2006 TOYOTA HIGHLANDER HYBRID Complaints

The contact owns a 2006 Toyota Highlander Hybrid. The contact stated that while driving 72 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The check engine and traction control warning lights were illuminated. Additionally, the "Check Hybrid System", "Check AWD", and "Check VCS" messages were displayed. The contact was able to coast to the side of the road and had the vehicle towed to the residence. The contact notified an independent mechanic of the failure, and the mechanic stopped by the residence. The independent mechanic retrieved a DTC that the power inverter for the hybrid system had failed and caused the vehicle to go into LIMP Mode. The vehicle was not repaired. The contact called the dealer and was informed that there were no recalls associated with the VIN. The contact stated that when the dealer searched the VIN on the NHTSA.gov website, the VIN search showed that the VIN was included in NHTSA Campaign Number: 13V396000 (HYBRID PROPULSION SYSTEM). The manufacturer was made aware of the failure and informed the contact that the recall did not apply to the VIN. The vehicle remained at the residence unrepaired. The failure mileage was approximately 150,455.

The contact owns a 2006 Toyota Highlander Hybrid. The contact stated while driving 65 MPH, the vehicle stalled with the check hybrid system and two other unknown warning lights illuminated. The contact managed to coast the vehicle to the side of the highway; however, the vehicle failed to restart. Due to the failure, the vehicle was towed to an independent mechanic where a diagnostic test was performed. The mechanic discovered that there was a leak in the inverter cooling system. Upon investigation, the contact discovered an unknown recall that was related to the failure. The manufacturer was notified of the failure but informed her that the vehicle was not included in the unknown recall. The vehicle was not repaired. The failure mileage was approximately 280,000.

WE WERE DRIVING DOWN THE HIGHWAY I-30 EAST UP A HILL GOING APPT 70 MPH WHEN THE CAR WENT INTO LIMP MODE AND SLOWED DOWN TO 10 MPH. THEN WENT TO ONLY 1 MPH. WE CHECKED THE BATTERY CONNECTION, FUEL CAP, EVERYTHING WE FOUND ONLINE TO CHECK.

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER HYBRID. THE CONTACT STATED THAT THE VEHICLE DID NOT START AND THE HYBRID WARNING INDICATOR ILLUMINATED. THE CONTACT ALSO STATED THAT THE VEHICLE WAS REPAIRED THREE PREVIOUS TIMES BY NAGUABO AUTO TOYOTA (CARRETERA 31 KM 3.9, NAGUABO, PR 00718) REGARDING THE HYBRID MODULE. THE VEHICLE WAS NOT REPAIRED AGAIN. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

CURRENTLY, THE VEHICLE IN MOTION, HOWEVER IT POTENTIALLY CAUSES UNSAFELY IF NOT FIXED AS REQUESTED. THE REASON I COME TO YOU FOR COMPLAINT, I DO HAVE A SITUATION WITH CARLSON TOYOTA AND/OR TOYOTA MOTOR GROUPS. HERE THE SITUATION WHAT HAPPENS. I DO HAVE 2006 TOYOTA HIGHLANDER HYBRID. I DROVE THIS SUV SINCE 2009. I HAVE A NUMBER OF RECORDS FROM THE SAME DEALER TO MAINTAIN THE SUV SAFE. HOWEVER, COUPLE MONTH AGO ON 04/22/2019, I GOT SOME OF THE DASHBOARD LIGHT INDICATES ANTI-LOCK BRAKING SYSTEM (ABS) CHECK LIGHT IS ON. I TOOK THE CAR TO THE CARLSON TOYOTA DEALER PAY DIAGNOSED FEE $149.00 AND THE RESULTS IS UNPREDICTABLE PRICES. SEE THE LISTS: 1) BREAK ACTUATOR ASSEMBLY----------------------------$2225.00 2) RIGHT REAR WHEEL BEARING AND HARNESS ----------$1156.00 TOTAL------------------------------------------------------$3,381.00 THE REASON I AM COMPLAINING TODAY NOT BECAUSE OF THE PRICE TO HIGH. HOWEVER, I FOUND TOYOTA PUBLISHED LETTER ON APRIL 19, 2016, TO ALL TOYOTA DEALER PRINCIPALS, GENERAL MANAGERS, SERVICE MANAGERS, AND PARTS MANAGERS. UNDER THE SUBJECT LINE WARRANTY ENHANCEMENT PROGRAM ?ZG1, FOR ALL 2006-2007 MODEL YEAR HIGHLANDER HYBRID, AND OTHERS TYPE INCLUDED. ALSO, DOWN THE LAST THREE PARAGRAPH (SEE ATTACHED LETTER) INDICATES UNDER OWNER LETTER MAILING DATE, SAID ?TOYOTA WILL BEGIN TO NOTIFY OWNERS IN LATE APRIL, 2016 AND WILL BE MAILED OVER SEVERAL MONTHS. A SAMPLE OF THE OWNER NOTIFICATION LETTER HAS BEEN INCLUDED FOR YOUR REFERENCE.? AFTER I FOUND THE PUBLISHED NOTICE, I WENT TO THE CARLSON TOYOTA DEALER ON 06/18/2019. I DESCRIBED THE SITUATION AND I SHOWED THE RECIPES OF WHERE I GET FROM DURING INSPECTION, AND FINALLY THEY TOLD ME THIS WARRANTY ENHANCEMENT PROGRAM IS EXPIRED. I ASK THEM HOW IS EXPIRED, NOBODY TOLD ME ABOUT THIS RECALL OR WARRANTY ENHANCEMENT PROGRAM. I NEED HELP TO RESOLVE THIS SITUATION. SEE ATTACHED DOCUMENTS. *JS

