2009 TOYOTA TACOMA Complaints

AIR BAG LIGHT ON, TOYOTA FOUND DTC S B1785 OCCUPANT CLASSIFICATION SENSOR FRONT LEFT COLLISION DETECTION, B1650 OCCUPANT SYSTEM MALFUNCTION, ZERO POINT CALIBRATION AND SENSITIVITY CHECK DONE BUT TOYOTA HAWAII SAYS WE NEED TO REPLACE FRONT RIGHT SEAT SENSOR MAT ASSY. IS THAT A SAFETY ISSUE AND IS THIS A MANUFACTURE DEFECT? TOOK TO TOYOTA 3 TIMES NOW FOR THE SAME ISSUE OF THE AIR BAG LIGHT COMING ON. PLEASE ADVISE, THANK YOU! BOTH LENS BULBS MELT INNER SIDE OF PLASTIC PARTS ON THE HEADLIGHTS. PLEASE ADVISE IF THIS IS ALSO A RECALL/DEFECT. *TR

8/4/14 THE LEFT REAR SPRING BROKE SEVERING THE BRAKE LINE, LEAVING HER WITH NO ABILITY TO STOP THE TRUCK. 7/12/13 THE RIGHT REAR SPRING WAS FOUND TO BE BROKEN. BOTH THE TOYOTA DEALER AND THE SHOP THAT FIXED THE SPRINGS TOLD ME THAT THIS WAS VERY COMMON IN THESE TRUCKS. HAD MY DAUGHTER LOST HER BRAKES TEN MINUTES EARLIER, SHE WOULD HAVE BEEN ON THE INTERSTATE AND THE RESULTS COULD HAVE BEEN TRAGIC.. UPDATED 08-20-14 *BF. UPDATED 08/27/2014 *JS

A BROKEN LEAF SPRING CUT MY BRAKE LINE AND MY BRAKES STOPPED WORKING WITH MY 8 YEAR OLD CHILD IN THE TRUCK. I HAD ALREADY REPLACED A LEAF SPRING ON THE OTHER SIDE. THIS COULD HAVE CAUSED A VERY SERIOUS ACCIDENT, LUCKILY THE BRAKES STILL HAD SOME FLUID IN THEM WHEN I REALIZED THERE WAS AN ISSUE. THE TRUCK HAD TO BE TOWED TO THE DEALERSHIP FOR REPAIR. *TR

THE DTRL AMBER BULB HAS MELTED BOTH LENS DUE TO EXCESSIVE HEAT FROM BULB.THE LEFT/RIGHT LENS ARE CRACKED AND FALLING APART. *TR

THE BULB TO THE DAYLIGHT RUNNING LIGHTS MELTED THE LENS IN FRONT OF IT AND BROKE IT IN TWO PIECES. THIS IS FOR BOTH LIGHTS. THIS BULB IS TOO CLOSE TO THE LENS, PROBABLY A DEFECT IN ENGINEERING OR DESIGN. THESE LIGHTS ARE CONSTANTLY ON AND THERE IS NO WAY TO TURN THEM OFF. I'M AFRAID SOMETHING WILL CATCH ON FIRE. I CALLED TOYOTA DEALERSHIP AND WAS TOLD THEY COULDN'T FIX IT BECAUSE I DIDN'T HAVE EXTENDED WARRANTY. I CALLED CORPORATE OFFICES AND WAS TOLD I WOULD HAVE TO GET VEHICLE DIAGNOSED AT COST OF $150 BEFORE THEY CONSIDERED TAKING ANY ACTION. AND IF IT WAS DETERMINED THAT IT WAS A MANUFACTURING DEFECT THAN I WOULD HAVE TO PAY HALF OF THE COST OF THE NEW HEADLIGHTS, WHICH WOULD BE AROUND $300, PLUS THE $150 FOR THE DIAGNOSTIC TEST. TOLD THEM OTHERS HAVE HAD THIS EXACT SAME PROBLEM, TO NO AVAIL. THIS IS NOT FAIR AS IT'S OBVIOUS THIS IS DEFECTIVE EQUIPMENT/DESIGN. THANK YOU. *TR

TL* THE CONTACT OWNS A 2009 TOYOTA TACOMA. THE CONTACT STATED THAT THE PASSENGER'S SIDE HEADLIGHT HOUSING MELTED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO CONFIRMED THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 25,000 AND THE CURRENT MILEAGE WAS 80,000. THE VIN WAS NOT AVAILABLE.

DAY TIME RUNNING LIGHTS OVERHEATING AND MELTING THE PLASTIC INSIDE HEADLIGHT WHICH LOOKS LIKE IT IS BURNT AND BLACK CAUSING HEADLIGHT TO CRACK AND DAMAGE TO THE BULBS. I HAVE REPLACED DRIVER SIDE NOW AND PASSENGER SIDE HAS STARTED TO MELT. *JS

TODAY, 04/12/14, AT AROUND 11:55 A.M., I HAD MY FOURTH EXPERIENCE OF UNINTENDED ACCELERATION IN MY 2009 TOYOTA TACOMA. THE FIRST TWO INCIDENTS I HAD NOT REPORTED. THE THIRD INCIDENT I DID REPORT TO TOYOTA, THEY EXAMINED MY TRUCK AND FOUND NOTHING THEY THOUGHT WOULD CAUSE THE ACCELERATION. TODAY, I WAS APPROACHING A BUSY INTERSECTION DURING A STREET FESTIVAL IN THE DOWNTOWN SECTION OF MY HOME TOWN. MY TRUCK DID NOT STOP WHEN I PRESSED THE BRAKE, BUT THE ENGINE REVVED AND THE TIRES SQUEALED TWICE AS I TRIED UNSUCCESSFULLY TO STOP THE VEHICLE. IT CARRIED ME THROUGH THE INTERSECTION - IF IT HAD BEEN OCCUPIED, I DON'T KNOW IF I WOULD HAVE BEEN ABLE TO STEER AWAY FROM PEDESTRIANS, AS THE STREET WAS NARROW AND IT ALL HAPPENED VERY FAST. AS SOON AS I HAD CONTROL OF THE TRUCK, I PULLED OVER TO CHECK THE RUG. THE RUG WAS HOOKED INTO ITS HOLE, A GOOD 3 INCHES FROM THE ACCELERATOR, AND COULD NOT BE MOVED BY HAND. I AM NOW AFRAID TO DRIVE MY TRUCK, AND AM GRATEFUL TO GOD THAT NO ONE WAS HURT OR KILLED. I HAD A PASSENGER WITH ME WHO WITNESSED THIS. *TR UPDATED 09/29/2014 *JS

FRONT TURN SIGNAL LIGHTS BURNING AND MELTING LENS. INSPECTION OF PLASTIC BULB SOCKET SHOWS SIGNS OF HEAT DAMAGE AND POTENTIAL FIRE HAZARD. *JS

AT 59,500 MILES THE LEFT FRONT WHEEL BEARING STARTED MAKING A LOT OF NOISE AND VIBRATION AND NOTICEABLY ALTERED THE STEERING. THE WHEEL BEARING WAS REPLACED UNDER WARRANTY. NOW AT 90,000 MILES THE BEARING IS FAULTY AGAIN AND TOYOTA REFUSES TO FIX IT AGAIN. I TOOK IT TO MY MECHANIC WHO TOLD ME THAT HE SEES A LOT OF FAILED WHEEL BEARINGS ON THE TACOMAS. A FAILED BEARING CAN RESULT IN THE WHEEL LOCKING UP OR FALLING OFF AT HIGHWAY SPEEDS. *TR