2012 TOYOTA RAV4 Complaints

My 2012 Toyota RAV4 (Super White / Blizzard Pearl paint) is experiencing severe and recurring paint peeling caused by a known manufacturing defect in which the factory paint primer failed to properly adhere to the base metal layer. The peeling first began in 2023 following freezing weather in Austin, TX. It occurred again in 2024 after another freeze event, and then once more in 2025, at which point a large section of roof paint peeled off completely, exposing bare metal. I attempted to repair the damage with spray paint but the new paint continues to peel off as well, because the underlying adhesion defect was never corrected. This confirms the failure is rooted in the original factory primer, not in external damage or neglect. This poses a direct safety hazard to other drivers and pedestrians when paint debris becomes airborne at highway speeds, and the exposed bare metal is now vulnerable to rust and further structural deterioration. Toyota formally acknowledged this defect and created Customer Support Program ZKG to address it across nearly 1.74 million vehicles, including the RAV4. In July 2022, Toyota confirmed in writing that 'sunlight/ultraviolet exposure over time degrades the adhesion between the factory-applied paint primer coat layer and the base metal electrodeposition layer, causing paint to peel from the metal body panel.' Freeze-thaw cycles accelerate this exact failure mode by forcing moisture under already-weakened paint edges, causing rapid and widespread delamination — consistent with what I experienced after the 2023, 2024, and 2025 Austin winter weather events. I was not properly notified about Program ZKG and missed the coverage window as a result. Toyota has declined to provide goodwill assistance. Given that Toyota knowingly sold vehicles with a defective paint system, failed to adequately notify all affected owners, and that the ongoing peeling creates an active road safety hazard with bare metal now exposed on the roof, please investigate.

My vehicle is a 2012 rav 4 sport, color Barcelona Red. Said color and model has been know to have clear coat and paint issues. My vehicles clear coat and paint in the top has been peeling at an alarming rate, a year or so ago it started, but the last 6 months have been excrutiating. This problem poses a risk to me as if the issue continues on, oxidation might occur and possibly lead to holes in the surface. To other paint flying off from the vehicle might distract them in the porcess of driving and the glare produces by it might impact others vision. Other areas that have been affected include, hood and side mirrors.

The contact owns a 2012 Toyota Rav4. The contact stated that while driving at various speeds, the vehicle shuddered abnormally. The contact stated that the vehicle was consuming an excessive amount of engine oil. Several unknown warning lights were illuminated. The vehicle was taken to a local Auto Zone, where it was scanned with an OBD2 scanner and DTC: P0607, P1603, and P1604 were retrieved. The vehicle was taken to another local independent mechanic, where it was diagnosed with an unknown electrical failure. The vehicle was not repaired due to the cost. The local dealer was not contacted. The vehicle was not repaired. In addition, the contact related the failure to an unknown recall; however, the VIN was not under recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 138,000

The small pipe that's part of the Upper Radiator Coolant Hose Connector Adapter broke off and drained coolant from the vehicle. This small pipe had deteriorated and become brittle leading to the failure.

The windshield pump is not working front and back The wipers turn but no liquid comes out though the tank is full It does not make the sound it normally does when it pumps the windshield liquid Dealer wants almost $200 just to look at it and verify the problem

I have a 2012 Toyota Rav-4 Limited . I have had the vehicle since 2020. Ever since I bought the vehicle it fogs up. All the windows fog up and it does not matter what setting I have it on, de-foggers, fan, fresh air, AC, etc. nothing resolves the problem.It is very dangerous as I cannot see where I am going. I cannot use the front de-foggers in bad weather because it makes the afore mentioned problem worse.I have to put the windows down to see and this remedy is not feasible. I have researched and a lot of other people are experiencing this same safety issue in this model vehicle. I love the vehicle but dread bad weather as it is a struggle to see . Please help.

While at the end of a car wash with the car in neutral, the car accelerated by itself. It reached 60 mph for over a half mile, and was unresponsive to steering and brakes. The left front wheel was severely damaged. Fortunately, there were no accidents.

Over the last several years, I have experienced a minimum of four, possibly one or two more, incidents of this vehicle accelerating at a high rate while I have had my foot on the brake. In all of these cases, I was braking to come to a stop - braking quickly and hard in a couple cases. While braking and slowing, my engine revved/accelerated at a very high rate. In all of these incidents, I changed gears to neutral, and the acceleration stopped. These incidents were random and very far apart from one another in terms of time. In all cases, my foot was firmly (and only) on the brake pedal, and my floor mat was in the proper position and secure. There was nothing in contact with the acceleration pedal. On Monday, March 10, 2025, I got into my car in our garage to go to work. The car started normally. When I put my car into reverse, the engine started revving/accelerating at a very high rate and it was lurching, like it was trying to move. Luckily, my foot was firmly on the brake, and the brake held. I quickly put the car back into park, and the engine began revving/accelerating at an even higher rate. I then turned the car off. Again, I checked my floor mat, and it was in place and secured, my foot was only on the brake pedal, and there was nothing touching the acceleration pedal. This was a frightening experience, and at that point I decided that I would never drive this car again. If I did not have my brake firmly engaged, my car would have shot out of my garage when I put it in reverse. Upon researching the problem, my husband and I read about the unintended acceleration that many people have experienced with Toyotas, causing numerous deaths and injuries, and about the class action law suit with Toyota. Although the investigation seemed to chalk the incidents up to "user error" - foot being on the wrong pedal, floor mats affecting the acceleration pedal, etc. - I know with 100% confidence that none of these were the case. I will be notifying Toyota, as well.

Constant brake issues Sun visors won't stay in place (breaks) Massive oil consumption (not leaking) Oil on dipstick appears black & burnt quickly after adding or replacing oil

No accident but dealer mechanic says I need a new transmission as torque converter is the problem. . Car has 107500 miles and has had routine maintenance. I have since learned that there were dealer service bulletins on this issue and some owners got repairs. My vehicle, a 2012 RAV4, was not included in the bulletin. I read many situations like mine on the RAV4world website and other social media. Toyota needs to be held accountable for the thousands in repair costs owners are experiencing for a design flaw. The safety issue is the transmission could fail prematurely.