2008 TOYOTA RAV4 Complaints

REAR U JOINT SEIZED AT 100519 MILES. NOTED VIBRATION AND REAR WHEEL INSTABILITY STARTING APPROX 30 MPH.

VEHICLE DEVELOPED A CLUNK NOISE THAT COULD BE HEARD AND FELT THROUGHOUT THE VEHICLE, ESPECIALLY IN THE STEERING SYSTEM AND ESPECIALLY DURING SLOW SPEED OPERATION. THE PROBLEM BEGAN IN 8/2015 AT ~45,000 MILES. VEHICLE ALSO DEVELOPED A LOOSE FEEL IN THE STEERING AND WOULD PULL TO THE RIGHT UNDER HARD ACCELERATION. BY 1/2016, THE PROBLEM GOT NOTICEABLY WORSE. I THEN TOOK THE VEHICLE TO A LOCAL AUTO REPAIR SHOP FOR DIAGNOSIS/REPAIR. AFTER AN HOUR OR SO OF CHECKING THE ENTIRE SUSPENSION AND STEERING SYSTEM, THE PROBLEM WAS DIAGNOSED AS A BAD "STEERING INTERMEDIATE SHAFT". THE LOCAL SHOP OWNER STATED HE HAD REPLACED SEVERAL OF THESE SAME STEERING SHAFTS ON OTHER RAV4S AROUND THE SAME VINTAGE (2006-2010). I CONTACTED MY LOCAL TOYOTA DEALERSHIP AND THE SERVICE AGENT ALSO STATED THEY HAD "SEVERAL" INCIDENTS WITH THIS VINTAGE OF RAV4S AND STEERING SHAFT PROBLEMS BUT THERE WAS NO RECALL AND SINCE THE VEHICLE WAS OUT OF THE WARRANTY PERIOD, TOYOTA WOULD NOT COVER THE REPAIRS. I THEN LOOKED ONLINE TO SEE IF ANY OTHER OWNERS HAD THE SAME PROBLEM AND WAS SHOCKED TO SEE HOW MANY OTHERS HAVE HAD THE SAME ISSUE WITH RAV4S OF THE SAME VINTAGE AND HAD SIMILAR RESULTS WITH LOCAL TOYOTA DEALERS. I BELIEVE THIS IS A SERIOUS SAFETY CONCERN AS EVENTUALLY THE STEERING SHAFT AND/OR SHAFT U-JOINT KNUCKLES COULD FAIL DUE TO THIS POOR DESIGN AND CAUSE LOSS OF CONTROL (STEERING) OF THE VEHICLE. TOYOTA DOES NOT SEEM TO BE TAKING THIS SERIOUSLY, HOPEFULLY THE NHTSA WILL.

2008 RAV 4 HAS LESS THAN 60K MILES. WAS EXPERIENCING A CLUNKING NOISE WHEN TURNING LEFT OR RIGHT AT LOW SPEEDS. TOOK MY VEHICLE INTO THE DEALERSHIP AND WAS TOLD IT NEEDS A NEW STEERING SHAFT AT A COST TO ME OF $688. UPON RESEARCHING THIS ISSUE I HAVE DISCOVERED THAT IT HAS BEEN AN ISSUE WITH THIS MAKE, YEAR AND MODEL FOR A LONG TIME. WOULD LIKE TO SEE A RECALL GENERATED FOR THIS AS TOYOTA OWNERS SHOULD NOT HAVE TO BEAR THE COST OF FAULTY MANUFACTURING.

THE CAR IS LOOSING ABOUT 1 QUART OF OIL IN 1100 MILES AND IT STARTED ABOUT 100,000 MILES ON THE CAR. APPARENTLY THIS IS A COMMON PROBLEM, BUT THE TOYOTA DEALER CLAIMS THIS IS INDUSTRY STANDARD.

