 2-3 SECONDS. I THEN PUSH THE GAS PEDAL DOWN A BIT MORE AND THE RPM'S WILL SHOOT UP, THE CAR WILL JERK, AND SPEED AHEAD. IF I DON'T APPLY THE EXTRA GAS, IT LEAVES ME IN A SITUATION WHERE I MIGHT BE HIT FROM BEHIND BY OTHER CARS. WHEN THE CAR JERKS AHEAD, I'VE COME CLOSE TO SLAMMING INTO CARS AHEAD OF ME. I'VE DONE SOME RESEARCH ON THE WEB AND HAVE FOUND NUMEROUS OTHER TOYOTA OWNERS WITH THIS SAME EXACT PROBLEM. I HOPE NO ONE HAS BEEN KILLED OR INJURED FROM THIS DEFECT THAT TOYOTA IS UNWILLING TO ADDRESS, AND THAT THE NHTSA WILL INVESTIGATE THIS BEFORE ANYONE IS KILLED OR INJURED. *NM

IT IS NOT POSSIBLE TO SAFELY DRIVE THE TOYOTA HIGHLANDER 2004 WITH THE MICHELIN 225/65/R17 TIRES SOLD AS ORIGINAL EQUIPMENT IN ANY KIND OF SNOW CONDITIONS. EVEN WITH AS LITTLE AS 1-2 INCHES OF SNOW THESE TIRES ON THE HIGHLANDER TRAP AND BUILD UP SNOW IN THE WHEEL WELL LEAVING THE DRIVER WITH NO STOPPING ABILITY.*AK

DT*: THE CONTACT STATED WHILE DEPRESSING THE ACCELERATOR PEDAL, THE TRANSMISSION MOMENTARILY HESITATES BEFORE PROPERLY SELECTING THE CORRECT GEAR TO ENGAGE. THE VEHICLE WAS TAKEN TO THE DEALERSHIP SEVERAL TIMES FOR INSPECTION. THE DEALERSHIP MECHANIC RESET THE SOFTWARE THREE TIMES, BUT THIS DID NOT CORRECT THE PROBLEM. DIAGNOSTIC TESTING WERE PERFORMED ON THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND SENT A REPRESENTATIVE TO INSPECT THE VEHICLE. THE REPRESENTATIVE DROVE THE VEHICLE AND EXPERIENCED THE HESITATION AND EXPLAINED, THIS IS A FLAW IN THE DESIGN AND THE VEHICLE IS FREE-WHEELING. THE REPRESENTATIVE WOULD CONTACT THE ENGINEERS AND TRY TO SOLVE THE PROBLEM. UPDATED 03/17/06. *JB

IDENTICAL TO COMPLAINT #10114548 MY EVENT HAPPENED JANUARY 6, 2005 WITH LESS THAN 10,000 MILES ON VEHICLE. NOW, AT 35,750 MILES, I HAVE O2 SENSOR PROBLEMS ON A ROUTINE BASIS(3RD SENSOR ON ORDER FROM DEALER RIGHT NOW). I AM VERY CONCERNED THAT THESE PROBLEMS WILL CONTINUE PAST WARRANTY, I HAVE LITTLE FAITH IN THIS VEHICLES SAFETY AND PERFORMANCE -EVERY DAY I CROSS MY FINGERS THAT NOTHING ELSE GOES "BRAKES" WHILE DRIVING WITH MY 2 SMALL CHILDREN. THIS NEEDS TO BE INVESTIGATED. *NM

I BOUGHT A 2004 TOYOTA HIGHLANDER IN NOVEMBER OF 2003 BECAUSE MY HUSBAND AND I FOUND OUT WE WERE PREGNANT AND NEEDED A BIGGER CAR. THREE MONTHS AND 5000 MILES LATER I HAD TO BE TOWED TO THE DEALERSHIP BECAUSE OF A DEFECT IN A CHIP IN THE "MOTHERBOARD." (SOME SENSOR DEFECT THAT CAUSED THE ASC MECHANISM TO FOUL UP.) ANYWAY, ON MONDAY, THE SAME THING HAPPENED AGAIN AT 50500 MILES, BUT THIS TIME THE CAUSE WAS A STEERING SENSOR ACTUATOR. OF COURSE, THE CAR IS NO LONGER UNDER WARRANTY. I RAISED CANE BECAUSE TWO MAJOR THINGS HAVE CAUSED ME TO BE TOWED TO THE DEALERSHIP WITH BARELY 50000 MILES ON THE CAR. THEY ARE PAYING FOR THE COST OF THE PARTS BUT THAT'S IT. I TRULY BELIEVE TOYOTA SHOULD HAVE PAID FOR THE ENTIRE ORDEAL, INCLUDING TOWING, LABOR AND RENTAL CAR BECAUSE OF MY INCONVENIENCE AND OBVIOUS DEFECT IN THE CAR. TOYOTA IS ONE OF THE HIGHEST QUALITY BRAND NAMES OF CARS AND YOU DON'T EXPECT TO DEAL WITH THESE TYPES OF ISSUES WHEN BUYING ONE. I FEEL THAT THEY REALIZE I HAVE A DEFECTIVE CAR AND HAVE DECIDED NOT TO CARE. NOW I DON'T TRUST THE VEHICLE AND WANT TO TRADE IT IN FOR A NON TOYOTA CAR. THANKS FOR YOUR TIME AND CONSIDERATION. *JB

THE AUTOMATIC TRANSMISSION ELECTRONICS GET CONFUSED AT STREET SPEEDS, NOT ALLOWING ME TO ACCELERATE, ESPECIALLY WHEN MAKING A LEFT ACROSS TRAFFIC. I HAVE BEEN NEARLY T-BONED ON NUMEROUS OCCASIONS. I TALKED TO THE TOYOTA DEALERSHIP ABOUT A YEAR AGO, AND THE TECHNICIAN SAID THAT HE WAS AWARE OF THE PROBLEM AND EXPECTS TOYOTA TO COME UP WITH A SOFTWARE UPDATE TO FIX THE PROBLEM. RECENTLY, I LEFT A MESSAGE WITH THE SAME TECHNICIAN ASKING WHAT PROGRESS HAS BEEN MADE, AND I RECEIVED NO REPLY. IT IS EXTREMELY SCARY TO FIND THIS 'DEAD SPOT' IN ACCELERATION. THIS IS OUR FOURTH TOYOTA, AND MIGHT BE THE LAST IF TOYOTA DOES NOT ADDRESS THIS ACCIDENT WAITING TO HAPPEN. *JB