2008 TOYOTA HIGHLANDER Complaints

WHILE DRIVING ON I40 NEAR TEXAS/NM STATE LINE, OIL COOLER LINE FAILED RESULTING IN THE HIGHLANDER DUMPING OIL ON THE ROADWAY FOR OVER A MILE BEFORE IT WAS NOTICED. PULLED OFF IMMEDIATELY, SAW OIL POURING OUT FROM BOTTOM PASSENGER SIDE OF ENGINE COVER. EXTERIOR LOWER PASSENGER SIDE AND REAR OF VEHICLE WERE ALSO COVERED IN OIL. NO DASH INDICATOR LIGHTS EVER WARNED OF ISSUE. THIS LEFT US STRANDED ON SIDE OF BUSY INTERSTATE WITH HEAVY SEMI TRAFFIC FOR HOURS WHILE WAITING FOR A TOW TO A SHOP FOR REPAIRS, WHERE WE HAD TO WAIT A DAY FOR THE PART. COMPLETELY UNACCEPTABLE TOYOTA KNEW OF A DEFECTIVE DESIGN THAT COULD LEAD TO ACCIDENTS AND DEATH, AND CHOSE NOT TO ISSUE A RECALL! WILL BE SEEKING LEGAL ACTION.

THE INCIDENT HAPPENED WHILE I WAS DRIVING MY FAMILY NORTH ON INTERSTATE 81 AT 1:00 AM. WE WERE TRAVELING AT ABOUT 75 MPH. IN MY DRIVER-SIDE MIRROR, I NOTICED WHAT LOOKED LIKE A MIST GETTING KICKED UP BEHIND THE CAR AND COVERING THE REAR WINDOW. IN THE DARK, I COULDN'T TELL IF IT WAS WATER OR SOME OTHER LIQUID. THE ROAD WAS DRY SO MY WIFE AND I PLANNED TO GET OFF ON THE NEXT EXIT AND INSPECT THE CAR, WE HAD CHILDREN IN THE CAR, AND STOPPING ON THE SIDE OF THE ROAD DID NOT SEEM SAFE. WHILE WE WERE LOOKING FOR THE NEXT EXIT, I KEPT LOOKING FOR INDICATOR LIGHTS TO COME ON AND CHECKING THE TEMPERATURE GAUGE TO SEE IF I COULD DISCERN IF THERE WAS ANYTHING WRONG WITH THE VEHICLE. NO INDICATOR LIGHTS CAME ON AND THE TEMPERATURE GAUGE STAYED WITHIN NORMAL LEVELS. THEN AFTER A FEW MINUTES, ABOUT 5-6 MINUTES, THE ENGINE SEIZED. ALL OF THE INDICATOR LIGHTS CAME ON AND THE DISPLAY SAID THERE WAS A PROBLEM WITH THE VSC SYSTEM. THANKFULLY THE CAR CONTINUED TO ROLL AND I WAS ABLE TO PULL THE CAR TO THE SIDE OF THE ROAD AND TURN ON THE EMERGENCY BLINKERS AND CALLED FOR ASSISTANCE. WHEN FINALLY WE GOT THE CAR TOWED TO THE NEAREST TOYOTA DEALERSHIP WE WERE INFORMED THAT THE OIL COOLANT LINE HAD "BLOWN" AND OUR ENGINE HAD SEIZED FROM A LOSS OF ENGINE OIL. TWO WEEKS BEFORE THIS INCIDENT THE CAR ALSO DISPLAYED THE VSC WARNING SO WE HAD THE CAR TOWED TO BEAMAN TOYOTA WHERE WE PAID 1818.60 TO HAVE, AMONG OTHER THINGS, THE WATER PUMP AND DRIVE BELT REPLACED. KNOWING WE WERE GOING ON THE ABOVE TRIP WE HAD ALL THE RECOMMENDED REPAIRS PERFORMED SO WE COULD BE CONFIDENT IN THE CAR DURING OUR TRIP.

THE BRAKES FEEL LIKE THE PULSATE WGEN YOU START TO PRESS ON THEM. THEN WHILE ENGAGING THE BRAKES IT WILL FEEL LIKES ITS GRABBING THEN IT RELEAES AND THE PEDAL FEELS LIKE IT HAS NO PRESSURE IN IT. THE CRUISE CONTROL STOPPED WORKING, ALL THE LIGHTS ARE ON FOR THE BRAKE SYSTEM, AND NOW IT HAS A LONG HIGH PITCH BEEP WHEN TURNING THE CAR ON OR APPLYING PRESSURE TO THE BREAK PEDAL.

2008 HIGHLANDER HYBRID LIMITED CHECK ENGINE LIGHT CAME ON AND SHOWED CODE P0A1B - DRIVE MOTOR 'A' CONTROL MODULE, THE CODE WAS CLEARED MANUALLY AND THE CHECK ENGINE LIGHT WENT OFF, THE NEXT DAY THE LIGHT CAME BACK ON AFTER DRIVING ABOUT 3 MILES THEN PARKED. THE NEXT DAY THE LIGHT WENT OFF ON ITS OWN AS WE TOOK IT TO THE TOYOTA DEALERSHIP AND HAS NOT BEEN BACK ON SINCE DRIVING IT THERE AND BACK, THE DEALERSHIP SAID THEY DROVE AROUND A LITTLE AND THE LIGHT NEVER CAME ON, WE BROUGHT IT HOME AND HAVE DRIVEN ABOUT 7 MILES WITHOUT THE LIGHT COMING ON. ACCORDING TO THE LOCAL TOYOTA DEALERSHIP AND CORPORATE TOYOTA THERE ARE NO RECALLS FOR OUR VIN BUT IT IS SHOWING ALL SIGNS OF THE INVERTER ASSEMBLY RECALL THAT AFFECTED 235,000 VEHICLES IN THE RECALL. TOYOTA QUOTED THE REPAIR AT $9000+ AND EVEN THOUGH IT HAS THE SYMPTOMS OF THE RECALLED VEHICLES THEY WILL NOT FIX IT BECAUSE IT IS NOT ON THE RECALL LIST AND THERE IS NOTHING THEY CAN DO. THE REPAIR COST IS MORE THAN THE VALUE OF THE CAR.

