2008 TOYOTA RAV4 Complaints

STEERING INTERMEDIATE SHAFT WORN OUT : MAKING CLUNKING NOISE WHEN TURNING EITHER WAY ALSO WHEN REVERSING CAR TOYOTA TECHNICIAN FOUND THIS DEFECT/ISSUE

TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. THE CONTACT HEARD A REALLY LOUD GRINDING NOISE EMERGING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO DOWNEAST TOYOTA IN BREWER, MAINE FOR DIAGNOSTIC TESTING ON JULY 6, 2017, BUT THE FAILURE COULD NOT BE DUPLICATED. THE CONTACT WAS ADVISED TO BRING THE VEHICLE BACK WHEN THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DETERMINED THAT THE REAR DIFFERENTIAL COUPLER FAILED AND NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS OUTSIDE THE NINE YEAR EXTENDED WARRANTY. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

2008 TOYOTA RAV4 EXCESSIVE OIL CONSUMPTION. AFTER REACHING 100,000 MILE ON MY VEHICLE, IT BEGAN TO USE 1 QUART OF OIL EVERY 1,200-1,500 MILES. TOYOTA KNEW OF THIS PROBLEM (TSB TO DEALERS) BUT REFUSE TO OFFER ANY RESTITUTION TO CUSTOMERS IF THE VEHICLE HAS PASSED THE 60,000 MILE POWER TRAIN WARRANTY. THIS IS A MANUFACTURE PROBLEM AND TOYOTA SHOULD HAVE TO MAKE THESE REPAIRS FREE OF ANY CHARGE TO THE CUSTOMER.

VERY BAD CLUNKING / POPPING SOUND WHEN I BACK UP AND TURN MY WHEELS. SEEMS TO HAPPEN MOSTLY WHEN I FIRST DRIVE THE SUV IN THE MORNING. ONLY HAS 96,000 MILES ON IT.

IT HAS EXCESSIVE OIL CONSUMPTION AND HAS FOR AT LEAST A YEAR THAT I HAVE BEEN AWARE OF. I HAVE TO ADD AT LEAST A QUART OF OIL EVERY 1000 MILES OR LESS. I FEEL I HAVE TO CARRY OIL EVERYWHERE AND THAT I NEED TO CHECK THE DIP STICK FREQUENTLY. THE DEALER HAS CHARGED A FAIR AMOUNT OF MONEY FOR THINGS THAT HAVE NOT FIXED IT YET AND NOW IS QUOTING ME $3800.00 FOR ENGINE DIAGNOSTIC/REPAIR. THEY NEVER ONCE MENTIONED TO ME THAT THERE IS A KNOWN CONSUMPTION PROBLEM WITH THIS ENGINE TYPE ON ANY OF MY OTHER EXPENSIVE VISITS TO THEM BACK WHEN MY MILEAGE WAS UNER 150,000 MILES. IT'S KNOW OVER 167,000 MILES AND SO IS NOT COVERED BY THEIR SO CALLED WARRANTY ENHANCEMENT PROGRAM.

TOYOTA RAV4 2008 LIMITED SUNROOF EXPLODED GOING 70 MPH ON INTERSTATE (NO OTHER FACTORS, SUCH AS WE WERE NOT UNDER/HAD NOT JUST GONE UNDER AN INTERSTATE OVERPASS). I WAS DRIVING - SOUNDED LIKE A GUNSHOT. HUSBAND IN PASSENGER SEAT AND SOUNDED LIKE A LOUD POP. GLASS SHATTERED ALL OVER US. WE PULLED OVER, PATCHED IT THE BEST THAT WE COULD AND TOOK STATE ROADS HOME (3 HR INTERSTATE DRIVE VS 5 1/2 HOUR, 55 MPH BARELY DRIVE HOME. TOOK TWO REPLACEMENT SUNROOF KITS TO GET IT RIGHT. INSURANCE PAID IN FULL UNDER GLASS POLICY.