2008 TOYOTA RAV 4. CONSUMER WRITES IN REGARDS TO VEHICLE EXCESSIVE OIL CONSUMPTION PROBLEMS. *SMD THE CONSUMER STATED THE VEHICLE HAS CONSUMER 15 QUARTS OF OIL IN 36,000 MILES. ALSO, THERE WAS A NOISE COMING FROM THE FRONT BRAKE. THE DEALER INFORMED THE CONSUMER, THERE WAS SOME RUST IN THE DRUM AREA THAT PROBABLY CAUSED THE NOISE. *JB

TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT STATED THAT THE WINDSHIELD WIPERS DID NOT WORK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 113,000.

TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED AND REMAINED ON. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V166000 (AIR BAGS). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 28,000.

HAVING JUST EXITED I-95, I WAS TURNING THE STEERING WHEEL TO THE RIGHT TO PULL UP TO THE CURB AT THE PHILADELPHIA AIRPORT TO PICK UP A PASSENGER. UPON DOING SO, THE STEERING COLUMN MADE A LOUD POP OR CLUNK SOUND, AND THE STEERING WHEEL IMMEDIATELY LURCHED APPROXIMATELY 6-8" TO THE LEFT - AND NEARLY OUT OF MY HANDS - ALMOST CAUSING ME TO CRASH INTO THE CROWD AT THE CURB. AFTER THIS SOUND OCCURRED, THE STEERING WHEEL (AS IN A PREVIOUS COMPLAINT IN 2013) WAS STILL OPERATIONAL, HOWEVER WAS ABLE TO MOVE APPROXIMATELY 6 - 9" UP, DOWN, RIGHT, OR LEFT WHILE STILL REMAINING OPERABLE. UPON TAKING THE VEHICLE TO THE TOYOTA DEALERSHIP, I WAS ASKED IF I HAD BEEN IN A FRONT-END COLLISION (ANSWER, "NEVER"), AS A FACTORY WELD HAD FAILED THAT KEEPS THE STEERING COLUMN ATTACHED TO A SAFETY ROD IN THE DASH. REPAIRS ARE EXPECTED TO RUN APPROXIMATELY $3,700. MATTER HAS BEEN SENT TO TOYOTA CORPORATE, HOWEVER NO WORD HAS COME BACK. IT APPEARS AS IF I WILL BE RESPONSIBLE FOR THE FULL REPAIR COST, DESPITE FAILURE IN FACTORY WELD. APPARENTLY NO FAIL-SAFES ARE IN PLACE SHOULD THIS WELD FAIL, SUCH THAT A VERY DANGEROUS SITUATION ARISES, ESPECIALLY IF THIS HAD HAPPENED THREE MINUTES EARLIER WHEN I WAS IN VERY HEAVY INTERSTATE TRAFFIC, INSTEAD OF JUST HAVING EXITED, AND MOVING AT 10 MPH OR LESS.

2008 TOYOTA RAV 4. CONSUMER WRITES IN REGARDS TO REAR SUSPENSION ARM RUST AND FAILURE RECALL. *SMD THE CONSUMER STATED THE DEALER ATTEMPTED TO PERFORM AN ALIGNMENT. HOWEVER, THE MECHANIC WAS UNABLE TO GET THE REAR SUSPENSION IN SPECIFICATION BECAUSE SUSPENSION ARMS WERE BENT. THE CONSUMER RECEIVED TWO SECOND OPINION, AND WAS INFORMED THE ARMS WERE NOT BENT. THE CONSUMER HAD THE ARMS REMOVED AND REPLACED WITH ADJUSTABLE ARMS. *JB

NOTICED WHILE PARKED IN DRIVEWAY, RIGHT FRONT HEADLIGHT APPEARED TO HAVE A BLOWOUT. REPLACED WITH NEW BULB, DID NOT WORK. CHECKED FUSE TO LIGHT, FUSE GOOD. HIGH BEAM DOES WORK, LOW BEAM DOES NOT. CHECKED ONLINE, AND SEE OTHERS HAVE HAD THE SAME PROBLEM.