2005 TOYOTA TUNDRA Complaints

I HAD A CHECK ENGINE LIGHT THAT CAME ON WHICH, AFTER CHECKED BY A COMPUTER, WAS DETERMINED TO BE PART NUMBER 1445 (P1445). I RESEARCHED IT OUT AND DISCOVERED THAT THIS IS A COMMON PROBLEM WITH THE TOYOTA TUNDRA 2005 MODELS, YET TOYOTA WOULD NOT COVER THE COST NOR DID THEY CARE UNLESS I WAS WILLING TO PAY FOR IT. P1445 IS FOR THE SECONDARY AIR INJECTION SYSTEM VALVE #2 STUCK CLOSED. IS THERE ANY WAY I CAN BE REIMBURSED BY TOYOTA FOR HAVING TO PAY FOR THE REPLACEMENT OF A PART THAT MANY HAVE HAD THE SAME PROBLEM WITH? THIS IS CLEARLY A FAULTY PART PUT INTO THE 2005 TOYOTA TUNDRAS AND TOYOTA SHOULD BE REQUIRED TO PAY FOR IT'S REPLACEMENT. *TR

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT THE SERVICE BRAKE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT CHECKED THE FLUID LEVEL AND NOTICED THAT THE BRAKE FLUID WAS NEARLY DEPLETED. THE CONTACT REPLENISHED THE FLUID AND THE LIGHT DIMMED. WHEN THE BRAKE PEDAL WAS DEPRESSED, IT SANK TO THE FLOORBOARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE ENTIRE UNDER CARRIAGE WAS EXCESSIVELY CORRODED AND THE BRAKE LINES FRACTURED. THE MANUFACTURER AND DEALER WERE MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 36,121. UPDATED 01/20/15*LJ UPDATED 01/10/15. *JB UPDATED 02/05/15*JB UPDATED 03/10/15*LJ UPDATED 06/17/2015 *JS

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V350000 (AIR BAGS). HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

BRAKE FLUID LOW-TOYOTA SERVICE CENTER SAID MASTER CYLINDER WAS LEAKING ONTO VACUUM PACK THUS BOTH HAD TO BE REPLACED, AN EXTREMELY EXPENSIVE REPAIR THAT SHOULD NOT BE NECESSARY ON A LOW-MILEAGE VEHICLE. *JS

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 14V655000 (AIR BAGS) EXCEEDED A REASONABLE AMOUNT OF TIME FOR REPAIR. THE DEALER STATED THAT THE PARTS WERE NOT AVAILABLE FOR REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE DELAY. THE VEHICLE WAS NOT REPAIRED. THE CONTACT HAD NOT EXPERIENCED THE FAILURE.

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT INDICATED THAT BURNING WIRES FUMES EMITTED FROM THE FRONT OF THE VEHICLE. THE CONTACT STATED THAT THE FAILURE HAD OCCURRED BEFORE AND THE HEAT FROM THE FIRE PREVENTED HIM FROM LIFTING THE HOOD LATCH. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THE FIRE WAS BURNING ON THE FLOOR OF THE FRONT DRIVERS SIDE. THE VEHICLE WAS DESTROYED. THE CONTACT DID NOT SUSTAIN ANY INJURIES AND WAS ABLE TO EXIT THE VEHICLE. THE VEHICLE WAS TO BE FURTHER INSPECTED AND DIAGNOSED BY THE MANUFACTURER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

