2012 TOYOTA PRIUS Complaints

While driving on the interstate I went to slow down to merge and my brakes failed. The following warning lights came on: Master Warning Light (yellow), Brake System Warning Light, Brake System warning light (red), ABS Warning Light, and the Slip Indicator light. My vehicle was towed to a Toyota Dealership and after running a diagnostic test, they confirmed that it was the "Break booster with accumulator c1391 stored internal leak of accumulator and need immediate attention" which they quoted at $4,295.68 to fix. After researching the issue saw A Customer Support Program 20TE07 was issued taking responsibility for the faulty Brake Booster Pump Assembly however only covered the repair for a two-year period and only if it was one of the identified diagnostic trouble codes listed in the CSP issued by Toyota but expired in Feb 2022. The code pulled from my vehicle 3 days ago was listed in this document, but the coverage only covers until Feb 2022. This is not a normal wear and tear issue, it is a faulty part that Toyota identified as a life and death safety concern but refuses to do anything about because mine didn't show an issue within their 2-year CSP timeframe. Toyota identified that there are roughly 118,950 2012-2014 model year prius V with a production period of late September 2010 to mid-November 2014 vehicles that this faulty part affects along with everyone else on the road with these vehicles as it causes failure of the brake booster pump assembly, which leads to a loss of braking assist and the deactivation of the Vehicle Stability Control system. For the safety and lives of the owners of these vehicles and all of the other lives of the drivers on the road that this could affect in the case of this faulty part should there be a catastrophic accident, like mine could have been, a nationwide recall on this part MUST be issued.

My Prius, along with the thousands of others this has apparently happened to according to a quick online search, has had the C1391 code appear, indicating a failed brake actuator and accumulator. It, like the thousands of Priuses from this generation, have had these faulty brake pump systems develop a leak and begin to fail. You will hear a whirring and hissing noise constantly when it starts going out, eventually resulting in a Christmas tree of dash warning lights and reduced braking due to a failsafe kicking on. Toyota apparently issued a "customer service bulletin" that is now ineffective as it only covered if you had the system fail within 10 years of manufactor or 150,000 miles AND had the codes appear. Most people's Priuses go out AFTER this, unless you're driving it like you stole it. It is a hefty repair too, being quoted at over $3000 at the Toyota STEALSRSHIP!! I have since gone to an independent mechanic and had one portion replaced in hopes that would fix the issue, but it turns out both the actuator and accumulator are needed to be replaced, which is extremely expensive, more so for the actuator than the accumulator, but still exorbitantly expensive. In conjunction with this, Toyota further added difficulties by making their paet numbers they have listed different from the mark number engraved on the part, so buying third party is made a bigger hassle by this as they will not know for certain the part number. This is a huge safety concern as this affects the vehicle's ability to brake. Their service bulletin was the equivalent of offering people bandaids years before they'd be anywhere to getting a cut!! Please investigate and please please PLEASE lead to Toyota issuing an actual recall, regardless of miles or year from manufacture. More and more Priuses are reaching the time where this will occur and it's a huge safety concern, if not an environmental concern when people start disposing of Priuses due to this massive failure with hefty repair bills.

The brake booster and brake booster pump assemblies had to be replaced at the dealership. Parts are not available for inspection as far as I know. We were warned by the dealership that we should not be driving the car because the brakes could completely fail at any moment if we didn't have parts replaced. That would have been dangerous for us and anyone else sharing the road with us. On a Sunday, leaving our house and driving down our street, three lights turned on on the dashboard display - traction, brakes, and ABS - and the brakes felt softer and less responsive than normal. After having gotten a diagnosis and repair estimate from the dealership, we carefully drove the car home to consider our options. We tried to get a second opinion from a trusted mechanic, but it sounded like the parts we needed were tightly monitored by Toyota and the original estimate for the repair from the dealership was above $3,000. After a few days, the dashboard warning lights turned off and the brakes felt back to normal. The whirring noise which had been happening roughly every 4 seconds had slowed to roughly every 10-12 seconds. We were told that this turning off of the lights sometimes happened, but that the issue was still the same. Prior to these lights turning on, the car had been making a lot of the whirring noises for some time, but it had never thrown the codes before that would have been picked up by a mechanic. At the time, we didn't recognize the sounds as a sign of an impending commonly recognized failure - only after doing some research did we find that this was a very common problem for a lot of Prius owners, especially for the given year and number of miles we had. There is an "extended warranty" for this part and repair, but while we were within the mileage limit, we were outside of the time limit and we were told at the dealership that Toyota would be inflexible about paying for the repairs.

