2008 TOYOTA RAV4 Complaints

THERE IS A RECURRING PROBLEM WITH DRIVER SIDE SUN VISOR WHERE IT DOESN'T STAY WHERE I PUT IT. IT REGULARLY SLIPS DOWN AND AT TIMES BLOCKS MY VIEW OF THE ROAD. THIS IS A KNOWN/RECURRING PROBLEM WITH MANY OTHER OWNERS OF THIS VEHICLE MAKE/MODEL (BASED UPON INTERNET SEARCH OF THIS ISSUE). WHEN THE VISOR IS PLACED OVER THE DRIVER DOOR WINDOW, WHEN I GO AROUND A CORNER (TURN), THE VISOR WILL ROTATE AND HIT ME IN THE HEAD, AGAIN DISTRACTING ME FROM THE ROAD AND FORCING ME TO MAKE REGULAR VISOR ADJUSTMENTS AGAIN AND AGAIN. THE TOYOTA DEALERSHIP IS AWARE OF THIS PROBLEM; A RECALL HAS NOT BEEN ISSUED FOR THIS PROBLEM.

PREMATURE EXHAUST SYSTEM FAILURE BEFORE 80,000 MILES OR 8 YEARS. TRIED TO RESOLVE THIS ISSUE WITH THE DEALER AND TOYOTA CORP (CASE #1508262478 @ 800-331-4331) BUT THEY WILL NOT REPLACE DEFECTIVE PARTS. THE CATALYTIC CONVERTER IS CONNECTED TO AN IN-LINE RESONATOR AND MUFFLER ASSEMBLY. THE MUFFLER SEAM HAS SPLIT. MY CLAIM TO THE DEALER AND TOYOTA CORP IS THE ENTIRE SYSTEM WORKS HAND IN HAND AND THE WAY TOYOTA HAS DESIGNED THE SYSTEM IT CAN NOT BE SEPARATED FROM THE CATALYTIC CONVERTER. THE ENTIRE SYSTEM IS REQUIRED TO REDUCE EMISSIONS AND INCREASE ENGINE PERFORMANCE AND THEREFORE COVERED UNDER THE EMISSION WARRANTY. NOT SURE IF IT IS A DESIGN OR MATERIAL DEFECT BUT SOMETHING COSTING OVER $1,400 TO REPAIR IS MORE THAN A SIMPLE MUFFLER REPLACEMENT THAT SHOULD NOT FAIL AT 52,000 MILES.

TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 13V383000 (SUSPENSION). THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO HAVE ALL FOUR TIRES REPLACED. THE MECHANIC STATED THAT THE REAR TIRES COULD NOT BE ALIGNED DUE TO THE EPOXY FROM THE RECALL REMEDY. AS A RESULT, THE LOWER CONTROL ARMS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 113,000.

MY OIL WARNING LIGHT KEPT COMING ON WHEN I WAS BRAKING. I HAD APPROXIMATELY 2300 MILES SINCE MY LAST OIL CHANGE BUT TOOK THE CAR IN TO GET CHECKED. THE MECHANIC FOUND THERE WAS VIRTUALLY NO OIL LEFT IN THE ENGINE. SINCE THEN I HAVE TO PUT OIL IN MY ENGINE AROUND EVERY 500-700 MILES. MY CAR IS EXPERIENCING EXCESSIVE OIL CONSUMPTION. I JUST TOOK MY CAR INTO MY CLOSEST TOYOTA DEALER AND THEY SAID IN 20 YEARS THEY HAVE NEVER SEEN THIS PROBLEM. I FEEL LIKE THEY ARE LYING TO ME AND JUST WANT THE FAULTY PART FIXED. I DON'T KNOW WHAT MY RIGHTS ARE AND WHAT I CAN DO TO GET HELP. -THANK YOU *TR

