2012 TOYOTA PRIUS Complaints

I was driving down the interstate with my cruise control on when all of a sudden the cruise control disabled and warning lights came up on my dash board. It still drove fine for several weeks. On Friday December 6th, I was going down the road and had to press the brake slightly for a car turning. When I pressed the brake, the car went into a spin. It spun a couple of rotations. Luckily I was on a wide part of the highway and no oncoming cars were approaching. Toyota had a recall for the same code and parts for the 2010 Prius but did not include the 2012 Prius. They just had an alert which I did not receive because the notice went to the former owner. However, I did take my car in for oil change and diagnostic but they did not tell me that there had been a problem with these parts. They want almost $4,000 to repair it. Why would they not include ALL vehicles with this same part. If it fail on one, it will fail on another. I think Toyota should make them all good. Please make them issue a recall for all of these parts. I took my car to a mechanic but because of special tools needed, you have to take your car to the dealership for repairs. When I called the dealership, I was told I needed a break booster pump and a brake master cylinder for a total of $3, which is ridiculous on a $7,000 car.

I write to add my voice to the litany of complaints in support of NHTSA investigation DP23005. While on an road trip recently the ABS, Traction Control, and Brake warning lights all came on. The brake felt squishy and didn't seem to be functioning as confidently as before. I altered my driving (giving plenty of distance, lowering my speed) so that in the event the brakes quit working I would have an exit strategy. I took it to my Independent Service Center as soon as possible who found the code C1391 and diagnosed the need to replace the master cylinder / booster assembly for several thousand dollars. Of course I must do this in order to remain safe but this is clearly a safety issue that could have been catastrophic. Meanwhile I am out of a car for several weeks until the part arrives and out of at least $2000 as quoted by my mechanic ($1640 for the part). The car only has 146,500 miles on it so otherwise would have plenty of life left in it. I'm filing this complaint to add my voice to the open petition and toward the NHTSA's investigation in strong support of holding Toyota responsible for PREVENTING injury and death through a proper recall, as well as against burdening the car owner with the costs of making up for Toyota's negligence on this issue. At the least they need to cover the cost of these necessary safety repairs when they are warned by the lights and reinstate their warranty extension for this issue

I write to add my voice to the litany of complaints in support of NHTSA investigation DP23005. While on an interstate road trip recently the ABS, Traction Control, and Brake warning lights all came on. The brake felt squishy and didn't seem to be functioning as confidently as before. I altered my driving (giving plenty of distance, lowering my speed) so that in the event the brakes quit working I would have an exit strategy. I took it to my Independent Service Center as soon as possible who found the code C1391 and diagnosed the need to replace the master cylinder / booster assembly for several thousand dollars. Of course I must do this in order to remain safe but this is clearly a safety issue that could have been catastrophic. Meanwhile I am out of a car for several weeks until the part arrives and out of at least $2000 as quoted by my mechanic ($1640 for the part). The car only has 146,500 miles on it so otherwise would have plenty of life left in it. I'm filing this complaint to add my voice to the open petition and toward the NHTSA's investigation in strong support of holding Toyota responsible for PREVENTING injury and death through a proper recall, as well as against burdening the car owner with the costs of making up for Toyota's negligence on this issue. At the least they need to cover the cost of these necessary safety repairs when they are warned by the lights and reinstate their warranty extension for this issue ("POL18-03") which expired for my vehicle in August of 2021.

have suddenly brake failture, w code c1391, it problem persist car do not stop by pressing brake , it is too dangerous to drive this car!!!! what you can help me w this recall or rebate option for brake repair?

The Toyota Prius of this generation has a known defect in the brake booster pump assembly. About 2 weeks ago the dash lights came on for ABS, Traction control, general warning light. The brakes work but feel soft, and a motor sound pulses behind the steering column every 8-10 seconds. My mechanic pointed out it is a known problem where the ABS booster pump has a faulty valve that doesn’t allow proper pressure to build to engage ABS system. I cannot afford the Repair: $3890 for master cylinder and brake booster. My concern is that most people can’t afford this repair and without a functioning ABS system, people are put at risk from this generation of Prius. Toyota did offer a customer service program acknowledging the issue, but that program only helped if these issues occurred before 2022. With the known issue, why wasn’t a recall required? Toyota should be required to address this safety issue. How many of these Prius are on the road where customers are expected to perform a $4,000. Repair to keep up the safety standards. The car is available for inspection upon request. Thank you.

About three weeks ago, my daughter told me that several lights were on on her display. I checked and among them were the traction control and 2 other related to the brake system. I looked up possible causes on the Internet and it seemed the brake booster/master cylinder could be a culprit, but then I checked the fluid reservoir and the fluid was low, so I topped it off, drove the car, pumped the brakes a few times and all the lights went off. About a week later the lights were back on. I checked all the lines and saw not visible signs of leaks and decided to take it to a mechanic. I took it to a local mechanic and I was told that the brake master cylinder with brake booster failed and had to be replaced. Afterward the brakes were repaired I went to 2 local Toyota dealerships to check the price of the parts. The first dealership provided the prices without any discussion. At the second dealership, the employee who waited on me, after I provided her the VIN and told her that I need the price of the brake booster/master cylinder,m told me that there was a service notice on the booster/master cylinder because of a high rate of failure and that I would have to check with the service department before she could sell me the part. This is concerning, if Toyota knew/knows that the part has a high rate of failure, why wasn't a recall notice issued?

I was driving and all of a sudden the emergency brake light, the ABS brake light and a couple more turned on and I had no more brakes. I had just driven 25 miles with it and stopped at many red lights along the way with no issue and NO WARNING lights. I could have gotten into a major accident if it had happened anywhere else in my route. Fortunately, I was about a mile from my house and the hybrid motor helped slow the car down. I was unable to stop at any stop sign in my development and here again was very fortunate that there were no cars along the way. Once I got home, I got it towed to Toyota and was told it is an internal failure of the actuator. I contacted Toyota America and was just told that there was a campaign to repair this but that I had passed the date. My car has only been serviced at the same Toyota in my city since I got it. I religiously brought it every 5000 miles. I am shocked that they never mentioned this campaign to me and that they didn't initiate a repair during the campaign. This is a major issue that needs to be addressed and Toyota needs to be held accountable.

1. The ABS system failed upon inspection at a dealership. Specifically the ABS accumulator and booster. 2. The ABS system put us at risk by failing prematurely, and traction control and ABS functions seemingly stopped working while driving on the road. 3. Yes, dealership confirmed the issue with a full diagnostic, and the part has a customer support program bulletin/TSB out for this specific issue. 4. inspected by manufacturer dealership service center. 5. Lights such as the parking brake, ABS, and (!) lit up while driving and the failure occurred at the same time.

Brake master cylinder and brake booster accumulator assemblies brake parts from this vehicle failed on another vehicle.

My actuator is failing. This is a known issue for Priuses and a danger to those on the road. Toyota issued a voluntary service program on these parts to avoid a recall and now many are on the road with actautors that should have been replaced.