2004 TOYOTA HIGHLANDER Complaints

2004 TOYOTA HIGHLANDER......DRIVER SUN VISOR DOES NOT STAY UP. BLOCKS VISION. TOYOTA WILL NOT FIX AT THEIR EXPENSE. RESEARCH SHOWS THAT THERE ARE NUMEROUS COMPLAINTS OF THE SAME NATURE. THIS IS A DESIGN FLAW AND TOYOTA NEEDS TO STEP UP. *TR

THE LENSES OF THE DAYTIME RUNNING LAMPS/HIGH BEAMS HAVE DEVELOPED WHITE, OVAL-SHAPED BUBBLING/MELTING MARKS OF APPROXIMATELY 0.5 TO 0.75 INCHES IN DIAMETER, IN THE CENTER OF THE LENSES, DIRECTLY IN FRONT OF THE LAMPS. I FIRST NOTICED THIS IN DECEMBER 2010 JUST PRIOR TO CHANGING THE ORIGINAL LAMPS (THEREFORE THE REPLACEMENT LAMPS DID NOT CAUSE THIS PROBLEM). I REPORTED THIS TO TOYOTA, CASE NUMBER 1012071480. TOYOTA TOLD ME TO TAKE THIS UP WITH THE SERVICE DEPARTMENT OF A DEALER. AT THE DEALERSHIP, I WAS INITIALLY QUOTED A PRICE OF $988 TO REPLACE THE ASSEMBLIES. AFTER DISCUSSION WITH THE SERVICE MANAGER AND HIS FOLLOW-UP WITH TOYOTA, THE PRICE WAS LOWERED TO $396 TO PAY ONLY FOR LABOR, PARTS TO BE PROVIDED AT NO CHARGE. I OPTED TO NOT HAVE THIS DONE FOR THIS PRICE. POSSIBLE SAFETY ISSUES: 1) DAMAGED/MELTING LENSES COULD IMPACT THE EFFECTIVENESS OF THE HIGH BEAMS AND/OR THE DAYTIME RUNNING LAMPS; 2) HEAT THAT IS HOT ENOUGH TO DAMAGE/MELT THE LENSES COULD BE A FIRE HAZARD; 3) DAMAGED/MELTING LENSES COULD BE AN INDICATION OF AN ELECTRICAL PROBLEM. I HAVE DIGITAL PHOTOS TAKEN IN DECEMBER 2010 SHOWING THE DAMAGED/MELTING LENSES THAT I HAVE PROVIDED TO TOYOTA AND WOULD BE PLEASED TO PROVIDE TO NHTSA. I HAVE ALSO RETAINED THE ORIGINAL LAMPS, AND THE CAR STILL HAS THE DAMAGED/MELTED LENSES. *TR

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED WHEN THE ENGINE WAS STARTED THE STEERING ANGLE SENSOR WARNING LIGHT ILLUMINATED AND THE STEERING BECAME DIFFICULT TO HANDLE. THE VEHICLE WAS TOWED TO THE DEALER WHO PERFORMED A DIAGNOSTIC THAT WAS UNABLE TO LOCATE A FAILURE. THE VEHICLE WAS TEST DRIVEN AND THE FAILURE WAS RECREATED. THE DEALER REPLACED THE STEERING ANGLE SENSOR. THE FAILURE AND THE CURRENT MILEAGE WAS 14,000. UPDATED 5/2/11 *CN

