2007 TOYOTA TUNDRA Complaints

Subject: Dealer Warranty Enhancement Program ZH7 Certain 2007 – 2008 Model Year Tundra Extension of Warranty Coverage for Frame Corrosion - Ended on 1/21/2019 (attached). Details: See Attached Pictures - Frame has rusted out with considerable "perforation" 10mm or larger. The condition clearly started many years ago. The vehicle was rust protected at an independent non-dealer shop. No known frame issues were witnessed prior to the 2019 deadline. Vehicle was not taken to the Toyota Dealer based on aftermarket rust protection application and no witnessed issues. The enhancement was not stated as a mandatory recall (which it should have been). The vehicle has 80k and has been lightly used in Virginia (cold climate state). The entire structural integrity of the truck is put at risk with this condition. An independent shop investigated the condition and provided the pictures. Repairs are underway but Toyota America should be responsible for extending this enhancement to a mandatory recall of all impacted vehicles. This is clearly a public safety hazard, breakdown in quality and totally unacceptable.

The frame of the vehicle has a recall on it because of excessive rusting. The previous owner had not gotten the recall fixed. The rusted frame causes issues with steering, maintenance, and general control and safety of the vehicle. Toyota dealerships claim this recall has expired. A rusted frame violated NY State inspection. Since this indefinitely violates the NHTSA guidelines and regulations, how can it expire? Toyota refuses to fix the recall on the frame due to “expiration” and would rather endanger roadways see as many of these vehicles still are driven on public roadways and come with a hefty cost due to the expiration. Many vehicles like this with under 100k miles have the same critical issue, leaving Americas at a loss. This recall should not “expire”

What component or system failed or malfunctioned, and is it available for inspection upon request? Gas tank cover plate is rusting out causing the tank to almost fall out. How was your safety or the safety of others put at risk? My safety and others safety was put at risk as if the tank were to fall out, it could catch the vehicle on fire. Also as the plate rusts even more day by day, the heat from the exhaust and other parts that heat up it can damage the gas tank and once again is a fire hazard. Has the problem been reproduced or confirmed by a dealer or independent service center? No, there are no open recalls from what I can’t tell by the vin but same year has same problems and are under recall. Not sure why this one isn’t under recall. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, there would be no lights for an issue like this.

The frame is shot on my 07 Toyota tundra the frame rails has several big holes in the frame as well all the crossmembers are rusted and I’m still currently paying on the truck I still owe $14,000 on it and I can’t afford to get it fixed so will you please please please help me out with this situation and either open the recall up or see if I can qualify for the assistance program I’m paying on a vehicle I cannot drive it’s unsafe to drive and the issue needs fixed the recall or whatever it’s was called should’ve never been expired to begin with and I wasn’t even aware of the recall had I was I would’ve got it fixed !! I’m begging you please help me as my family relies on this on truck I have !! Thank you and have a nice day !!

The contact owns a 2007 Toyota Tundra. The contact initially received a recall notice for NHTSA Campaign Number: 09V388000(Vehicle Speed Control); the vehicle was taken to the dealer and the recall was serviced. Recently, the contact stated that as his wife was exiting their driveway, the vehicle independently accelerated without warning. The contact's wife turned the vehicle into her yard where she hit four trees and then crashed into a big tree which stopped the vehicle. The air bags deployed once she crashed into the bigger tree. The contact's wife was thrown to the right and hit her head on the rearview mirror. His wife was taken to the hospital by ambulance where she was treated for the head wound and back pain. She later sought treatment from an orthopedic doctor where they discovered three compressed fractures to her vertebrae(T1, T2, and T3). A police report was filed. The contact did his own investigation into the accident and discovered that black box had recorded that the vehicle's speed was 42.3 MPH at the time of the failure. Both the dealer and the manufacturer were notified of the failure but both offered no assistance. The vehicle remained in the contact's possession. The vehicle had yet to be repaired. The failure mileage was approximately 164,000.

While driving at speeds between 30 - 50 miles an hour. There is a very rough shudder coming from the transmission. It will get better by speeding up or by stopping the vehicle and turning the car off. When the shudder starts and you try to come to a stop the rear end of the vehicle shakes excessively. You think the back of the truck is going to skip off the road. Toyota did a manufacture service bulletin for this issue. However they only covered certain years and my VIN was not included in the fix. My vehicle now has 211000 miles and it is happening to my vehicle.

I bought a 2007 Toyota Tundra less than 3 months ago from Toyota of Simi Valley. 2 months ago my check engine light and other warning lights suddenly went on while I was driving and my truck went into “limp mode” while merging onto a freeway, causing other drivers to swerve around me to avoid a collision. I took the truck back to Toyota and they advised the Air injection pump and air control valve need to be replaced. Total cost to repair is almost $4,000. I purchased at Bronze level extended warranty which covers up to 24,000 miles but the insurance carrier denied the claim saying these items are excluded, despite these items not being listed on their “excluded items list”. Toyota then offered to pay 1/2 the total cost of repairs, which in of itself is an admission of guilt. I’ve only made 2 payments on the vehicle, I should not be responsible for these repairs. I took the vehicle to an independent mechanic who advised Toyota’s assessment is correct, however, it should only cost $2k to fix the vehicle, not $4k. The mechanic also advised of an emission system issue and that this vehicle will not pass smog at this time.

Transmission shifts very rough. When let off accelerator then back on the trans shift very rough. When coming to a stop and at a stop the trans jumps as if it’s downshifting while sitting still. These issues have been existing since I initially purchased the vehicle. It was reported and I was told it’s normal.

The contact owns a 2007 Toyota Tundra. The contact stated that while idle at a traffic light and attempting to accelerate, the vehicle was jerking with a popping sound coming from underneath the vehicle near the middle and the rear end. There were no warning lights illuminated. The contact took the vehicle to a certified mechanic who diagnosed that the yoke had separated from the driveshaft. The vehicle was not repaired by the mechanic and was instead taken to the dealer for a possible recall repair related to the failure. The dealer confirmed the diagnostic result however, the vehicle was not included in NHTSA Campaign Number: 07V579000 (Power Train). The contact stated that the same failure had occurred 5 years prior and the vehicle was repaired out-of-pocket. The manufacturer was made aware of the failure. The approximate failure mileage was 100,000.

After filling the gas tank and driving home, I happened to notice something hanging down under the driver’s side of the truck. The rear of the two fuel tank bands was fractured near the outboard mount and appears to be due to excessive corrosion. I have no idea if it separated that day or how long I may have been driving with just the front fuel tank band (also rusted) holding the fuel tank in the vehicle. If I hadn’t had a clear view of the truck from a distance (from sidewalk a few houses away), I’m afraid I might never have noticed until the front fuel tank band (now under greater loading condition) also fractured. I’m assuming in that scenario, the fuel tank would drag the ground, held only by the fuel lines, with possible deadly consequences depending on vehicle speed and other factors. I can’t stop my mind thinking about what might have happened. At higher speed, would the rear axle have catapulted over the fuel tank causing loss of control, even before any fuel leakage?