CLUNKING NOISE FROM STEERING COLUMN STARTED IN JULY OF 2020 AND IS GETTING WORSE CURRENT MILEAGE IS 130000. I MOSTLY HERE THE NOISE WHILE TURNING THE STEERING WHEEL AND ALSO FEEL THE CLICK IN THE STERRING WHEEL.

I HAD AN ENGINE OIL COOLER HOSE RUPTURE AT 131000 MILES. I LEFT AN OIL SLICK A MILE LONG ON THE STREET CAUSING A HAZARD IN THE ROAD AND A MESS IN MY GARAGE. ENGINE OIL HAD SPRAYED ALL OVER THE LOWER HALF OF THE ENGINE AND ONTO THE CATALYTIC CONVERTER WHICH WAS HEAVILY SMOKING AND I NOTICED A SMALL FIRE DOWN IN THE LOWER HALF OF THE ENGINE COMPARTMENT SO I HAD TO POUR WATER ON THE FIRE. TOYOTA HAS KNOWN ABOUT THIS ISSUE FOR A GOOD 7 YEARS BECAUSE I RECEIVED A "WARRANTY ENHANCEMENT NOTICE" (ZE2) IN 2014 STATING THAT THE OIL COOLER HOSE COULD SPRING A "LEAK" AND THEY WERE EXTENDING THE WARRANTY FOR SAID PART TO 10 YEARS OR 150,000 MILES. BUT TOYOTA PLAYED DOWN THE SEVERITY OF THE ISSUE STATING THAT A MAJORITY OF VEHICLES WITH THIS KNOWN DEFECTIVE PART WOULDN'T FAIL. TOYOTA KNEW THAT THE RUBBER HOSE WILL FAIL ON ALL VEHICLES DUE TO THE HEAT/COOL CYCLE BY ITS CLOSE PROXIMITY TO THE CATALYTIC CONVERTER (ABOUT 6 INCHES AWAY) SO THEY REDESIGNED THE OIL COOLER LINES TO BE ALL METAL. ALL TOYOTA/LEXUS VEHICLES WITH THE 2GR-FE ENGINE (2007-2011) WILL EXPERIENCE THIS CATASTROPHIC FAILURE OF THE RUBBER OIL COOLER HOSE(S) OVER TIME AND I'M SURE VEHICLE FIRES HAVE ALREADY HAPPENED DUE TO THIS KNOWN DESIGN FLAW.

MILEAGE ON 2008 HIGHLANDER SPORT IS 159226. WIFE ADJUSTED STEERING TELESCOPE/TILT WHEN SLOWING TO STOP SIGN. STEERING WHEEL COLUMN CAME OFF IN HER LAP.

TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, SMOKE WAS SUDDENLY PRESENT COMING FROM UNDER THE PASSENGER SIDE OF THE FRONT HOOD BEFORE THE ENGINE STALLED. AFTER STOPPING AND EXAMINING UNDER THE HOOD IT WAS DISCOVERED NO OIL WAS PRESENT IN THE ENGINE AND OIL HAD SPILLED ONTO THE ENGINE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ENGINE OIL COOLER LINE HAD BURST CAUSING OIL TO LEAK FROM THE ENGINE. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE LOCAL DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 82,652.

HIGHLANDER HYBRID 2008 WE WERE DRIVING ON A COUNTRY BACK ROAD. IN IDAHO, WE HAD JUST STOPPED AT A STOP SIGN AND WENT TO DRIVE FORWARD AFTER GOING AROUND 100-200 METERS AND THE CAR LURCHED FORWARD WHILE I WAS DRIVING AND THEN THE SCREEN WITH ALL THE WARNINGS BEGAN GOING OFF. ALL OF THEM SAYING PULL OVER TOT THE SIDE OF THE ROAD AND THAT ALL THE SYSTEMS WERE FAILING. ALL THE WARNINGS SAID THINGS TO TAKE THE CAR TO DEALER. WE PULLED OVER TO THE SIDE OF THE ROAD AND THEN TRIED TO GET THE CAR TO MOVE FORWARD BY PUTTING IT IN DRIVE AND YOU COULD HEAR THE CAR TRYING TO DO SOMETHING BUT NOTHING HAPPENED. THE CAR DID TURN ON BUT THAT WAS IT.

TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE ENGINE OIL COOLER PIPE RUPTURED WITHOUT WARNING WHICH CAUSED THE VEHICLE TO STALL. THE CONTACT PULLED OVER, SHUTOFF THE VEHICLE AND INSPECTED THE VEHICLE. THE CONTACT BECAME AWARE THAT THE OIL WAS COMPLETELY DRAINED FROM THE ENGINE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE INSPECTED. THE INSPECTION CONFIRMED THE DRIVER'S ASSESSMENT. THE MECHANIC INFORMED THE CONTACT OF A MANUFACTURER'S EXTENDED WARRANTY COVERAGE ON SIMILAR VEHICLES HOWEVER, THE WARRANTY HAD EXPIRED ON THE VEHICLE. THE CONTACT STATED THAT HE WAS NEVER NOTIFIED OF THE EXTENDED WARRANTY PRIOR TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 82,156.