2008 TOYOTA RAV4 Complaints

Starting in June 2018, I have had seven episodes of unintended acceleration. (I have owned the car, purchased in private sale, since June of 2013.) There were common elements to each incident:1. gradually slowing; 2. foot on brake; 3. engine accelerates sharply, a moment before complete stop in first six, a moment after in seventh and last. In each incident able to maintain control as foot already was on brake; yet in three of the incidents, including the last two, the car bucked forward a few inches despite the pressure on the brake. Situation resolved when I turned off the ignition, a reflex developed after the first incident. This last incident was particularly upsetting as I was in a long line of slow moving cars on a relatively narrow road with pedestrians on each side of my car. Each incident has been reported to the local dealer with which I have been trading for many years. They did a thorough inspection when I reported the incidents to them in January of 2020 and again just today after the last incident that occurred on May 19, 2023. They could find nothing wrong and include on their report "TAS STATES SUSPECTED DRIVER ERROR, PEDAL MISS [sic] APPLICATION." I do NOT accept this conclusion. I note in the last incident I had come to complete stop momentarily before the engine accelerated and despite my heavy pressure on the brake bucked forward, with control established only when I shut the engine down. During the entire period of these incidents I also have been driving two other vehicles, a 2008 Camry and a 2023 Camry. I have had no such incidents while driving these two cars. I do NOT drive with two feet, always the first question asked when such an incident is reported. Finally, I believe my car dates from a period when Toyota was vehemently denying such a problem in their cars when they knew full well that such was the case, a deception for which they were found criminally liable. Such history does not instill confidence in corporate Toyota.

The contact owns a 2008 Toyota Rav4. The contact stated while driving at various speeds, there was an abnormal knocking sound coming from the engine compartment. There were no warning lights illuminated. The contact stated that her husband checked the oil level and noticed that the oil level was low. The contact stated that two weeks prior to the failure, an oil change service was performed. The contact stated that her husband added oil; however, two weeks later he checked the oil level again and the oil level was low. The contact stated that the vehicle consumed one quart of oil every two weeks or approximately every 200 miles. The contact stated that the vehicle was taken to the dealer and the service manager stated that it was a known issue with the vehicle. The contact was notified of a TSB however, the vehicle was over the mileage. The manufacturer was not notified of the failure. The approximate failure mileage was 110,000.

Severe rust on frame and undercarriage. Other 2008 Toyota models were recalled due to the same rust issues. Unsure of when rust first started.

Vehicle suddenly lose power while the cars are being driven, the engine shut off, and catch on fire.

I was starting to back out of my driveway and my steering wheel made a loud clunking noise and became free floating. The plastic air vent fell on my right foot. I did not attempt to drive the car after this incident. I had it towed to Toyota Service. I was told that the steering bracket had come loose and that they had never seen anything like it before. I did some online research and found that this has happened many times with 2006, 2007 and 2008 Toyota RAV 4 vehicles. I believe there are even case numbers for some of them. It was determined to be a failed weld each time! If this had happened to me over the summer, when I was driving in the mountains it cold have caused a serious or even fatal accident. I don't understand why this hasn't been recalled?! This is very dangerous for the unsuspecting people driving RAV 4s! The repair estimate for this is over $5,000!

The driveshaft welds that held the power steering motor to the vehicle frame failed. This caused steering wheel to be loose and unstable and the power steering motor to slam against the floor vent. It caused it to fall to the floor near the pedals where it could have obstructed the brake or accelerator pedal

The contact owns a 2008 Toyota Rav4. The contact stated while driving 5 MPH, there was smoke coming from the front of the vehicle. There was no warning light illuminated. The contact pulled over to inspect the vehicle and became aware that the alternator was smoking. The vehicle was turned off and towed back to the residence. The contact purchased the alternator and fixed the vehicle. Neither the dealer nor the manufacturer had been notified of the failure. The approximate failure mileage was 126,000

The contact's daughter owned a 2008 Toyota RAV 4. The contact stated that his wife was driving with their daughter on the highway at approximately 65 mph. The contact stated that his wife said no warning lights were illuminated. The contact's wife reported that the vehicle began to make a loud buzzing noise from the engine. The contact's wife was able to pull over on the road shoulder when she noticed smoke issuing from under the hood. The vehicle burst into flames from under the hood. The contact's wife and daughter jumped out of the vehicle, the daughter burned the palm of her right hand. The police and fire department arrived. The police attempted to extinguish the fire and called the fire department which extinguished the fire with water. The vehicle was undrivable and the police had it towed to an impound lot. The police nor the fire department issued a report. The daughter did not seek medical attention for the burn on her right hand. The contact said that the insurance company will inspect the vehicle this week. The contact said the vehicle was completely burned. The manufacturer was informed of the failure. The failure mileage was approximately 150,000.

Making knockings/wobbling sound when steering wheel turning left or right while driving. Sound increases everyday with van driven. This problem started about 2 months ago. I reported this problem to Toyota Coustomer Service Last week. This is very serious issue as a safety of a Van. I have several problems with Van It is Lemon

This vehicle will not pass inspection due to unsafe frame/rotted frame. I've brought it to three different shops to see if it was just one area of the frame, but the whole framework has been declared unsafe. It has been well cared for and is in excellent condition otherwise and since it's well known that the Toyota frames have a long-standing bad reputation I feel I should get a frame replacement. Its scrap value is just $200! A massive rip-off to me!