TRUCK RAN INTO ANOTHER VEHICLE, AIR BAGS DID NOT WORK TO PROTECT THE DRIVER...UPDATED 12/03/14 *BF UPDATED 9/14/2015*JS

COLD START OF VEHICLE, VERY LARGE NOISE, LASTED ABOUT 1 MINUTE. ONLY DOES THIS WHEN COLD START. IF VEHICLE HAS BEEN DRIVEN NO SOUND. RESEARCH INDICATE, THAT OTHER PROBLEMS NOTED ON THE INTERNET WERE THE AIR INJECTION PUMP, AND SWITCHING VALUES, HAS FOAM THAT HAS DETERIORATED AND FELL DOWN ON THE DC MOTOR AND BURNED THE MOTOR OUT. SEEMS THE MANUFACTURE KNOWS OF THE PROBLEM BUT HAS ONLY CERTAIN MODEL YEARS THEY ARE COVERING. SAME PART IN ALL YEARS BUT NOT COVERING 2005 WHICH IS THE MODEL YEAR OF MY TRUCK. IF SAME PART IS ON DIFFERENT MODEL YEARS THEY SHOULD COVER ALL MODEL YEARS THAT HAVE THIS PART AS IT SEEMS THIS IS A VERY EXPENSIVE REPAIR. THIS IS A REQUIREMENT TO UTILIZED TO IMPROVE COLD-START EMISSIONS, WHICH IS MANDATED REQUIREMENT. TOYOTA'S CUSTOMERS HAVE A CUSTOMER SUPPORT PROGRAM TO EXTEND THE WARRANTY SHOULD BE WITH ALL MODEL YEARS THAT HAVE THIS PART. I HAVE AS OF YESTERDAY TAKEN MY TRUCK TO THE DEALERSHIP AS I AM PRETTY SURE THIS IS THE PROBLEM. DIAGNOSIS SHOULD BE FORTH COMING. MANY COMPLAINTS ON INTERNET FOR THIS SAME MODEL YEAR AND PROBLEM. *TR

WE RECEIVED SEVERAL RECALL NOTICES FOR FRAME DETERIORATION AND THE NEED FOR INSPECTION, CORRECTION AND ANTI-CORROSION CHEMICAL APPLICATION. WE TOOK IT TO THE TOYOTA DEALER AS REQUESTED. THEY CALLED THE NEXT MORNING TO HAVE US PICK UP THE VEHICLE AND THE ANTI-CORROSION SPRAY (BLACK GOOEY STUFF SIMILAR TO UNDERCOATING) THAT THEY USED WAS EVERYWHERE, INCLUDING ON THE WIRING HARNESSES, BRAKE LINES, THE STEP BARS THAT WE INSTALLED AFTERMARKET LAST YEAR, INSIDE OF THE WHEEL WELLS, THE MUD FLAPS - IT WAS STILL WET AND SMELLED AWFUL. WE CONTACTED THE SERVICE MANAGER WHO BLEW US OFF, WE CALLED TOYOTA AND THEY REFUSED TO ASSIST, OTHER THAN TO TAKE DOWN THE COMPLAINT ON PAPER. I CAN'T SEEM TO FIND AN ATTORNEY EVEN REMOTELY INTERESTED IN ASSISTING WITH THIS CASE. TOYOTA SAYS THAT THE COATING MAY NEVER DRY SO IT WILL ATTRACT ALL DIRT AND GRIME THAT IT'S EXPOSED TO. IT LOOKS AND SMELLS HORRIBLE. WE CAN'T EVEN SELL IT BECAUSE IT SMELLS SO BAD! TOYOTA WON'T REMOVE IT OR EVEN REPAIR IT, NOR WILL THEY REPLACE THE VEHICLE. *TR

FOR A WEEK I HAD NOTICED A LEAK ON THE SURFACE OF THE PARKING LOT OF MY APARTMENT BUILDING WHERE I ALMOST ALWAYS PARK MY TRUCK. SINCE IT'S AN APARTMENT, I DIDN'T PAY MUCH ATTENTION TO IT, THINKING IT WAS SOMEONE ELSE'S VEHICLE. THEN ON SUNDAY AUGUST 31ST, I HAD DRIVEN ROUND TRIP TO AKRON, OHIO AND BACK TO WILLOUGHBY, OHIO AND NOTICED A HUGE LEAK. I TOOK IT TO THE DEALER WHO SAID IT WAS THE POWER STEERING AND THAT THERE ARE TWO OF THE PARTS THAT NEED TO BE REPLACED. I RESEARCHED THIS PROBLEM AND FOUND THEY HAVE RUSTED AND LEAKED ON OTHER TUNDRA'S OF THE SAME YEAR AS MINE. *TR