TL* THE CONTACT OWNS A 2006 TOYOTA HIGHLANDER HYBRID. WHILE DRIVING APPROXIMATELY 15 MPH, THE VEHICLE LOST POWER, THE CHECK ENGINE AND ABS WARNING INDICATORS ILLUMINATED, AND THE VEHICLE STALLED. ALSO, "CHECK HYBRID SYSTEM" APPEARED ON THE INSTRUMENT PANEL. FRED HAAS TOYOTA WORLD (20400 INTERSTATE 45 N, SPRING, TX 77373) WAS NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED BECAUSE THE TEST WAS NOT FREE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 250,000.

MY 2006 HIGHLANDER DROVE JUST FINE. PARKED IN MY USUAL SPOT AND THE NEXT TIME I START IT MY P/S LIGHT IS ON AND I HAVE NO STEERING. I SEARCHED ONLINE AND IT SEEMS TO BE A COMMON PROBLEM FOR IT TO JUST QUIT WORKING ON PEOPLE. I'M CURIOUS AS TO WHY THIS ISSUE HASN'T BEEN ADDRESSED BY TOYOTA YET. THANK GOD I WASN'T DRIVING LIKE OTHERS WERE WHEN IT HAPPENED.

I HAVE HAD TO REPLACE THE BRAKE ACTUATOR ON MY 2006 TOYOTA HIGHLANDER HYBRID 3 TIMES SINCE 2014. REPLACING THIS PART IS A $2500 - $3000 REPAIR. THE FIRST TIME, WE PAID OUT OF POCKET. THE SECOND TIME, I WAS TOLD I WOULD HAVE TO PAY OUT OF POCKET AND I DECLINED. PARKED THE VEHICLE FOR ABOUT A YEAR AND THEN RECEIVED NOTICE FROM TOYOTA THAT THE PART WAS BEING OFFERED AN EXTENDED WARRANTY UNDER LETTER ZG1. AT THAT POINT, I HAD THE PART REPLACED UNDER THE EXTENDED WARRANTY. NOW THE PART HAS FAILED AGAIN. THIS IS A VERY SERIOUS ISSUE AS IT CONTROLS THE ABS BRAKING SYSTEM AND FAILURE CAN HAVE DEVASTATING CONSEQUENCES. I THINK TOYOTA RECOGNIZED THE ISSUE, MADE ADJUSTMENTS, BUT DID NOT MAKE PROPER ADJUSTMENTS AND STILL HAS ISSUES WITH THIS PART. PARTICULARLY - THIS ISSUE MAY BE RELATED TO THE FACT THAT THE HYBRID VEHICLES RELY ON THE BRAKING SYSTEM TO REGENERATE THE BATTERY.