THE DRIVER'S SIDE SUN VISOR WILL NOT STAY UP, SO IT NORMALLY STAYS IN A VIEW-OBSTRUCTED POSITION WHEN DRIVING. THIS IS A SERIOUS SAFETY ISSUE AND TOYOTA REFUSES TO BUDGE IN TERMS OF RECALLING THIS ITEM. I BROUGHT THIS TO THE ATTENTION OF TOYOTA A YEAR OR SO AGO AND THEY ASKED ME FOR A QUOTE TO FIX - I SENT THEM A COPY OF THE DEALER PRICE QUOTE (AROUND $150) AND TOYOTA REFUSED TO PAY FOR IT AS A SAFETY ISSUE AND BASICALLY TOLD ME TO GO AWAY. I WOULDN'T NORMALLY COMPLAIN ABOUT SOMETHING LIKE THIS BUT I'VE NOTICED MULTIPLE COMPLAINTS ABOUT THIS SAME ISSUE ON THE INTERNET....AND EVEN FROM THOSE WHO HAD THE VISOR REPLACED UNDER WARRANTY AND IT HAPPENED AGAIN. PLEASE FEEL FREE TO CALL ME AT [XXX] IF YOU'D LIKE ANY ADDITIONAL INFORMATION. PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*CC

THE RAV4 HAS EXHIBITED SUDDEN UNINTENDED ACCELERATION THREE TIMES: LATEST OCCURRED ON 7/17/2015 AT 7:30 PM WHILE STOPPED AT AN INTERSECTION; THE 2ND ON 7/06/15 WHILE IN PARK IN MY DRIVEWAY JUST AFTER STATING THE CAR; THE 1ST ON ABOUT 6/30/15 AROUND NOON WHILE STOPPED AT A TRAFFIC LIGHT. FORTUNATELY, I HAD MY FOOT ON THE BREAK OR WAS IN PARK SO THAT THE CAR DID NOT MOVE. AFTER TURNING THE CAR OFF AND RESTARTING THE PROBLEM WENT AWAY. THE VEHICLE WAS TESTED AT LOCAL DEALER ON 7/20 WITH DIAGNOSTIC DATA SENT TO TOYOTA CENTRAL, BUT THEY COULD FIND NO PROBLEM IN THE DATA - NO ERROR CODES. THE TECHNICAL CASE NUMBER IS [XXX]. AFTER CONTACTING TOYOTA CUSTOMER SERVICE (CASE # [XXX]) I WAS TOLD THEY COULD DO NOTHING FURTHER THAT THE CAR "PERFORMED AS DESIGNED" PER SABINA CHARFAUROS, CASE MANAGER, 188-331-4331 EXT. 73846 UPDATED 9/28/15 *LN UPDATED 3/23/2016*JS

I'VE HAD MY 08 TOYOTA RAV4 FOR OVER 4 YEARS NOW. I GET THE OIL CHANGED ON IT EVERY 5,000 MILES REGULARLY. I GOT IT WITH ABOUT 25,000 MILES ON IT AND RIGHT AROUND 70,000 MILES I NOTICED THAT THE OIL LIGHT WOULD COME ON BEFORE I REACHED MY NEXT OIL CHANGE. IT HOLDS ABOUT 5 QUARTS AND WITH BEING CHANGED EVERY 5,000 MILES THAT MEANS IT IS BURNING MORE THEN 1 QUART EVERY 1,000 MILES! MY BROTHER-IN-LAW DID SOME RESEARCH AND FOUND OUT THAT THIS IS BECOMING A PROBLEM WITH MANY RAV4'S WITH THE PISTONS IN THE 2AZ FE MOTOR. I LOVE THIS CAR SO MUCH AND IT BREAKS MY HEART TO KNOW THAT THERE IS SOMETHING WRONG THAT I CAN'T FIX. I DON'T WANT TO GET A DIFFERENT CAR BUT NOW I HAVE TO!

TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. WHILE THE VEHICLE WAS BEING SERVICED, IT WAS DISCOVERED THAT THE VEHICLE HAD A FRACTURED STEERING ROD. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 89,901.

TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT STATED THAT THE SOFTWARE WAS UPDATED IN THE VEHICLE DUE TO A MANUFACTURER'S RECALL. WHILE TRAVELING AT ANY RATE OF SPEED, THE CONTACT'S ANKLE WAS IMPACTED BY THE ACCELERATOR PEDAL AND THE BRAKE PEDAL, WHICH GENERATED AN UNSAFE CONDITION AND A SUDDEN LOSS OF POWER. THE CONTACT EXPERIENCED THE FAILURE MORE THAN ONCE AND HAD TO MOVE OVER TO THE RIGHT LANE TO GET THE VEHICLE TO PICK UP SPEED EACH TIME THE FAILURE RECURRED WHILE IN DRIVE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V113000 (VEHICLE SPEED CONTROL). THE DEALER'S TECHNICIAN CAME TO THE CONTACT'S RESIDENCE FOR A TEST DRIVE AND THE TECHNICIAN INDICATED THAT THE POWER LOSS WAS DUE TO THE PLACEMENT OF THE CONTACT'S FOOT ASSOCIATED WITH THE SPACING NEAR THE ANKLE BY THE BRAKE PEDAL AND THE ACCELERATOR PEDAL. THE VEHICLE WAS NOT REPAIRED FROM THE RECALL REMEDY OF THE SOFTWARE UPDATE AND THE CONTACT INDICATED THAT THE FAILURE MAY RECUR WITHOUT WARNING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS 57,315. UPDATED 09/10/15*LJ UPDATED 12/06/2017*CN

THE HOSE CONNECTING THE CANISTER FILTER TO THE CANISTER BROKE OFF DRIVING IN THE RAIN AND I DIDN'T SEE UNTIL NEXT DAY WHILE 8 HRS AWAY FROM HOME. CALLED THE LOCAL DEALER THEY DIDN'T HAVE THE PART. NO CHECK ENGINE LIGHT SHOWN.I GOT HOME AND HAVE THE CANISTER FILTER REPLACED WITH THE DEALER AND NEXT DAY CHECK ENGINE, VSC AND 4WD LIGHT CAME ON, DEALER SAYS IT COST $1800 TO FIX IT. I RESEARCHED ONLINE AND LOT OF 2006 AND UP RAV 4 OWNER HAVE SAME ISSUE. CANNISTER HOSE BROKEN OR FILTER DROPPED AND WATER GETTING INTO THE SYSTEM. I GOT TOYOTA SERVICE BULLETIN T-SB-0098-09 WHICH WAS UPDATED TO T-SB0161-11 ON OCTOBER 20,2011 FOR THIS ISSUE. TOYOTA HAD COVERED WARRANTY FOR 2GR-FE ENGINE FROM 2006-2011 SOLD ON CA, CT, ME, MD, MA, NJ, NM,VT,WA, RI UNDER CALIFORNIA LONG TERM EMISSION WARRANTY OF 64 MONTHS OR 70,000 MILES WHICH EVER OCCURS FIRST. TOYOTA KNEW THE ISSUE AND EVEN ADDED A NEW COVER (PART NO 77641-0R020) THE PROTECT THE CANISTER FILTER AND THE HOSES BUT THEY DIDN'T ISSUE THE RECALL. A LOT OF PEOPLE HAVE SAME ISSUE. THE FILTER AND HOSE ARE UNPROTECTED UNDERNEATH THE CHASSIS AND IT CAN BREAK OR FALL DRIVING UNDER NORMAL DRIVING IN A RAIN OR SNOW. I CALLED TOYOTA AND THEY REVIEW MY CASE AND GAVE ME CASE # BUT THEY WON'T FIX IT BECAUSE MY VEHICLE WAS NOT DRIVEN AND SOLD ON THE AFOREMENTIONED STATES. TOYOTA HAS COVERED THE WARRANTY ON THE STATES WITH HEAVY SNOW AND RAIN ONLY. BUT THESE THINGS ARE TRUE FOR THE STATE I AM IN TOO. REMAINING STATE STANDARD 36 MONTHS 36,000 WARRANTY. BUT THIS THING CAN HAPPEN TO ANYONE AT ANY MILEAGE. TOYOTA KNEW IT AND HAD A FIX BY PUTTING THE NEW COVER BUT DIDN'T ISSUE A RECALL . THE SERVICE BULLETIN EVEN STATES THE VEHICLES MANUFACTURED BEFORE CERTAIN VIN NUMBER AND MINE DOES FALL UNDER IT. I PAID $220 TO REPLACE FILTER AND $62.5 TO DIAGNOSE. NOW THEY WANT ANOTHER $1800 TO FIX IT. I WISH I COULD ATTACHED THE SERVICE BULLETIN. UPDATED 09/15/15*LJ UPDATED 11/08/2017*CN