2014 TOYOTA HIGHLANDER Complaints

Component: Latches/Locks — Power Door Lock Actuator I am the original owner of a 2014 Toyota Highlander AWD, currently with 88,000 miles on it. I have experienced six power door lock actuator failures on this vehicle. All replacements were OEM Toyota parts, and all repairs were paid out of pocket. Failure history: - 01/12/2019 — driver rear (original part) - 02/27/2019 — driver front (original part) - 12/07/2019 — passenger rear (original part) - 06/09/2023 — passenger front (original part) - 08/08/2025 — driver rear (OEM replacement, 6 yr 7 mo service life) - 08/30/2026 — driver front currently failing (OEM replacement, 7 yr 6 mo service life) All four original actuators failed between years 5 and 9 of the vehicle's life. Two OEM replacements have since failed on a comparable schedule. This is a consistent wear-out pattern across every door on the vehicle, not isolated part failure. The higher-cycle driver-side doors have now failed twice each. Current condition: the driver front door intermittently does not lock when commanded by the key fob or by the interior lock switch. The failure is silent — there is no chime, warning, or indication that the door did not secure. The driver has no way to know the door is unlatched without physically checking it. Safety concern: an unsecured door can open during vehicle operation, and reduces occupant protection in a side impact or rollover because the latch is not engaged. Because the failure is intermittent and gives no warning, a driver can reasonably believe the vehicle is locked when it is not. This affects occupants including children in rear seating positions. Toyota has issued no recall, technical service bulletin, or warranty extension for this component. Complaints describing the same repeated actuator failures have been reported by owners of Highlanders and other Toyota models across multiple model years. I am submitting this record so the failure pattern is documented.

The radio keeps freezing up all the time along with the back tail light area going in and out. I keep smelling like burnt wire smell. Engine sound really rough.

The driver’s-side rear spoiler on my 2014 Toyota Highlander Limited AWD has melted, bubbled, and warped. The vehicle has been stored 100% of the time in a fully enclosed garage with no windows since new. It has only 65,000 miles and has received all service exclusively at authorized Toyota dealerships. There has been no direct sun exposure, accident, or misuse. Toyota dealer and Corporate attributed this to “solar convergence” and denied any repair assistance or goodwill coverage. This explanation does not match the facts given the garage setup and minimal outdoor time. This appears to be a materials/design defect in the black plastic spoiler. Similar melting/warping issues are reported by other owners on Highlanders and RAV4s, even on low-mileage garaged vehicles. Dealer replacement quotes are typically $2,700+. I request NHTSA investigate this recurring plastic failure as a potential defect in materials and workmanship. Attachments (upload with form): • Photos of the melted spoiler (multiple angles) I am available for any additional information. 05 May 2026

I noticed the smell of wires burning, a billow of smoke started emitting from the two levers used to heat the seats near the gear shift area. I was on the freeway and immediately pulled to the side of the road, turned off the car and called 911 before any flames were seen. There were no warning signs, lamps or other symptoms until the smell of burning wires and the smoke.

The contact owns a 2014 Toyota Highlander. The contact stated that a hybrid system warning alert was displayed. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the windshield wiring system had failed and that the windshield needed to be replaced. The vehicle was not repaired. The mechanic informed the contact that the windshield failure was associated with NHTSA Campaign Number: 18E107000 (Electrical System, Visibility). The dealer was not contacted. The vehicle was not diagnosed or repaired. The windshield manufacturer was made aware of the failure; however, the vehicle manufacturer was not made aware of the failure. The approximate failure mileage was 190,000.

Was driving 70 mph on nj 287 when all sudden I hear something that sounded like implosion and air was coming from sunroof. Ended up being sun roof glass flew out of car sunroof frame. Toyota knew it was a defect as they did inspection but did not want to cover it because they said it’s out of warranty. Thankfully no one was driving behind me at that time

Rear lights located both on the tailgate and body of the vehicle. The lights covers failed to remain adhered to the lights themselves and fell off and are partially adhered as a result of what appears to be a failure of the adhesion material . Two light covers may have been lost while driving. Unknown if their loss resulted in damage(s) to others. Without the outer cover results in the exposure of the lights to weather and potential failure. Review with Toyota of Orange service manager confirm the failure of adhesive/ manufacturing process of the lights

Installed (4) Firestone Destination Le3 tires in March 2022. All four tires became dry rot in just over 2 years, failed inspection at 2 1/2 years. 70,000 mile tires with roughly 28,000 miles left of the warranty.

Water leaks inside the car every time it rains. We checked the sunroof drain tubes. They are clear. It is getting in through the roof rail bolts. It runs down the pillars to the floor and underneath the floor carpet. The carpet is wet for long periods of time in rainy seasons. I am concerned there is going to be mold issues.

The vehicle is painted in Blizzard Pearl, which has a known peeling issue. Toyota never sent us any notification of an issue with the paint. A patch of the paint has peeled off of the top of the vehicle and has continued to grow larger. When we contacted Toyota, we were informed the period to fix this issue has closed and we would have to repair out of pocket. Our vehicle was mostly garage kept and didn't suffer the immediate failure of the paint. Blizzard Pearl is a color with an additional cost and has the most complaints for failure. Toyota has acknowledged the problem but did very little to ensure customers were notified, did not take into account Blizzard Pearl painted vehicles would fail at different times due to climate/storage of vehicles, and only provided a narrow window to their customers for this issue. The peeled paint has exposed the body of the vehicle to the elements, which will cause it to rust.