2002 TOYOTA HIGHLANDER Complaints

DRIVER/S SIDE SUN VISOR WILL NOT STAY UP. WHILE DRIVING, IT SUDDENLY DROPS OBSCURING MY VISION AND PUTTING THE DRIVER AT EXTREME RISK FOR AN ACCIDENT (IMPAIRED VISION OF THE ROAD). THERE IS NO APPARENT WAY TO FIX THIS PROBLEM SHORT OF REPLACING THE SUN VISOR (ESTIMATED COST OF APPROX. $700 PER BLOGS). THIS PROBLEM HAS BEEN EXPERIENCED BY MANY OWNERS OF 2002 HIGHLANDERS AS EXEMPLIFIED VIA "COMPLAINT" POSTINGS. *TR

REAR-RIGHT BREAK LIGHT NOT WORKING. REPLACE BULB AND DID NOT WORK. CHECKED SOCKET AND ALL IS FINE BUT BREAK LIGHT STILL NOT WORKING. I HAVE RESEARCH THIS FOR A WHILE AND NO SOLUTION. THESE SEEMS TO BE A VERY COMMON PROBLEM AND TOYOTA DOES NOT HAVE A SOLUTION. DEFINITIVELY A SAFETY ISSUE. I ALREADY GOT A TICKET FROM POLICE FOR NOT HAVING THESE LIGHTS IN WORKING CONDITION.

PASSENGER RIGHT REAR BRAKE INTERMITTENT. TOOK THE CAR TO MY LOCAL TOYOTA DEALER, THEY COULD NOT FIND THE PROBLEM. BULB, LIGHT SOCKET, WIRING, FUSE ALL CHECKED GOOD. THE ISSUE HAS NOT GONE AWAY. TODAY I WAS STOPPED BY A POLICE OFFICER BECAUSE OF MY PASSENGER BRAKE LIGHT NOT WORKING. I TOLD THE OFFICER ABOUT WHAT I DID TO RESOLVE THE ISSUE AND THAT I TOOK THE CAR TO THE TOYOTA DEALER AND THEY COULD NOT FIND OUT THE PROBLEM. AFTER EXPLAINING WHAT I DID TO RESOLVE THE ISSUE, THE POLICE OFFICER EXPLAINED TO ME THIS IS A SAFETY ISSUE AND THE BRAKE LIGHT NEEDS TO BE FIXED. I GOOGLED THE PROBLEM THIS EVENING AND FOUND 10 WEB SITES ALL HAVING THE SAME PROBLEM WITH THE PASSENGER RIGHT REAR BRAKE INTERMITTENT OR NOT WORKING. I FOUND ONE COMMON THREAD WAS THAT THE MAJORITY OF THE COMPLAINTS WAS ON THE 2002 MODEL AND A FEW ON 2003. *TR

THIS IS CLEARLY A DESIGN FLAW & POTENTIALLY DANGEROUS. THE SUN VISORS FAIL & DROP DOWN IN FRONT ON YOU, NO LONGER STAYING AT A PROPER ANGLE OR STAYING UP. I CUT ONE OPEN & FOUND THAT THE PIVOTING PIN IS COATED IN PLASTIC & HELD IN PLACE BY A METAL CLIP. OVER TIME THE PLASTIC CRACKS & FALLS OFF THE METAL PIN CAUSING THE LOSS OF THE REQUIRED FRICTION TO HOLD THE VISOR SECURELY IN PLACE. MY 1ST REPAIR WAS TO REFORM THE PIN WITH EPOXY, BUT THE FORCE FROM THE METAL CLIP WAS TOO MUCH AND IT FAILED IN A FEW MONTHS. THE NEXT FIX WAS TO CUT THE VISOR OPEN AGAIN & FORCE THE PART OF THE PIN STILL COVERED IN THE ORIGINAL PLASTIC COATING DEEPER INTO THE METAL CLIP. THAT REPAIR LASTED UNTIL NOW. THE REPLACEMENT PARTS ARE RIDICULOUSLY EXPENSIVE, BUT NOW I CAN NOT REPAIR IT AND NOT DOING SO WOULD BE A DRIVING HAZARD. FROM WHAT I HAVE READ ONLINE THIS IS A COMMON PROBLEM AND TOYOTA SHOULD HAVE DONE SOMETHING BY NOW. *JS

2002 TOYOTA HIGHLANDER. CONSUMER STATES AIR BAGS DID NOT DEPLOY DURING A COLLISION *TGW THE CONSUMER STATED A VAN PULLED OUT IN FRONT OF HUSBAND WHILE TRAVELING APPROXIMATELY 55 MPH. THE IMPACT WAS AT 45-50 MPH. THE CONSUMER'S HUSBAND HIT HIS HEAD ON THE STEERING WHEEL AND SUFFERED AMNESIA AND THE CONSUMER SUFFERED A NECK INJURY. *JB

DRIVER'S SIDE SUN VISOR KEEPS FALLING DOWN SUDDENLY WHILE DRIVING. WHILE SEARCHING ONLINE, I FOUND OUT THAT MANY 2002 HIGHLANDER OWNERS HAVE THE SAME PROBLEM. REPAIR IS TOO COSTLY. IT IS DEFINITELY A SAFETY HAZARD. *TR

TL* THE CONTACT OWNS A 2002 TOYOTA HIGHLANDER. THE CONTACT WAS DRIVING 60 MPH WHEN THE VEHICLE SUDDENLY ACCELERATED WITHOUT ANY WARNING. THE CONTACT DEPRESSED THE BRAKE PEDAL BUT THE VEHICLE FAILED TO STOP. THE CONTACT HAD TO COMPLETELY TURN OFF THE ENGINE IN ORDER TO GET THE VEHICLE TO STOP. THE VEHICLE WAS TOWED TO A DEALER WHO DIAGNOSED THAT THE ACCELERATOR CABLE WAS STUCK IN THE FORWARD POSITION AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 210,000.

