2012 TOYOTA PRIUS Complaints

ABS/Brake Actuators on these cars are faulty! Not able to apply adequate pressure on the brakes to stop the car confidently. Brake actuator hissing notating that pressure is being lost. Brakes feel like they are skipping, and also making a loud "quack/screeching" noise. Brakes were inspected on my vehicle, and the pads had over 60% life left, and no damage to the rotots, so its the brake actuator at fault. A very common issue on 3rd generation prius models, and a $3000+ repair through toyota. Customer support program ZJB issued. Its not a recall, but instead an "extended warranty". Toyota will not fix the problem without dash warning lights on, so my car is just waiting to break down or cause an accident. I worry about my life and the brakes failing at some point. Ive taken it to two different mechanics and they both noted its a well known problem that toyota is trying not to pay out for.

After feeling looseness from the front end all the way up to the steering wheel when going over any bumps I brought the car to the local dealer. After inspection I was told four things that are very disturbing: The steering shaft needs replacement; The cost will be more than $1100; There is no warranty or recall or cost coverage; The car is not reliable and should not be driven any more than essential until fixed (and they don’t know when the parts will be available). Although the car is out of warranty based on age, this car has only 66,525 miles after almost 9 years, and my wife and I have been the only drivers and not on any dirt roads. I have been told by an independent repair shop this is a known problem with Prius and should be a recall item since it is dangerous to keep driving. This is especially troubling since the dealer could not fix it when I was there because they have to order parts and they don't know when the parts will be in.

I was driving going 45mph when my car shut off and wouldn't start back up. It almost caused an accident from it stopping in the middle of the highway. The master warning light, brake system warning light, warning buzzer ABS warning light and the slip indicator light came on as also the message center reading to have the hybrid system checked immediately. I did have ot towed on for a diagnosis and it came back saying i needed a new inverter power module this will cost $2000 . i cant afford that. I read all over the internet how there is. Safety recalls. When i called toyota they said there are no recalls so now im stuck paying this. Not happy at all!!! If there are anymore 2012 prius with this problem please write a complaint so we can get this on recall and have the company cover the cost of repair.

I write to report that I asked for help at TOYOTA on the repair of the brake booster pump program. On August 19th, 2021 I took my Toyota Prius 2012 to my nearest dealer, in this case, Toyota of Homestead in Florida, US (I have a screen capture of the appointment); because the brake pump was pumping continuedly every 15 seconds regardless of the vehicle was in motion or stop parked; also the breaking felt like spongy and hesitant. I explained that to the Toyota dealer employee and he told me that the pump running every 15 seconds is not normal and agree that something was not right with my car's brake, but if there is not a MIL light ON, they can not replace my brake booster under the Toyota Program, and I have to pay $170.-first to "scan" the vehicle and make a diagnostic, well I told him that was too much money just to scan the vehicle since there was no light on in the dash the Toyota employee told me I will need to pay for the full brake pump replacement. That was unfair because the Toyota employee agree that definitely the brake was bad, but can not do anything. Took my car home and a few days later September 2nd, the brake lights came on. Well, my wife uses this car daily to transport our kids to school and to do the shopping necessary for food and supplies, and definitely, the cars do NOT break AS IT SHOULD. Toyota employee told me the repair will cost between $3000.- to $4000.-, I took the car to the Dealer when was covered under the Customer Support Program, but the light on the dash should NOT be the main factor to determine that the brake booster needs to be replaced. To be fair TOYOTA should recall all those vehicles. The Toyota dealer employee witness that there was a problem with the pump, and anybody with common sense that know this cars should immediately notice that the sound of the pump going on every 15 seconds is NOT NORMAL. This is my second Prius (My first one was a Toyota Prius C 2014) and I detect almost immediately with something is WRONG.

