2008 TOYOTA HIGHLANDER Complaints

I own a 2008 Highlander Hybrid Limited. The ABS actuator and assembly have gone bad. The following dash lights are illuminated: ABS, VSC, brake warning, and parking brake. The issue has been confirmed by toyota dealer. This defect has been reported HUNDREDS of times and Toyota has yet to issue a recall for 2008 and above models. In 2019 there was a Customer Support Program Bulletin(CUSTOMER SUPPORT PROGRAM BULLETIN (ZKC): REPAIR COVERAGE FOR BRAKE ACTUATOR ASSEMBLY AND BRAKE BOOSTER PUMP ASSEMBLY ON CERTAIN 2008-2010 MY HIGHLANDER HYBRID VEHICLES) stating, " Toyota is providing coverage for repairs related to the certain internal malfunctions of the brake booster assemblies. One or more of the following specific Diagnostic Trouble Codes (DTCs) C1391, C1252, C1256 or C1253 will be stored in the vehicles memory to be used as verification." This 'customer support' bulletin was published June 6TH, 2019 and revised August 28TH, 2019. The bulletin continues, "Primary Coverage offers the Customer Support Program until December 31, 2020, regardless of mileage. After the Primary Coverage, the Secondary Coverage is applicable for 10 years or 150,000 miles from the vehicle’s date of first use, whichever occurs first." However, as this document clearly states that the affected and covered vehicles range from those manufactured in the years 2008-2010, the owners of a 2008/2009 model would only be eligible for primary coverage; allowing only about 1 year and 7 months for possible brake failure before a customer could file a claim for repair under warranty. Without any coverage the total cost for repair amounts to +$3,000.00(.) Seeing as this is an issue with Toyota manufacturing it seems that Toyota is much more concerned with keeping their money instead of preventing injury by issuing a recall and taking care of their customers.

This exact issue has occurred before and was already recalled and repaired. The issue is the brake system malfunctions and the vehicle information center states to take vehicle to dealership for repair immediately. Brakes can fail and multiple warning system are displayed.

Air bag lights continue to show. Vehicle had not been in any accidents. Seat warms do not work light comes on when you turn them on. Driver window will go up half way occasionally. Back wiper motor makes loud noise and doesn’t work anymore. Tire sensor also comes out.

My 2008 toyota highlander gas pedal must be lose.because I barley push the gas and it takes on fast.i was driving home on the highway and the truck just died .the battery dies I couldn't turn my wheel I could not press the break

I checked by local car repair shop found out failure code C1391. Mean- Brake Actuator Assembly fault. Recall program ended already by 2020. But is not my mistake, i every time on time change oil, tire, brake pads and do State inspection. this is Part defect from beginning some cars failing low mileage some failing after. This is whole part failure only by Toyota Hybrid vehicles. This repair only done by Toyota dealership because of Toyota software to install. Repair cost about 3500$ and i can't afford this repair cost i have 3 children 6years, 3years, 10 month old. Dangerous to drive with kids. Toyota USA already denied my request. Sincerly, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The Hybrid inverter failed on the car instantly stopping the car without any sort of warning what so ever. Car did not have a limp mode or any way to get the car off to the side of the road. It stopped in the traffic lane and had to be pushed out of harm's way. A search shows like it's becoming a common problem, $12,000.00 to fix it is another problem.

The contact owns a 2008 Toyota Highlander. The contact stated while driving at an undisclosed speed, the ABS and stabili-trak warning lights were illuminated. The vehicle was taken to an independent mechanic to be diagnosed. The mechanic retrieved DTC: C1391, indicating that the brake actuator assembly was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the Extended Program had expired, and the contact was advised to call the NHTSA Hotline for assistance. The failure mileage was approximately 180,000.

Unable to buckle 3rd row passenger side seat belt buckle. Safety of my children were put at risk as I didn’t realize this until recently since our family grew. No warning indicating lights are on.

Airbag failed to deploy in a front-left collision with another vehicle. The other vehicle's airbags did deploy. The vehicle is totalled and not available for inspection. The lack of deployment resulted in a head injury and whiplash. There was no advanced warning of this being a problem.

All the lights relating to brakes and ABS flashed up on the dashboard. We continued home slowly. Upon investigation from a trusted mechanic it seems it is the brake actuator. From numerous reviews and complaints online this is a reoccurring issue with Toyota cars but recalls were only issued for 2006-2007 models even though the 2008 Highlander hybrids use the same part.