2013 TOYOTA HIGHLANDER Complaints

MY 2013 TOYOTA HIGHLANDER WAS PURCHASED USED IN 2015 WITH ABOUT 40,000 MILES ON IT. IN 2016 THE CAR STARTED TO MAKE A "THUMPING" NOISE WHEN I MAKE A LEFT TURN OVER A BUMP BUT IT DIDN'T HAPPEN OFTEN AND I THOUGHT IT WAS RELATED TO MY GARAGE ENTRY OF A 1.5" BUMP IN THE PAVEMENT. MOST NOTICEABLE AT LOW SPEEDS BUT THAT MAY BE A RESULT OF THE LOWER INTERIOR NOISE. THE CARE HAS HAD THESE NOISES BECOME MORE PREVALENT SINCE I FIRST NOTICED IT. THE CAR HAS APPROXIMATELY 80,000 MILES ON IT NOW AND IT IS GETTING MORE PRONOUNCED. IT OCCURS WHEN YOU HIT ANY TYPE OF BUMP AND MORE OFTEN WHEN TURNING THE VEHICLE. I HAVE SEEN MANY REPORTS OF THIS AND EXPECT TOYOTA TO OFFER THEIR OWNERS A REPAIR FOR THIS ISSUE. THIS IS NOT THE TYPE OF QUALITY I EXPECT FROM TOYOTA HAVING OWNED A CAMRY (1987), RAV-4 (2006) AND NOW MY SECOND HIGHLANDER (2002 & 2013).

VEHICLE STARTED MAKING A CLUNKING NOISE 3 DAYS AGO. BROUGHT IT INTO THE DEALERSHIP TO HAVE IT REPAIRED. WAS INFORMED IT WAS NOT COVERED UNDER WARRANTY AND IT WOULD COST $507 IN REPAIRS. AFTER READING MANY COMPLAINTS ABOUT THE SAME ISSUE IT ACTUALLY IS MAKING ME A LITTLE CONCERNED.I HAVE ALWAYS OWNED TOYOTA'S AND NEVER HAVE HAD ANY ISSUES. MY MILEAGE IS 65,887 I TRULY BELIEVE THAT THIS ISSUE NEEDS TO BE RECALLED AND REPLACED. I NOTICED A LOUD CLUNKING NOISE WHEN I MADE LEFT HAND TURNS OR IF THERE WAS A SPEED BUMP OR A DIP. THE STEERING WHEEL ALSO DIDN'T FEEL THE SAME EITHER ALMOST LIKE IT'S LOOSE. I'VE OWNED THIS VEHICLE FOR APPROX 1 YEAR OURCAHSED CERTIFIED PRE OWNED. THE DEALERSHIP REALLY FRUSTRATED ME TODAY AND NOW I QUESTION EVEN KEEPING THIS VEHICLE. IF THIS SHAFT PLANS ON GOING OUT EVERY 30-60K MILES ID RATHER DUMP IT AND GET A DIFFERENT VEHICLE.

AROUND A YEAR AGO, AT APPROXIMATELY 58000 MILES, I BEGAN TO NOTICE A KNOCKING SOUND AND STEERING VIBRATION WHEN I TURNED IN EITHER DIRECTION AT LOW SPEED IN CITY DRIVING. I TOOK THE VEHICLE IN FOR EVALUATION AT RICE TOYOTA. THE TECHNICIANS COULD NOT HEAR ANYTHING. I TOOK IT BACK AT 61,118 IN FEBRUARY 2018 AS THE STEERING HAD GOTTEN WORSE, NOW LOOSE AND SLOPPY FEELING AT ANY SPEED. THEY COULD HEAR/FEEL IT THIS TIME AND I WAS TOLD IT WAS THE ELECTRIC POWER STEERING MOTOR AND TO JUST "TURN THE RADIO UP". I WAS READY TO TRADE THE VEHICLE IN, AS I FELT UNSAFE DRIVING IT ANYMORE, BUT KNEW I COULDN'T IN IT'S CURRENT CONDITION.I DID SOME RESEARCH AND FOUND THAT OTHERS WERE HAVING THE SAME PROBLEMS. THERE WAS EVEN A TSB (BULLETIN T-SB-0034-13) ISSUED ON 4/26/17 REGARDING THE STEERING PINION SHAFT. AFTER I FELT THAT I COULDN'T DRIVE THIS CAR IT ANYMORE, I RETURNED TO RICE TOYOTA ONCE AGAIN ON 11/24/18 AT 67,770 MILES AND THE REPAIRED THE VEHICLE. "IMMEDIATE STEERING SHAFT NEEDS TO BE REPLACED" FOR A TOTAL OF $588.23. THE VEHICLE NOW DRIVES BETTER, HOWEVER, I HAVE LOST FAITH IN IT , AS WELL AS TOYOTA. THIS IS A VERY SERIOUS SAFETY ISSUE THAT NEEDS TO TO BE ADDRESSED FOR THE SAFETY OF ANYONE DRIVING A 2008-2013 HIGHLANDER.

