2010 TOYOTA HIGHLANDER HYBRID Complaints

THE HYBRID INVERTER FAILED WHEN ACCELERATING FROM A RED LIGHT. A LOUD CLUNK WAS HEARD AND THE CAR WOULD NOT MOVE FORWARD. THE ENGINE WAS STILL RUNNING BUT CAR WOULD NOT ACCELERATE AND HAD TO BE PUSHED OUT OF THE ROAD. "CHECK HYBRID SYSTEM" WARNING FLASHED. CAR WAS TOWED TO A DEALER WHO CONFIRMED THAT IT WAS NOT COVERED BY THE WARRANTY AT 9 YEARS, 117K MILES (WARRANTY IS 8 YEARS, 110K MILES). THE PREVIOUS RECALLS FOR THE HYBRID INVERTER HAD BEEN COMPLETED ~3 YEARS AGO AND SO THE RECALL ALSO WOULD NOT COVER THE REPAIR. THE QUOTED COST OF THE REPAIR IS ~$11K.

ALL DOORS AND HATCH DO NOT LOCK WITH THE KEY FOB OR WITH THE POWER LOCKS ON BOTH THE PASSENGER AND DRIVER SIDE DOORS.

ABS - CODE -1391,THIS IS SECOND TIME,FIRST TIME(2016) WAS CHANGED THIS PART -44510-48080

WHILE USING THE TAILGATE CLOSE BUTTON ON THE KEY FOB,CAR SHUT OFF AND PARKED, A LOUD BANG WAS HEARD WHILE THE DOOR WAS CLOSING AND THE DOOR JAMMED, SLIGHTLY OPENED AND IMMOVABLE. HAD TO TAKE THE CAR TO A CERTIFIED TOYOTA REPAIR FACILITY TO GET THE CLOSING SERVO DISCONNECTED SO THE DOOR WOULD SHUT. MANUAL OPERATION OF THE DOOR IS THE ONLY WAY TO OPEN AND CLOSE AT THIS TIME. NOTHING WAS BLOCKING THE DOOR AS IT WAS CLOSING AND COMPLETE REPAIR APPEARS TO BE VERY EXPENSIVE. BACK DOOR HINGES APPEAR TO BE SLIGHTLY OUT OF LINE BUT DOOR WILL CLOSE MANUALLY. T-SB-0038-15 ADDRESSES A PROBLEM SIMILAR TO THIS BUT THE DOOR WOULD OPEN - IN THIS CASE IT WOULD NOT UNTIL THE TOYOTA SERVICEMAN REMOVED THE SERVO.

I ALMOST GOT IN TO AN ACCIDENT ON 5/11/2018 DUE TO THE ABS SYSTEM NOT STOPPING THE VEHICLE WHILE DRIVING IN I-95. I GOT A WARNING LIGHT ON THE DASH AS I WAS PRESSING THE BRAKES, LATER THE CAR DID NOT WANTED TO STOP, BUT IT DID NOT PREVENT ME FROM HITTING THE OTHER CAR. I PRESS ON THE EMERGENCY BRAKE AND I WAS ABLE TO STOP THE CAR. LATER, I TOOK THE CAR TO GET DIAGNOSE AND PUT ERROR CODES C1391, ABS ACCUMULATOR LEAK OR MALFUNCTION. CONTACTED DELRAY TOYOTA IN DELRAY BEACH, FL AND THEY DENY TO DO A RECALL WHEN THERE IS AN EXTENTED WARRANTY RECALL ON CAMRY AND PRIUS MODEL LINE FOR THE SAME PROBLEM. CALLED TOYOTA CORP. AND THEY ARE DENYING TO DO ANYTHING TO FIX THE SAFETY PROBLEM WITH THIS VEHICLE. THEY STATED THAT SINCE THERE WERE NOT ENOUGH BUYERS FOR THIS MODEL, THEY WILL NOT COVER OR MAKE A RECALL ON SAFETY FOR THE PUBLIC. I HAVE FOUND OVER ALL THE INTERNET COMPLAINTS ABOUT THE SAME ISSUE. I AM LOOKING FOR A RESOLUTION. A PICTURE OF THE ERRORS CODES ON THE VEHICLE IS INCLUDED ON THE COMPLAINT.

