2023 TOYOTA TUNDRA Complaints

The engine seized up with 25,000 miles on it, on May 25th, 2025. I was not listed as under the engine recall, so they did a "Short Block" rebuild under warranty. I feel like this is insufficient and my vehicle should be under the recall for an entire new engine. My safety was put at risk because the vehicle shut down out of nowhere on a busy highway with narrow shoulders. I had to wait on the side of the road until a tow truck could get to me. Dealer confirmed it was seized up and ordered the short block replacement. No warning at all before the engine seized up.

The contact owns a 2023 Toyota Tundra. The contact received notification of NHTSA Campaign Number: 23V566000 (Fuel System, Gasoline) and 25V322000 (Exterior Lighting); however, the parts to do the recall repairs were not yet available. The contact stated that the vehicle was taken to the dealer for the recall repair and the vehicle was inspected. The contact was informed that the parts needed to be ordered, and the parts were ordered. The dealer contacted the contact, and the contact was informed that the parts were available. The contact scheduled an appointment for the recall repair however, when the vehicle was taken to the dealer, the contact was informed that the parts were sold. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The vehicle inconsistently delays when accelerating from a stopped position. This is more frequently noticed shortly after starting the vehicle. This was first noticed around 10K miles, and my vehicle is currently at 25,235 miles. This has happened approximately 4-5 times. While at a stop sign, judging traffic to enter into the intersection I have pushed the gas with no response for 2-3 seconds then a sudden burst of power. Having worked as a state LEO/Trooper for over 25 years I find this very concerning. Any delay in acceleration for power could result in a collision.

Engine is misfiring, truck vibrates when breaking when accelerating the engine cuts out dealership confirmed at service on 2/4/2025 that sensor needs to be replaced, need breaks, four tire rotation No No

While on vacation, approximately 400 miles from home, the engine dash light came on. The truck seem to be running fine but I did notice a different smell coming from the exhaust. I was able to return home and took it to the dealership as soon as possible. The dealership, Stephen Wade Toyota, contacted me and said that my driver side Cadillac converter had gone bad. They had no explanation of why it went out, but I would need a new one at $2,143.15. I asked if the Cadillac converter was covered under any type of warranty and the dealership informed me that in Utah it expired at 35,000 miles. Truck has 66,000 miles and regular maintenance has been performed on the vehicle. It seems extremely premature that a 2 year old vehicle with 65,000 miles would be experiencing a Cadillac converter failure.

Vehicle & Warranty Details Model: 2023 Toyota Tundra VIN: [XXX] Mileage at Failure: 34,658 miles Warranty Coverage: Factory bumper-to-bumper (3 years / 36,000 miles) — active Powertrain warranty (5 years / 60,000 miles) — active Toyota Platinum extended warranty (7 years / 100,000 miles) — active Maintenance: Oil changes every 5,000 miles (better than Toyota’s 10,000-mile recommendation) Symptoms & Failure Description Engine suddenly shut off while driving at about 50 mph with my [XXX] and [XXX] in the truck, Restarted once, then shut off again shortly after Engine now barely cranks and will not start Check engine light came on during initial failure No visible oil leak present Strong burning smell, similar to burning brakes or friction Prior to failure, noticeable hesitation on cold starts that cleared after a short time Toyota has diagnosed this issue as an Engine seizure and are NOT honoring the remedy included in the rod bearing/oil starvation failures in 2022–2023 Tundra's with the 3.5L twin-turbo V6 (engine code V35A-FTS) Symptoms consistent with Toyota Recall 24V381, although this VIN is not yet listed on the recall Typical failure includes: internal machining debris causing oil flow restriction, bearing damage, and eventual engine seizure without external oil leaks or loud noises INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2023 Toyota Tundra. The contact stated while driving approximately 65 MPH, the vehicle lost motive power. The message “Engine Power Reduced – Pull Over Immediately” was displayed. The contact was able to pull over to the side of the road. The contact stated that while attempting to restart the vehicle, there was smoke coming out of the passenger's side of the hood. The vehicle was towed to the dealer, where it was diagnosed that the engine had failed and needed to be rebuilt. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 28,361.

The contact owns a 2023 Toyota Tundra. The contact stated while attempting to reverse, there was an abnormally loud sound coming the brakes. The dealer was contacted. The contact stated that the failure occurred on several occasions. The vehicle was taken to the dealer where it was diagnosed and determined that the brakes needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case. The contact was referred by the manufacturer to the NHTSA Hotline to report the failure. The approximate failure mileage was 25,600.

P265/60/R20. All wheels are worn severely on outer wheels. One wheel is so severely worn on outer edge it’s into the secondary rubber and I was told it wasn’t safe to drive… Dealership said that it wasn’t safe to drive long distances that it could blow apart… as of know no one had admitted fault and they expect me to cover costs. Truck is 2023 with 19,500 miles on it. Pictures show the worst tire but all of the tires are wearing the same with the outer edge worn severely.

The contact owns a 2023 Toyota Tundra. The contact stated while driving 65 MPH, the vehicle stalled. The contact stated that the message “Engine Failure – Pull Over” was displayed after the failure. The contact pulled over to the side of the road; however, the vehicle failed to restart. The vehicle was towed to the dealer, where it was diagnosed and determined that the engine was blown. The dealer determined that the short block needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 42,000.