MY COMPLAINT IS ABOUT STEERING COLUMN NOISES, PLAY, LOOSENESS AND FEEDBACK THROUGH THE STEERING WHEEL. IT IS DESCRIBED IN A SERVICE BULLETIN: TSB-0034-13 I HAVE 97,000 MILES ON THE VEHICLE AND THE PLAY IS BECOMING MORE NOTICEABLE AS MILEAGE INCREASES. IT IS VERY DISAPPOINTING THAT TOYOTA KNEW ABOUT THIS ISSUE AND ISSUED THE TSB BEFORE I PURCHASED IT NEW. HOW ARE OWNERS SUPPOSED TO BE NOTIFIED ABOUT THESE THINGS WHILE UNDER WARRANTY?

STEERING MAKES A POPPING/CLICKING SOUND WHEN MAKING TURNS. SEEMS TO BE GETTING WORSE AS IT STARTED WITH JUST TURNING LEFT AND NOW DOES IT RIGHT AS WELL

CLUNKING NOISE WITHIN THE STEERING WHEN I TURN, ESPECIALLY AT LOWER SPEEDS. TOOK IT TO A REPAIR SHOP AND THEY INDICATED IT WAS THE INTERMEDIATE STEERING SHAFT. 48,000 MILES AT THE TIME.

I STARTED HEARING A POPPING NOISE IN THE STEERING COLUMN UNDER THE STEERING WHEEL. THE NOISE BECAME LOUDER AS TIME WENT ON ESPECIALLY WHEN I MADE TURNS. ON 11/07/18 TOYOTA RECENTLY DIAGNOSED THE PROBLEM AS AN INTERMEDIATE STEERING SHAFT AND I MADE AN APPOINTMENT TO GET IT FIXED AT THE DEALER FOR $584.92. THERE'S 57,665 MILES ON THE VEHICLE. I CAN VISIBLY SEE THERE'S SLACK IN THE STEERING SHAFT WHERE IT CONNECTS TO THE RACK AND PINION. II AM A 65 YEAR OLD WOMAN WHO BOUGHT THE VEHICLE NEW AND DROVE IT VERY GENTLY. I UNDERSTAND THE NEW SHAFT MAY HAVE AN IMPROVED DESIGN I HOPE SO IT DOES NOT OCCUR AGAIN. IT'S VERY CONCERNING IF I LOST CONTROL WHILE DRIVING. I WOULD THINK THERE SHOULD BE A RECALL BEFORE SOMEONE GET'S HURT.

STARTED HEARING A LOUD POPPING NOISE UNDERNEATH THE STEERING WHEEL OR PEDALS. NOISE BECAME LOUDER AS TIME WENT ON ESPECIALLY WHEN I MADE TURNS. TOYOTA RECENT DIAGNOSED THE PROBLEM AS AN INTERMEDIATE STEERING SHAFT. WAS ORIGINALL TOLD IT MIGHT BE A RACK AND PINION PROBLEM. HOPEFULLY THAT THIS DOESN'T NOW TURN INTO SOMETHING ELSE. THIS IS NOT COVERED UNDER MY POWERTRAIN WARRANTY. VERY UPSET.

TL* THE CONTACT OWNS A 2013 TOYOTA HIGHLANDER. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT T-BONED ANOTHER VEHICLE ON THE FRONT DRIVER'S SIDE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES TO THE RIGHT LEG, WHICH REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. FURTHERMORE, WHILE THE VEHICLE WAS STATIONARY AND WHILE DRIVING VARIOUS SPEEDS, THE ANTI-LOCK BRAKES FAILED ON MORE THAN ONE OCCASION IN OCTOBER OF 2018. THE CONTACT STATED THAT THE BRAKES AND WHEELS SEIZED ON THREE OCCASIONS. AN INDEPENDENT MECHANIC WAS MADE AWARE OF ALL THE FAILURES, BUT COULD NOT DETERMINE THE SOURCES. A DEALER WAS NOT MADE AWARE OF THE FAILURES. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.

VEHICLE HAD A KNOCKING NOISE HEARD AND FELT FROM STEERING WHEEL WHEN TURNING. SEEMED TO BE MORE PROMINENT AT LOWER SPEEDS, OCCURRED WHEN TURNING RIGHT AND LEFT. TOOK VEHICLE TO TOYOTA DEALER AND DIAGNOSED AS A FAILED INTERMEDIATE STEERING SHAFT. VEHICLE WAS OUTSIDE WARRANTY AT 54,853 MILES. RESEARCH INDICATES THIS IS A COMMON ISSUE WITH THIS YEAR HIGHLANDER AND TOYOTA HAS ISSUED A TSB, BUT HAS NOT ISSUED A RECALL TO DATE. COST OF REPAIR WAS $463.34.