I am writing to express a complaint regarding the issues I have experienced with the brake system of my Toyota Prius C, 2012 model. For the past several months, I have noticed that the brakes exhibit strange noises, soft pedal sensation, reduced braking efficiency, were driving and the ABS, traction, brake, and that other light turned on and the brakes became slow these issues have been observed on multiple occasions and pose a safety risk to myself, other drivers, and pedestrians. I have taken the vehicle for inspection, but the problems persist or have not been definitively resolved. I believe these faults may be related to defects in the braking system, and therefore I request a thorough inspection and necessary repairs at no cost, considering that the manufacturer could be responsible for manufacturing defects.

While driving my 2012 Toyota Prius, the traction control, brake, and ABS warning lights all came on at the same time. I used a home OBD scanner but it didn’t show any diagnostic codes. After some research and inspection, I discovered that the issue was related to a faulty brake booster and accumulator—something I’ve learned is a common problem with this model. I was relieved to hear that Toyota has an extended warranty on these parts. However, last night while driving, the brakes suddenly stopped functioning properly. It became very difficult to slow down, which put me in a dangerous situation. I’m deeply concerned about the safety risks this defect poses and believe this issue deserves further attention.

The contact owns a 2012 Toyota Prius. The contact stated while driving 30 MPH, the ABS and traction control warning lights illuminated. The contact stated that while attempting to depress the brake pedal, the vehicle hesitated while responding. The contact stated that there was a buzzing sound coming from accumulator pump. The dealer was contacted. The contact stated that the failure had occurred on several occasions. The vehicle was taken to Nico's Auto Repair where it was diagnosed and determined that the brake booster and accumulator assembly needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 140,000.

This Prius Hybrid is my [XXX] mother's car which she got thinking is was a very safe and reliable vehicle. She purchased the vehicle from a Toyota dealership here in Maine on [XXX]. Last week while driving down the road, all of a sudden, every brake warning light lit up the dashboard and the brakes became extremely unresponsive. It scared us both to death but thank goodness, I was driving when this happened. After doing some research, I have discovered that this a very well known brake issue with the 2010-2015 Prius cars. I cannot for the life of me understand how this major safety defect has not been made into an actual safety recall. I did contact Toyota customer service and they will not help us at all. Even though my mother has only had the car for just under 9 years and is well under the allotted mileage, they said their Customer Support Program (ZJB) only covers 10 years from the day the car was first driven after production. Her Prius now is inoperable and the repair costs are in the thousands. We are so incredibly disappointed with Toyota and the safety board for allowing this to happen to all of the defective Prius owners. I hope you will reconsider and do the right thing and recall these cars before someone does get into an accident where they are injured or killed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am reporting a sudden and dangerous failure of the brake booster in my 2012 Toyota Prius. While driving, I experienced a loss of braking power, accompanied by several warning lights including ABS, Brake, and the Traction Control system. The brake pedal became extremely stiff and unresponsive, significantly increasing the stopping distance. This failure nearly caused an accident, as I was unable to stop quickly enough when traffic slowed unexpectedly. This issue happened without warning and is a serious safety risk. I later discovered this is a common and widely reported defect in 2010–2015 Toyota Prius models. Toyota issued an extended warranty (Customer Support Program ZE3) to cover this known brake booster defect — but only for vehicles within 10 years or 150,000 miles. While my Prius has well under 150,000 miles, it is just over 10 years old, which disqualifies me from coverage, leaving me with a repair estimate over $4,000 for a well-documented manufacturer defect. This seems grossly unfair, especially for responsible owners with low-mileage, well-maintained vehicles. Toyota’s refusal to issue a formal recall and instead offering only limited support puts millions of Prius drivers at risk. A brake system failure of this kind should qualify as a safety defect and trigger a mandatory recall, not a quietly limited program with arbitrary expiration dates. I urge NHTSA to investigate this issue further and consider a recall of the defective brake booster system in these Prius models to protect public safety and ensure fair treatment for affected owners. Thank you.

On three of the four tires at different times the tires were separating. They had bulges in the tire. Caused extreme vibration and noise. The last tire was today with 22k miles. The other two were a year ago with 15k miles. I’ve had to replace all 4 tires

The contact owns a 2012 Toyota Prius V. The contact stated that while driving at an undisclosed speed, the service brakes warning light illuminated. The vehicle was taken to the dealer, who diagnosed failures with the brake booster assembly and brake booster pump assembly. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21TE01. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.