2015 TOYOTA RAV4 Complaints

In July 2026, the rear power liftgate on my Toyota RAV4 suddenly stopped operating properly and would not close. I was unable to push the hatch down normally and then noticed that one of the hinges appeared bent and the liftgate was misaligned. Because I needed to close the vehicle, I tried to lower the hatch very slowly, moving it down only a small amount at a time so I would not put additional pressure on the damaged hinge. While I was doing this, the hatch suddenly sprang back upward and struck me in the shoulder. It took approximately 15 minutes of carefully working with the hatch before I was finally able to get it closed. One hinge was replaced for $400, but after the liftgate was opened only about three times, the hinge became bent again and the hatch was once again visibly misaligned. I have since received an estimate of approximately $3,000 because I was told that multiple components may need to be replaced. At this point I am not opening the liftgate for fear that the broken parts will become worse. The problem has not been successfully repaired and no one has been able to explain why the replacement hinge failed almost immediately. I am concerned that the liftgate may unexpectedly move, fail to close or latch properly, or strike someone while they are attempting to operate it. This appears to be a recurring failure rather than normal wear and tear.

The contact owns a 2015 Toyota Rav4. The contact stated that the radio was inoperable. The contact stated that the gauges failed to properly operate. While driving 65 MPH, the vehicle lost power steering functionality. Additionally, the rearview camera image was reversed before becoming inoperable. The ABS, AWD, and engine warning lights were illuminated. The vehicle was taken to an independent mechanic, and an undisclosed fuse was replaced. The mechanic made the contact aware of NHTSA Campaign Number: 15V144000 (Steering). The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and scheduled an appointment with the dealer for the recall repair of NHTSA Campaign Number: 23V734000 (Electrical System). The failure mileage was approximately 189,000.

Car’s sunroof exploded while driving, was going about 55 on the highway and I heard a loud pop followed by the sound of breaking glass which I found to be my whole sunroof exploding from the inside out. This is dangerous because of the possibility of glass landing on people or in the car leading to potential injury. This issue is apparently one that happens fairly commonly. The component has not been checked yet. There were no warning signs, just a swift explosion and damage.

Purchased less than 2 months ago from Performance Mitsubishi in Delray Beach FL. Lift gate was not opening and closing properly. Yesterday the hinges broke and lift gate won't shut. It appears there is a class action lawsuit for this issue. I am now responsible for fixing this because the dealership won't.

On Friday February 27, 2026 as the vehicle was being driven it caught fire. Fire department and sheriffs office was called to the scene. Vehicle fire was put out but the whole front end burned.

There were two recalls on paint chipping off the body of the car. The last one ended in Nov 2025 I think. BUT...there are many of us who had no idea there was a paint recall, me included. I brought my Rav (great car btw, no issues with how it runs at all) thru a car wash over Thanksgiving, and two softball size paint chips came off, probably due to high pressure water. I then researched the paint and found out that there WAS a recall but I just missed it. This recall needs to be extended needs for I have paint chips missing now all over my car. This is unacceptable from a great car company like Toyota, they need to stand by something so basic as paint quality. The paint color in question is white pearl, code is 070. Thanks for your time here.

The oil filter housing is made of plastic and can crack when removing and installing and if not alert after an oil change, the engine can blow if oil drains out under pressure.

When we bought the SUV, it had a small top battery installed. The battery slid over and caused my alternator to go out completely. I must have caught fire, as there were burnt wires to the alternator. We replaced the alternator, and it was over $295 dollars and then had to get a new battery, and that was over $150 dollars. I installed it myself because I am a mechanic.

The contact owns a 2015 Toyota RAV4. The contact stated that while driving at an undisclosed speed, the vehicle independently accelerated. The contact stated that the failure occurred while the contact was parking the vehicle. The contact's vehicle crashed into a vehicle that was parked beside the contact's vehicle. In addition, the vehicle crashed into the Dollar Tree Store doors. The contact stated that the failure occurred while the brake pedal was depressed and the vehicle was uncontrollable. The contact stated that it was very scary. The Dollar Store door glass was completely shattered. The Dollar Store was closed down as a result of the damage. The vehicle was driven to the contact's residence. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. A Police report was filed. No injuries were sustained. The contact stated that an insurance claim was filed. The contact stated that the failure needed to be investigated by NHTSA. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 70,450. The VIN was unavailable.

November 20,2025 I was driving my 2015 Toyota Rav-4….Turning into my driveway and Suddenly a light on the dashboard came on…An emblem with the Steering ?? Wheel and Exclamation ?? point came on…I was glad that I was at a safe place and called Toyota dealership service department…I was told that it was something to do with the Power Steering Electrical System…That I shouldn’t drive the vehicle but take it to the dealer…I asked if there was a recall and I was told that there wasn’t a recall…I checked several places on Google and it showed several recalls for this particular vehicle and issue…The dealership advised me that there’s no recall for my vehicle…I’m not understanding…I have my Rav-4 that I’m afraid to drive and don’t know what to do at this point…