WHILE ATTEMPTING TO MAKE A STOP AT AN INTERSECTION DURING CITY DRIVING THE BRAKE PEDAL BECAME VERY HARD TO PRESS DOWN AND SEVERAL WARNING LIGHTS CAME ON MY VEHICLE DASHBOARD. AT FIRST, THE PROBLEM WAS INTERMITTENT BUT PROGRESSIVELY GOT WORST OVER CONTINUED DRIVING. I TOOK MY VEHICLE TO MY LOCAL TOYOTA DEALER FOR INSPECTION. THE SERVICE MANAGER INFORMED ME THAT I HAD A PROBLEM WITH THE ABS BRAKE SYSTEM MODULE AND THE REPAIR WAS ABOUT $2,600.00. I PARKED THE VEHICLE BECAUSE IT WAS NO LONGER SAFE TO DRIVE AND TO MANY CLOSE CALLS. LATER I FOUND OUT THAT THIS 2006 TOYOTA HIGHLANDER HYBRID AND SEVERAL PROCEEDING MODEL YEARS HAD A VERY EXTENSIVE CONSUMER COMPLAINT NUMBER FOR THIS VERY SAME ABS BRAKE SYSTEM CONCERN. I CONTACTED THE SERVICE MANAGER AT THE SAME LOCAL TOYOTA DEALERSHIP ABOUT A WARRANTY AT WHICH TIME THE SERVICE MANAGER INFORMED ME THAT MY WARRANTY EXPIRED WHICH I NEVER WAS INFORMED. IT SEEMS TO ME PERSONALLY THIS IS HOW THE AIR BAG SAFETY PROBLEM WAS OVER LOOKED ON THESE VEHICLES UNTIL CONSUMERS LOST THEIR LIVES ON FAULTY CONSUMER PRODUCTS THAT GOT PROGRESSIVELY WORST OVER TIME. SEVERAL OF THE OTHER IMPORT MANUFACTURE HAVE OFFERED RECALLS ON THE VERY SAME ABS SYSTEM BRAKE CONCERN. TOYOTA HAS YET TO OFFER A RECALL SEVERAL MODEL YEARS INTO THIS SAFETY CONCERN WITH THE ABS BRAKE SYSTEM. IF WE AS CONSUMERS CAN'T STOP OUR VEHICLES WHILE DRIVING ON THE CITY STREETS OR HIGHWAYS ACCIDENTS HAPPEN AND PEOPLE DIE. THIS SAFETY CONCERN HAS GONE ON LONG ENOUGH WITH THOUSANDS OF COMPLAINTS OVER THE YEARS FOR THE SAME ABS BRAKE SYSTEM CONCERN. THERE MUST BE A MUCH BETTER JOB AT PROTECTING THE CONSUMER SAFETY FROM CONTINUED SAFETY CONCERNS NOT BEING ADDRESSED BY TOYOTA. ALL THE OTHER IMPORT MANUFACTURES HAVE STEP UP WITH RECALLS, WHATS TAKING TOYOTA MANUFACTURES SO LONG AFTER YEARS OF THE SAME SAFETY CONCERNS. PLEASE HELP US WITH THIS ABS BRAKE SYSTEM CONCERN.

I PURCHASED THE VEHICLE USED IN AUGUST 2018. IN JANUARY, WARNING LIGHTS INDICATED A 'VSC SYSTEM' PROBLEM. THE EVENT OCCURRED WHILE I WAS DRIVING. I RESEARCHED CAR REPAIR WEBSITES AND FORUMS, AND DISCOVERED THAT THIS IS OFTEN A SIMPLE PROBLEM WITH A SENSOR FOR THE FUEL DOOR, OR A LINKAGE IN THE ACCELERATOR ASSEMBLY. I FOLLOWED INSTRUCTIONS, AND THE LIGHT TURNED OFF. OVER THE PAST SIX WEEKS, THE LIGHTS HAVE RETURNED, USUALLY IN ASSOCIATION WITH REFUELING THE VEHICLE. I TOOK THE VEHICLE TO A DEALER TODAY, AND WAS INFORMED THAT AN ABS ACTUATOR WAS FAILING. THE PART IS $1700 FROM TOYOTA, WITH LABOR TOTALING $600. FURTHER RESEARCH REVEALED THE PROBLEM WAS WIDESPREAD, BUT THE ONLY REMEDY WAS A 'WARRANTY ENHANCEMENT' THAT HAS ALREADY EXPIRED. I CANNOT AFFORD THIS REPAIR, AND I WAS NOT INFORMED OF THIS ISSUE AT PURCHASE. BECAUSE THIS ISSUE WAS CRITICAL FOR VEHICLE SAFETY, I FELT THE NEED TO ALERT THE NHTSA TO A CONTINUING PROBLEM.