ABS Actuator and Booster Assembly failing. No recall was issued but a safety bulletin to the dealer with a cutoff date and nothing issued to consumer to know it needs to be replaced. Now I am outside their service bulleting window with a 3,000 repair that should be covered indefinitely by toyota

My wife hit a deer at highway speed. The airbags deployed. The drivers side lower airbag deployed in the footwell. The driver was unable to get to the break paddle to stop due to the airbag at het feet. She had to use the emergency brake to stop the vehicle. That worked, but she had limited vision of the road ahead and it took some time for her to think of using the emergency brake.

I was driving with my 10 year old son on local city streets. I was approaching a busy intersection while going approximately 35 miles when my car just turned off with an error message about the hybrid system failing. I stopped the car and put it in park while trying to turn the car back on, but I kept getting the same hybrid system error message. While the stoplight was red, I got my son out of the car and over to the sidewalk because this was a dangerous situation where anyone not paying attention could've slammed into my stalled car (see picture of black Toyota Prius). I called AAA to get it towed. About 20 minutes later, a cop car pulled up to block my stalled car and then got it pushed to the side of the road (picture attached) because of how dangerous it was sitting there blocking traffic at a major intersection. My car was taken to Cabe Toyota dealership where they diagnosed it with a failed IPM card, which would cost around $4,000 to replace. I did a simple Google search and found that 80,000 Prius from 2012 - 2014 have been recalled for this EXACT reason. There have also been class action lawsuits surrounding this IPM failure due to its extreme safety risks to anyone inside a car that will just die in the middle of driving it, especially when their fail-safe system does not get triggered with this particular IPM failure. As of right now, the car is available for inspection because it's still at Cabe Toyota. The invoice shows that the IPM card needs to be replaced. There were NOT any warning lamps, messages, or other symptoms prior to the car shutting off while driving it. It had been running just fine.

The contact owns a 2012 Toyota Prius. The contact stated while attempting to use the horn, the horn failed to operate as needed. The contact also stated that the front passenger’s air bag warning light illuminated and then turned off. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the clock spring failed and needed to be replaced. The vehicle was also taken to an independent mechanic who confirmed the cause of the failure. The vehicle was not repaired. The manufacturer informed the contact that the vehicle was not included in the manufacturer communications regarding the clock spring assembly repair. The vehicle was not repaired. The approximate failure mileage was 90,000.

I was in freeway going home last night after visiting my mom by point loma area San Diego. I was on 8fwy going east, then I merge to 805fwy South which I always and usually take same route. As I went on ramp of 805 South going on a steep high altitude, my 2012 PriusV stall and I can't accelerate when I was stepping into my gas pedal which I have already pushed it all the way in. So I quickly put emergency lights on and slowly guided my car to the right shoulder. I called AAA which I've been a member for so many years. And believe me it is really a life saver. This safety could have been worst from my experience of been driving for more than 30 years. I got it towed all the way home which was about 7 miles. The traffic was heavy on a Saturday night and I waited for almost 2 hours for my towing. When I got up this late Sunday almost noontime, I went out to check on my car and it is still saying "Check Hybrid System" with all the lights on my module was on. I started it and noticed there was an acceleration so I drove it back to my driveway since the tow truck just drop it off on the curveside close by my residence. It drove ok, and then I started my research online and I recently bought a code reader but not sure if it will work on my hybrid 2012 Prius V. Nothing came out on the reader. I called my buddy which was a certified ASE mechanic but has less experience on hybrid. But he has a more expensive code reader and analyser equipment and tools. I also check the Toyota headquarters and you website about my car on safety recalls. I just had taken this vehicle to the dealer for some sort of worldwide safety recalls on all this typical model. I've also read an additional recall and they just have launched it 01/2019. I've plug in my vin# on all of this sites for a check but nothing is coming out. But their complaint is similar to what's going on to my car. It's "Check Hybrid System" and I believe it's the Inverter issues. Please update me and also the Toyota HQ.

The brake, abs, and stability control light come on and the brakes require more pressure to work . getting a code C1391 Abnormal Leak in the Accumulator. but I was never informed of this recall and there are no open recalls associated with my car