2012 TOYOTA PRIUS Complaints

On 10-17-24 these warning lights came on: 1. Pre-collision System 2. Hybrid System 3. Airbag 4. Safety Connect red light And Intermittently: 1. Slip Indicator 2. Brake System Cruise control would not set, and displayed "E3". ------- Component failed: Dealer determined that the driver's side door harness had been chewed by a rat that had entered the under dash area "somehow". They said it couldn't be repaired but must be replaced. My insurance deductible was $500 and they paid the balance of the $1,387.06 bill. (I have retained the harness, which could have been repaired by splicing the two wires connecting to the driver's side airbag collision sensor. The labor to splice the wires would have been less than an hour.) ------ Safety: The chewed wire apparently disabled the Airbag, Pre Collision, Emergency Automatic Braking, Seatbelt Pre-Tensioning, ABS, and Stability Systems. ----- The dealer confirmed the problem. ----- My insurance adjuster did inspect the harness. ----- I placed electronic rat traps in the vehicle, which killed three rats. ========= NEXT ========= ALL THE SAME WARNING LIGHTS CAME ON A FEW MONTHS LATER! I didn't throw more money at the Dealer, and took off the panels to inspect the wiring myself. There was damage to the passenger side door harness wires. I removed the harness and ordered a $60 used replacement on Ebay. While waiting for delivery, I researched rat damage to Toyota wires, and how rats could possibly enter the interior of the car. I discovered that there is an UNSCREENED 12x9 inch opening to bring fresh air into the HVAC system. It is hidden under the windshield wiper cowls. Also, there are two UNSCREENED vents in the trunk area. Other Prius owners covered those openings with 1/4 inch metal wire hardware cloth. I spent a few hours disassembling, covering, and reassembling pieces to prevent further access through the fresh air intake, and will do to the rear next. TOYOTA should recall these cars and ratproof the harnesses

Brake booster failures are a common safety issue with 2012-2015 Toyota Prius' this one included is starting to fail which can lead to ABS deactivating and shorter braking distances. There was a recall for this part but most tend to fail after the warranty period. Leaving many vehicles unrepaired and dangerous.

My brakes began making a funny noise when I used them. I only have 80000 on the car and do regular maintenance. I took it in because it seemed the brake pedal was getting spongy as well. They ran in through diagnostic tests and determined the braking module or brake booster/master assembly was bad. This seems to be an issues with Toyota and should be addressed immediately. It is an expensive fix for a low mileage car

47050-47180 47070-47060 Both failed at same time along with many others getting quotes of 3500-4000 to replace no brake control or anti lock brakes

Toyota installed known faulty brake booster and master cylinder systems in Prius C models manufactured 2012-2014. Knowing these systems would fail, but not wanting to pay for their mistake, they created a basically secret "extended warranty program" for owners to get their brake booster replaced ONLY IF for a specific 2 year time frame their brakes failed with a certain DTC code. Knowing that many prius owners would not actually receive the notification nor had driven their vehicle enough miles for the braking system to fail, they got away without having to correct their issue. The brakes literally just fail and stop working in the middle of the highway, causing extreme safety concerns and accidents with no responsibility from Toyota.

The accelerator wasn’t pushing down after I turned a corner then the lights in attached photo appeared. The power inverter needs to be replaced and since my car had the J0V software update in 2/2019, and the recall update came out in 3/2019, it was not linked to my vin as it should’ve been. The update to J0V (attached) should have been posted w my vin, correct? They are fixing it under customer support but refuse to tow it or give me rental bc they are saying it isn’t a recall issue, when the document below says it applies to all cars that needed J0V. I want to be sure all cars that had recall service before the March2019 update get this update linked to their vin.

Subject: Safety Complaint – 2012 Toyota Prius Brake Booster Failure (C1391 Code) I am writing to formally report a serious safety defect in my 2012 Toyota Prius involving the brake system. Recently, my vehicle’s dashboard displayed the ABS, traction control, and brake warning lights, indicating a critical braking issue. Upon diagnostic testing at a Toyota dealership, the vehicle was found to have DTC Code C1391 – Brake Booster Leak/Accumulator Failure. I later discovered that Toyota acknowledged this defect and issued a Customer Support Program (CSP) to cover repairs. However, I was never notified, despite always servicing my vehicle at Toyota dealerships. When I contacted Toyota, they confirmed that my vehicle has been flagged in their system, yet I was never received anything in the mail about the potential brake failure. Toyota initially set the CSP expiration in 2023, later extending it to May 2025, but they have refused to repair my vehicle under this program. The estimated repair cost is $4,680.09 along with a diagnostic fee of 206.09, which is a significant financial burden for an issue stemming from a known manufacturing defect. Most importantly, this is a major safety hazard: My brakes now produce a loud hissing sound when pressed, indicating imminent failure. If the brake booster fails completely, it could result in a loss of braking power, endangering myself, passengers, and others on the road. Numerous Prius owners have reported similar failures, yet Toyota has not issued a formal recall. I urge NHTSA to investigate this defect further and push Toyota to issue a full recall instead of a limited support program that many owners were unaware of. Given the life-threatening nature of brake failure, Toyota should not be allowed to limit coverage or deny repairs for a problem they have long recognized. I respectfully request that NHTSA take action to ensure Toyota addresses this safety defect responsibly.

The styrofoam padding of the headrest came unglued from the plastic base of the headrest. This was discovered when removing fabric to wash the fabric. Car was not driving at the time.

My break actuator goes off every 12 seconds continuously. There is no warning sign in the dash board. Brought the vehicle to the Toyota dealership and had it checked out. The dealership says there is no problems according to their analysis. But the actuator continuously goes off every 12 seconds and the dealership said this was "normal" and charged me the service fee. I am seriously concerned because I drive this car with my child and I am reading that this is a bad sign and that the breaks might fail at any time. Since the dashboard doesn't give me a warning sign and the dealership says there's no problems based on their diagnostics, even if everyone can hear the actuator go off ever 12 seconds I guess I can safely drive this vehicle...it seems like driving a ticking disaster waiting to happen.

ABS pump and master cylinder malfunction. Pump is running very often. Hard braking makes it sound abnormally.