2015 TOYOTA RAV4 Complaints

The contact owns a 2015 Toyota Rav4. The contact stated that while the vehicle was parked or being driven, water was leaking into the vehicle from the roof, causing water damage to the electrical wiring to the air bags. A dealer was contacted. The vehicle was taken to the dealer, where it was determined that there was a hole in the roof and that the roof needed to be removed for a proper investigation. The contact was informed that the air bags could unintendedly deploy unintentionally if not repaired. The vehicle was not repaired. The manufacturer was notified of the failure via letter and phone calls, and the contact was informed that the case had been closed. The approximate failure mileage was 65,000.

While driving a 2015 Toyota Rav4 (w/AWD) the vehicle's steering wheel started to shake and the vehicle lost acceleration. The check engine, AWD, and traction (trac) control lights illuminated. After pulling the vehicle over I tried calling AAA. After about 30 minutes, the warning lights went out. I decided to try to drive it home. After about 5 miles the same thing happened. However, after slowing down the problem went away. I called a Toyota dealer and requested a recall service (to fix the power steering assist). They scheduled the appointment and I dropped the vehicle off. When the vehicle was ready I discovered that they only performed the recall for the battery terminal. They informed me that there was no other recall for my VIN number. This problem should be on recall as I've researched and discovered many other complaints similar to mine. These situations like mine, and many others, are safety issues and could easily lead to injury and/or death.

There is an intermittent loss of the electric power steering assist. The car can't be steered during this loss of power, leading to an extremely high risk of a crash. Toyota issued a recall for the 2015 RAV4 for this exact problem, but they did not include my car's VIN in the recall. The problem has not been confirmed, as Toyota informed me that this could only be done at my expense. The vehicle or component has not been inspected for this problem. There have not been any warning lamps, but it's very obvious while driving that the power steering has failed.

Was driving on the freeway on my way to work and suddenly i heard this loud pop. I didn't know if a vehicle next to me had a tire blow out or if i had a tire blow out. I pulled over and i checked my car and then i looked on the roof as that is where the loud pop came from and i saw my sunroof broken with a hole in the middle.

I was driving on the freeway to work. It's a 40 minute commute I make every day Monday to Friday. Half way to my destination, I heard like a loud pop or explosion sound. There was an 18 wheeler on the middle lane to my right and I thought one of its tires exploded and a piece landed on my roof. It felt like something landed on my roof or hit it hard, but not sure what. I also thought maybe my tire blew out, but my tires are all new and were fine. I pulled over to the side and put my emergency break lights on and checked the roof of my car and saw that my sun roof was broken. There is a hole in the middle. \n

The contact owns a 2015 Toyota Rav4. The contact stated that while operating the vehicle, the battery, ABS, and brake warning lights illuminated, and the vehicle stalled on several occasions. The vehicle was jump-started, and the vehicle operated normally. Additionally, the steering wheel became difficult to turn on several occasions. The vehicle was taken to the local Auto Zone which replaced the battery, but the failure persisted. The local dealer was notified of the failures, but no assistance was offered. The cause of the failure was not determined. The manufacturer was not contacted. The failure mileage was 110,000.

See attached document for complaint. text from attached document: To my disappointment, the remedy was not perfo rmed totally. The reason for this was, "improper battery size" . Cont inuing with the message I was texted : "This means we cannot fully complete the recall without replacement of the battery. The recall is to replace hardware that keeps the battery secure due to this happening, this smaller size battery which had been Installed in your car is not properly secured.

Request for Resolution -Peeling Paint on 2025 Toyota RAV 4 I am writing to formally file a complaint regarding a paint peeling issue with my 2025 Toyota RAV 4 and Toyota's refusal to address the defect, despite timely reporting and documentation. The paint on my vehicle began peeling around February 2024 and significantly worsened by January 2025. I promptly filed two complaints with Toyota, and case numbers were opened. Per Toyota's request, I obtained a repair estimate from Toyota of Katy (attached) and submitted it through their system. However, Toyota has since closed both cases without resolving the issue, stating that the paint repair program expired in November 2024. This is particularly troubling because the issue was reported while the paint damage was progressing, I believe this reflects a serious quality defect that affects the appearance, durability, and resale value of the vehicle, and Toyota is failing to take appropriate responsibility. I respectfully request that NHTSA investigate this matter and consider whether similar complaints exist from other Toyota owners experiencing premature paint peeling. Thank you for your attention to this matter

After a battery recall was performed on the vehicle at the dealership, a serious safety issue occurred. A short circuit in the battery cable caused a fire in the engine compartment. Fortunately, I was able to extinguish the fire with an extinguisher before it spread, but it happened very close to the gas line and posed a severe danger. We believe the fire may be related to the recall service. The fire caused visible damage to the battery area, and we have documented it with photos and video. We are very concerned about the safety of this vehicle and potential negligence in the recall repair. We are requesting that NHTSA investigate this matter and take appropriate action.

The battery is off . It does not work. The car does not start. It looks like the battery is not properly installed. I just left my car at the Toyota dealership in June 12 for maintenance services, for brake fluid and flush etc including the replacement of a battery mounting hardware however it does not look right. The car started to go off and today it does not start at all. Please advice Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)