A COUPLE OF MONTHS AGO WHITE SMOKE EMITTED FROM THE EXHAUST PIPE. LAST WEEK, ON A TRIP WITHIN 400 MILES OF MY HOME, THE ENGINE AND VSC LIGHT CAME ON INTERMITTENTLY. I IMMEDIATELY CALLED TOYOTA AND WAS TOLD THAT THE CAR COULD STOP SUDDENLY AND LEAVE US STRANDED SO I MADE AN APPT FOR MONDAY MORNING. THE CAR RODE VERY ROUGH FOR THE LAST TWO HOURS AND IT SEEMED AS IF IT IS READY TO STALL ANYTIME. TOYOTA CHARGED ME $ 321.00 FOR A COMPRESSION AND DIAGNOSTICS TEST. TOYOTA FOUND THAT I HAD LOW COMPRESSION. TOYOTA ALSO OFFERED TO TAKE APART MY ENGINE FOR 2667.00 TO SEE IF THE RINGS WERE DAMAGED. I REFUSED THE WORK AND PICKED UP MY CAR. WE CALLED AN ENGINE REPAIR BUSINESS. THE OWNER KNEW THE MAKE, MODEL AND YEAR OF MY CAR AND ASKED IF WE HAD JUST HIT THE 100,000 MILE MARKER. WE HAD. HE TOLD US OF THE OIL SLUDGE PROBLEM, SETTLEMENT AND FAULTY ALUMINUM ENGINES. I HAVE RESEARCHED SIMILAR CHARACTERISTICS WITH THE HIGHLANDER AND SEE THAT IT IS A COMMON PROBLEM FOR THE 2002 HIGHLANDER. THE SLUDGE SITUATION WOULD ONLY BE COVERED IF IT WAS WITHIN 8 YEARS OF THE PURCHASE DATE. WHAT ABOUT THE MANY CONSUMERS WHO STILL HAVE THIS PROBLEM AND IT IS PAST THE EIGHT YEARS? I BOUGHT THIS HIGHLANDER IN 2005, HAD IT SERVICED REGULARLY AND WE ALSO CHANGED THE OIL OURSELVES. IN 2008 I BROUGHT THE CAR INTO THE TOYOTA DEALERSHIP FOR A TUNE UP AND AN OIL CHANGE PRIOR TO A LONG TRIP. ON THE WAY HOME, THE ENGINE LIGHT CAME ON AND WE PULLED OVER TO A LOCAL GAS STATION AND THERE WAS LITERALLY NO OIL IN MY ENGINE. TOYOTA DID THE OIL CHANGE BUT DID NOT PUT 5 QUARTS OF OIL INTO MY CAR FOR THIS LONG TRIP. WHEN I RETURNED I DID CONFRONT THE DEALERSHIP BUT THEY DENIED ANY WRONGDOING. WE HAVE, SINCE THAT TIME PERIOD HAD TO ADD OIL CONTINUOUSLY. IT TURNS OUT THAT I WILL NEED TO REPLACE MY ENGINE FOR 4500.00. *TR

VEHICLE HAS TOYOTA 2AZ-FE (2.4 L) 4 CYLINDER ENGINE. OIL & COOLANT LEAKING FROM BACK OF ENGINE. HEAD BOLTS ON MAIN GASKET FAILED. IN SEARCHING INTERNET, COUNTLESS OTHER OWNERS HAVE UNFORTUNATELY EXPERIENCED THE SAME FAILURE WHICH IS DUE TO AN INHERENT DESIGN PROBLEM BY TOYOTA. BOLTS BETWEEN GASKET AND MAIN ENGINE BLOCK FAIL AND CANNOT BE REPAIRED OR REPLACED. HAVE TO BUY AND INSTALL A NEW ENGINE. CALLED TOYOTA USA HEADQUARTERS IN TORRANCE, CA. AND SPOKE TO THEM, THEY SAID THEY WILL DO NOTHING FOR ME. SPOKE TO DYLAN AND THE CASE NUMBER IS 1111291430. I BELIEVE THAT A RECALL SHOULD BE ISSUED AND THAT TOYOTA SHOULD ASSUME FINANCIAL RESPONSIBILITY FOR THESE FAILURES, WHICH ARE OBVIOUSLY DUE TO A DESIGN AND MANUFACTURING PROBLEM OF TOYOTA. *KB

OVER THE PAST FEW MONTHS THE DRIVERS SIDE VISOR WOULD FALL WHEN I PRESS THE BREAKS. BLOCKING MY VISION. RECENTLY, THE VISOR WILL NOT STAY UP AT ALL, AND NEEDS TO BE TAPED UP TO PREVENT IT FROM FALLING WHILE I AM DRIVING. *KB