ECSESSIVE OIL CONSUMPTION OVER LAST YEAR INCREASING OVER TIME NOW USING 5-6 QUARTS BETWEEN OIL CHANGE... TOYOTA ACKNOWLEDGES OIL CONSUMPTION PROBLEM BUT WILL NOT REPAIR'

I FOUND OUT TOO LATE ABOUT THE DEFECTIVE PARTS IN THE 2AZ-FE ENGINE. MY PROBLEM STARTED AFTER THE WARRANTY AND THEY WILL NOT REPAIR IT. MY CAR BURNS A LOT OF OIL AND I HAVE TO HAVE AN OIL CHANGE OR ADD OIL FREQUENTLY (EVERY FEW WEEKS OF ADDING OIL). I NEVER RECEIVED NOTIFICATION OF THIS PROBLEM AND DIDN'T FIND OUT THAT THEY WERE FIXING THIS UNTIL I STARTED LOOKING ONLINE TO FIND OUT IF ANYONE ELSE HAS THE PROBLEM. I SEE CLASS ACTION SUITS AND OTHERS THAT WERE NEVER NOTIFIED. I EVEN HAVE HAD MY CAR INTO TOYOTA FOR REPAIRS AND WAS NEVER TOLD ABOUT THIS PROBLEM. SO NOW I HAVE A CAR WITH ONLY 147,000 MILES THAT NEEDS FREQUENT OIL THAT TOYOTA WON'T STAND BEHIND. IF IT WAS JUST MY CAR I MIGHT NOT BOTHER REPORTING IT, BUT ITS NOT

TL* THE CONTACT OWNS A 2008 TOYOTA RAV4. WHILE DRIVING 45 MPH, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT COULD NOT PULL THE VEHICLE OVER TO THE SIDE OF THE ROAD. THE CONTACT TURNED OFF AND RESTARTED THE VEHICLE, AND IT RETURNED TO NORMAL. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ALTERNATOR, BATTERY, AND IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT ALSO STATED THAT THE FAILURE RECURRED SEVERAL OTHER TIMES AFTER THE REPAIR. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AT 800-331-4331 AND ASKED THE CONTACT TO TAKE THE VEHICLE TO THE DEALER. A CASE NUMBER WAS NOT PROVIDED. THE APPROXIMATE FAILURE MILEAGE WAS 213,000. THE VIN WAS NOT AVAILABLE.

I WAS DRIVING MY 2008 RAV 4 AND I MADE A TURN & ALL OF A SUDDEN MY STEERING WHEEL LITERALLY BECAME FREE FLOATING. I CAN MOVE THE STEERING WHEEL 8 TO 12 INCHES UP AND DOWN WITH NO RESISTANCE. I CAN ALSO MOVE IT 6 TO 8 INCHES LEFT TO RIGHT WITH NO RESISTANCE. IT'S NOT GUIDED IN ANY WAY, YOU CAN MOVE IT AROUND IN A LARGE CIRCULAR MOTION. I WAS ABLE TO STILL STEER SOMEWHAT. THE COLUMN STILL SEEMS TO BE ATTACHED TO SOMETHING. WHEN YOU DO STEER, IT MAKES A HORRIBLE POPPING SOUND. THE DEALERSHIP SAID: A FRAME WELD DID GIVE OUT FOR THE STEERING COLUMN ASSEMBLY. THE STEERING COLUMN ASSEMBLY IS EVERYTHING BETWEEN THE WHEEL AND THE INTERMEDIATE SHAFT. THE STEERING ASSEMBLY IS MOUNTED TO THE INSTRUMENT PANEL REINFORCEMENT BAR. THIS IS A LARGE BAR THAT RUNS THE LENGTH OF YOUR DASHBOARD. THIS BAR HAS A FEW WELDED MOUNTS ON IT THAT ALLOW YOU TO BOLT THE STEERING COLUMN ASSEMBLY INTO, IT IS THESE WELDS WHICH FAILED. THE AIR DUCT ON THE DRIVERS SIDE FELL ONTO MY FEET/PEDALS WHILE I WAS DRIVING. LUCKILY IT DIDNT GET CAUGHT BEHIND MY PEDALS. I SOFT DRIVE APPROX 8000-9000 MILES A YEAR. I'VE HAD NO ACCIDENTS. TOYOTA IS CHARGING ME $2200 TO REPLACE THIS & WILL NOT COER THE COSTS. THIS IS A MAJOR SAFETY ISSUE & I DID RESERCH & THIS HAS HAPPENED NUMEROUS TIMES! CHECK IT OUT HERE: HTTP://WWW.RAV4WORLD.COM/FORUMS/99-4-3-MECHANICAL/115306-STEERING-ASSEMBLY-FRAME-WELD-BROKE.HTML