2002 TOYOTA HIGHLANDER Complaints

SUN VISOR DOES NOT STAY IN POSITION. IT ROTATES DOWN TO A VERTICAL POSITION, OBSTRUCTING DRIVER'S VIEW AND WILL NOT STAY IN HORIZONTAL POSITION AGAINST CABIN CEILING. *TR

TANK FOUND TO VERY RUSTED, AND SPLIT, ALONG WITH FASTENERS, SO THAT GAS WAS LEAKING WHILE PARKED. UNABLE TO DRIVE THE VEHICLE. *TR

WHILE DRIVING BOTH SUN VISORS FALL UNEXPECTEDLY AND BLOCK VISION. THIS HAS BEEN A PROBLEM FROM THE GET-GO AND WE HAD THESE REPLACED ALREADY AND JUST OVER A YEAR LATER THE PROBLEM IS OCCURRING AGAIN. *TR

I WAS IN THE FRONT PASSENGER SEAT. I PUT THE CAR CIGARETTE LIGHTER INTO ITS HOLDER AND INADVERTENTLY PRESSED IT IN ALL THE WAY. AFTER A FEW MINUTES IT FLEW OUT OF ITS SPACE, IT WAS ALL LITE UP AND FELL TO THE FLOOR OF THE CAR WHERE IT BEGAN TO BURN THE MAT. I PICKED IT UP AND GOT A 2ND DEGREE BURN ON MY FINGER. WE COULD NOT BELIEVE THAT IT HAPPENED SO WE PUT THE LIGHTER BACK IN THE HOLDER AND PRESSED IT IN. IT FLEW OUT AGAIN. *TR

THE DRIVER'S SIDE SUN VISOR WILL NOT STAY DOWN WHEN PUSHED INTO PLACE TO BLOCK BRIGHT SUN. INSTEAD, IT MOVES PARTIALLY BACK UP, THEREBY OBSCURING THE DRIVER'S VISION. THERE ARE NUMEROUS REPORTS OF THE SAME PROBLEM IN OTHER 2002 AND 2003 TOYOTA HIGHLANDERS. TOYOTA'S RESPONSE IS SIMPLY THAT THE CAR IS OUT OF WARRANTY, AND WE ARE WELCOME TO PAY $850 FOR A NEW VISOR (IT IS SO EXPENSIVE BECAUSE IT CONTAINS A GARAGE DOOR OPENER REMOTE CONTROL). THIS IS A SAFETY ISSUE. HERE IS MORE INFO FROM OTHERS WITH THE SAME PROBLEM HTTP://WWW.FIXYA.COM/CARS/T594661-HIGHLANDER_PROBLEM_SUN_VISOR. *TR

THE SUN VISOR WILL NOT STAY IN THE UP POSITION. TOYOTA REPLACED THE VISORS UNDER WARRANTY AFTER THE FIRST OCCURRENCE. HOWEVER, THEY ARE NOT STAYING UP ANYMORE. THE DRIVERS SIDE VISOR FALLS DOWN WHEN DRIVING CREATING A SAFETY HAZARD. BOTH OF THEM FALL DOWN AT AN ANGLE WHICH COULD CAUSE HEAD INJURIES DURING A CRASH. IN DOING AN INTERNET SEARCH, IT APPEARS THIS IS AN ISSUE WITH MANY OTHER HIGHLANDERS. I WENT BACK TO TOYOTA AND THEY WOULD NOT REPLACE IT UNDER WARRANTY. *TR

TL* THE CONTACT OWNS A 2002 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE SECURITY SYSTEM FAILED AND CAUSED ALL OF THE DOORS TO LOCK. THE DOORS COULD NOT BE OPENED MANUALLY, CAUSING THE CONTACT TO BE TRAPPED IN THE VEHICLE DURING EXTREME HEAT. THE POLICE DEPARTMENT BROKE THE REAR WINDOW TO RELEASE THE CONTACT. THE CONTACT FELT CONSTANT WEAKNESS IN THE HEAD DUE TO THE EXTREME HEAT EXPOSURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC TEST PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 39,050 AND THE CURRENT MILEAGE WAS 39,106.

TL* THE CONTACT OWNS A 2002 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE DRIVER AND PASSENGER SIDE SUN VISORS WOULD RELEASE DOWNWARDLY WITHOUT INTENT WHEN THE VEHICLE WAS STATIONARY OR IN MOTION. THE SUN VISORS WOULD BE PLACED IN THE UPWARD POSITION UPON RELEASING. THE FAILURE OCCURRED INTERMITTENTLY AND TEMPORARILY DISTORTED THE VISIBILITY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND AN INDEPENDENT MECHANIC, WHO BOTH STATED THAT THE ENTIRE SUN VISOR WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

THE HEATER WOULD NOT PROVIDE HOT AIR. I PUSHED IN ON THE SWITCH AND THE HEAT WOULD WORK AS LONG AS I HELD THE SWITCH PUSHED IN (NOT DESIGNED TO BE PUSHED - ROTARY SELECTOR). EVENTUALLY, EVEN PRESSING THE SWITCH IN WOULD NOT WORK. I WENT ON LINE AND FOUND A DISCUSSION BLOG THAT DISCUSSED MY EXACT ISSUE. I FOLLOWED THE RECOMMENDATION AND PULLED THE FACE COVER OFF, REMOVED THE CONTROL PANEL AND DISCOVERED EXACTLY WHAT HAD BEEN DESCRIBED - A BROKEN SINGLE STRAND WIRE THAT RAN TO THE BACK OF THE SWITCH. I ATTEMPTED TO MAKE THE REPAIR USING A MULTI-STRAND WIRE AS RECOMMENDED BECAUSE THE DEALER REPAIR OPTION WAS $1,000. THE HEATER APPEARS TO WORK -SLIGHTLY, BUT NOW I HAVE NO AC. I THINK THE CIRCUIT BOARD WAS DAMAGED BY THE SOLDERING IRON HEAT. BECAUSE WE LIVE IN THE SEATTLE AREA, THIS CAUSES ISSUES WITH THE WINDOW DEFOGGER AS WELL AS HAVING NO AC. *TR

I HAVE A PROBLEM WITH THE SUN VISORS ON MY 2002 HIGHLANDER. THE VISORS SEEM OVERLY HEAVY AND DUE TO THE NORMAL VIBRATIONS IN THE CAR THEY FREQUENTLY FALL DOWN, WHICH IS QUITE DISCONCERTING WHEN DRIVING! I'VE TALKED TO TOYOTA BUT THEY MENTION THERE IS NO WAY TO ADJUST THE TENSION AND I'M GOING TO HAVE TO PAY 700.00 TO GET THEM FIXED. I'M CONCERNED AS IT LOOKS TO BE A DESIGN FAULT (I.E. BOTH VISORS ARE FALLING DOWN, DUE TO THE WEIGHT OF THE THINGS) AND I DON'T WANT TO PAY FOR NEW ONES TO BE IN EXACTLY THE SAME SITUATION IN 18 MONTHS TIME. I HAVE RESEARCHED THE PROBLEM ON THE INTERNET AAND MANY PEOPLE ARE REPORTING THIS PROBLEM WITH TOYOTA HIGHLANDERS. *TT