DEFECTIVE INTERMEDIATE STEERING SHAFT. CLUNKING, ETC. SEEMS DANGEROUS, NO RECALL.... THIS IS ONE COMPLAINT TO ADD TO THE NUMEROUS OTHERS. TOYOTA, WHEN ARE YOU GOING TO DO SOMETHING ABOUT THIS?

I WAS DRIVING TO PICK UP MY SON WHEN A BRAKE MALFUNCTION WARNING LIGHT CAME ON INDICATING A PROBLEM WITH ABS SYSTEM. AFTER PICKING UP MY SON I WENT DIRECTLY TO THE DEALER AND THE FOUND THE PROBLEM WAS GIVEN BY CODE C1391, A BRAKE ACCUMULATOR VACUUM LEAK. WAS TOLD VEHICLE WAS UNSAFE TO DRIVE WITHOUT REPAIR, INTERNAL PRESSURE LOSS COULD PREVENT CAR FROM STOPPING IN A PANIC SITUATION. ALTHOUGH IT APPEARS THIS IS COVERED BY WARRANTY EXTENSION FOR SOME MODEL YEARS OF HIGHLANDER, CAMRY AND PRIUS, TOYOTA WOULD NOT EXTEND SAME COURTESY TO ME, NOR WAS DEALER ABLE TO OFFER ME A GOODWILL ADJUSTMENT. PUMP ASSEMBLY AND ACTUATOR ASSEMBLY PARTS AND REPAIR COST ABOUT $5300.00. VEHICLE WAS PURCHASED NEW FROM THE DEALER, HAD ALL RECOMMENDED AND NECESSARY MAINTENANCE AT DEALER ON DEALER SCHEDULE. *BF *TR

VERY COMMON PROBLEM IS BEING REPORTED IN ALL OF THE HIGHLANDERS OF 2008 FORWARD. AT LOW MILEAGE, THE STEERING COLUMN HAS A BEARING IN IT CALLED A STUB SHAFT BUT APPARENTLY GETS LOOSE LEAVING TO A CLUNK AND LOOSENESS IN THE STEERING. IT IS SO COMMON THAT OUR DEALER HAS TO KEEP MULTIPLE REPLACEMENT PARTS IN STOCK. PEOPLE ARE REPORTING THIS WITHIN THE 36,000 MILE WARRANTY, MY CAR BEGAN TO DO IT AT ABOUT 60,000 MILES. IT IS A $700 REPAIR. LOSS OF CONTROL OF THE VEHICLE IS POSSIBLE.

ACCELERATOR MOVED TO FULL SPEED AS BACKING UP BEGAN. AUTO PLOWED 110 FEET FULL SPEED THROUGH PLANTS AND TREES, COMING TO A STOP BY SOME TREES. CAR WAS PARKED ON PRIVATE DRIVEWAY. DRIVER SLIGHTLY INJURED. REAR END CAR DAMAGE IS $6,000+.

DOOR LOCKS ON PASSENGER FRONT AND REAR, DRIVER FRONT AND REAR, HAVE ALL BEEN REPLACED OR REPAIRED AT LEAST TWICE DUE TO MALFUNCTIONS. AS OF DECEMBER 2015, THE LOCKS ARE FAILING AGAIN FOR A THIRD TIME, CREATING A SAFETY HAZARD. LOCKS DON'T WORK. THEY WILL EITHER STAY LOCKED, FAILING TO OPEN, OR NOW, THEY WILL NOT LOCK AT ALL. THIS IS AN ONGOING PROBLEM THAT HAS NEVER BEEN FIXED PROPERLY. KEEPS RECURRING.