ON FEBRUARY, 18, 2011 AT APPPROXIMATELY 1:30 P.M. I GOT INTO MY 2004 TOYOTA HIGHLANDER, WHICH WAS PARKED IN A PRIVATE PARKING LOT AT 1 MEETINGHOUSE RD. IN CHELMSFORD, MA. I TURNED THE KEY ON, STARTED THE CAR, AND PUT THE GEAR IN REVERSE TO BACK OUT OF THE PARKING SPACE. AS I TOUCHED THE ACCELERATOR PEDAL WITH MY RIGHT FOOT, THE CAR ACCELERATED UNCONTROLLABLY AT A SPEED THAT DID NOT CORRESPOND WITH THE PRESSURE I HAD PUT ON THE PEDAL. I IMMEDIATELY PUT MY FOOT ON THE BRAKES, BUT THERE WAS NO RESPONSE FROM THE BRAKE SYSTEM. THE STEERING WHEEL WAS TURNED TO BACK OUT IN A COUNTERCLOCKWISE DIRECTION, AND WITHIN NO MORE THAN 4 SECONDS, THE CAR CRASHED INTO A BUILDING APPROXIMATELY 20 FEET FROM WHERE THE CAR WAS INITIALLY PARKED. THE CAR WAS TOTALLY UNRESPONSIVE TO MY EFFORTS TO BRAKE SUBSEQUENT TO THIS SUDDEN AND INEXPLICABLE ACCELERATION. I'M LUCKY I WASN'T KILLED, BECAUSE MY VEHICLE WAS TOTALED. *TR

COOLANT LOSS DUE TO STRIPPED HEAD BOLTS IN THE ENGINE BLOCK. ENGINE OVER HEATED. NO HEAT.*TR

TL*THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE GPS NAVIGATION SYSTEM ON THE VEHICLE FAILED WHICH CAUSED THE AIR CONDITIONING, HEAT, DEFROST AND THE RADIO TO FAIL. THE CONTACT HAD THE VEHICLE INSPECTED BY THE DEALER AND WAS TOLD THAT THE NAVIGATION SYSTEM NEEDED TO BE REPLACED; HOWEVER, THE DEALER DID NOT GIVE AN EXPLANATION OF WHAT CAUSED THE FAILURE TO OCCUR. THE FAILURE MILEAGE WAS 42,000 AND THE CURRENT MILEAGE WAS 82,000.

TL*THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT NOTICED THAT THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO INFORMED THE CONTACT THAT THE CYLINDER BEHIND THE INTAKE MANIFOLD WAS LEAKING AND THAT SHE WOULD NEED TO REPLACE THE ENGINE. THE DEALER ADVISED THE CONTACT THAT SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY THEY WOULD NOT BE ABLE TO PROVIDE HER WITH ANY ASSISTANCE. THE MANUFACTURER WAS NOTIFIED AND THE CONTACT WAS WAITING FOR A RESPONSE. THE VEHICLE WAS NOT REPAIRED DUE TO THE COST. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 78,000.

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING APPROXIMATELY 45 MPH WITH THE AIR CONDITIONER ACTIVATED, HEAT BEGAN BLOWING FROM THE VENTILATION AS OPPOSED TO COLD AIR. THE FAILURE WOULD OCCUR INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE FAILURE MILEAGE WAS 35,000 AND THE CURRENT MILEAGE WAS 40,000. UPDATED 03/07/11*LJ UPDATED 07/18/11

TL*THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH, AND NOTICED THAT THE TEMPERATURE GAUGE RAPIDLY INCREASED TO HOT AND THE ENGINE BEGAN TO OVERHEAT. THERE WERE NO WARNING LIGHTS ILLUMINATED. THE CONTACT PARKED THE VEHICLE FOR ONE HOUR AND THEN RESUMED DRIVING WITHOUT THE ENGINE OVERHEATING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING WHERE THEY WERE INFORMED THAT THE ENGINE BLOCK BOLTS WERE STRIPPED AND THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.

I HAVE A 2004 4 CYL HIGHLANDER, AND I CAN COMPLETELY UNDERSTAND THE OTHER COMPLAINERS SITUATION AS I AM EXPERIENCING THE SAME PROBLEM. IT HAPPENED AT AROUND 60K MILES AND THE DEALER SAID IT WOULD COST ABOUT $600. TO FIX. I DIDN'T. I JUST HAD TO PLAY AROUND WITH THE KNOB WHEN I NEED TO USE IT. *TR