2004 TOYOTA TUNDRA Complaints

TL* THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT STATED THAT THE VEHICLE'S FRAME WAS RUSTED. THE VEHICLE WAS TAKEN TO A DEALER FOR INSPECTION. THE TECHNICIAN STATED THAT THERE WERE NO HOLES IN THE FRAME AND PAINTED THE FRAME WITH CRC PAINT. THE CONTACT STATED THAT THE REMEDY FAILED TO REPAIR THE FAILURE AND THE RUST RETURNED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 58,000. UPDATED 09/09/15*LJ UPDATED 12/06/2017*CN

TOYOTA INSTRUCTED ME NOT TO ALLOW AN OCCUPANT IN THE PASSENGER SEAT UNTIL THE AIRBAG IS REPAIRED, RENDERING THE VEHICLE USELESS FOR ME. I CAN'T EVEN SELL THE VEHICLE DUE TO THE RECALL. I NEED TO TRAVEL IN A HIGH HUMIDITY AREA FOR AN EXTENDED PERIOD OF TIME, BUT THEY HAVE IGNORED MY REQUESTS FOR AIRBAG REPAIR.

TL* THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 15V285000 (AIR BAGS) AND 05V254000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME TO DELIVER THE PART TO DO THE RECALL REPAIR. THE MANUFACTURER AND DEALER WERE NOTIFIED MULTIPLE TIMES ABOUT THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

THE ENTIRE FRAME AND UNDER SIDE OF THE TRUCK TO INCLUDE BRACKETS, CABLES, FITTINGS, AND EXHAUST ARE SO RUSTED AND FLAKING OFF THAT I'M CONCERNED THAT THE TRUCK MAY BREAK APART DRIVING DOWN THE ROAD. I BOUGHT THE TRUCK USED FROM LOWE TOYOTA IN WARNER ROBINS, GA AND HAD NO IDEA THAT THE TRUCK WAS A RUSTED OUT DISASTER WAITING FOR A PLACE TO HAPPEN !!

FRONT AIR BAG RECALL CANNOT BE FIXED. WHEN I GO TO THE TOYOTA RECALL SITE THEY SAY THERE IS NO FIX YET FOR THE DEFECTIVE AIRBAGS.

TL* THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT REPAIRED THE VEHICLE PRIOR TO A RECALL BEING ISSUED. THE CONTACT STATED THAT THE MANUFACTURER WOULD REIMBURSE HIM FOR THE REPAIR; HOWEVER, THE REIMBURSEMENT HAD NOT YET BEEN MADE. THE NHTSA CAMPAIGN NUMBER AND AFFECTED COMPONENT WERE UNKNOWN. THE CONTACT HAD NOT EXPERIENCED A FAILURE. ..UPDATED 06-15-15 *BF UPDATED 10/17/2017*CN

LEFT FRONT BALL JOINT ON 2004 TOYOTA TUNDRA 4WD FAILED AND PULLED OUT OF SOCKET WITH NO WARNING (E.G. LOOSE STEERING, NOISE, OR VIBRATION) AT APPROX. 2 MPH IN PARKING LOT. THIS CAUSED THE LEFT AXLE TO PULL OUT AND HIT THE GROUND DAMAGING THE SPLINES. THERE WAS AN EARLIER RECALL FOR THIS SAME PROBLEM AND THE RECALL SERVICE WAS PERFORMED BY INSTALLING A "NEW" REPLACEMENT BALL JOINT IN 2009. LUCKILY WE HAD JUST EXITED A FREEWAY TRAVELING AT 65 MPH. SINCE THERE WAS NO "ACCIDENT" AND NO "COMPREHENSIVE" DAMAGES, THE AUTO INSURANCE DID NOT COVER ANY OF THE $1,200 DAMAGE OR $200 RENTAL CAR EXPENSE. *TR

6/13/13 VEHICLE DID NOT PASS INSPECTION MAJOR FRAME PERFORATION TOYOTA PERFORMED LIMITED FRAME REPLACEMENT AT THEIR COST AFTER MUCH DISCUSSION . NOT ALL SEVERELY RUSTED PARTS WERE REPLACED ONLY THE MAJOR ASSEMBLY MOUNTING PIECE ITEMS THAT WERE DISASSEMBLED AND COULDN'T BE REUSED WERE REPLACED. NO SUB PIECES OF THE MAJOR ASSEMBLY WERE REPLACED. IF THE WERE RUSTED THEY WERE REINSTALLED. 8/4/14 VEHICLE DID NOT PASS INSPECTION MAJOR RUST FAILURE DEFORMATION AND LEAKING OF STEERING RACK HOUSING THAT WAS SEVERELY RUSTED AND NOT REPLACED WHEN FRAME WAS REPLACED. RACK WAS REPLACED BY OWNER AT OWNERS EXPENSE. 4/15/15 REAR DIFFERENTIAL HOUSING RUST THRU AND HOUSING FAILURE. HOUSING WAS SEVERELY CORRODED WHEN FRAME WAS REPLACED. OWNER WAS INFORMED IT WAS NOT PART OF THE FRAME REPLACEMENT . TOYOTA DOES NOT HAVE ANY RECALL BULLETIN ISSUED DESPITE THE NUMEROUS COMPLAINTS FOUND ON THE INTERNET. REPLACEMENT WILL BE AT OWNERS EXPENSE. BRAKE BACKING PLATES AND AXLE MOUNTING HARDWARE THAT WERE SEVERELY CORRODED WHEN FRAME WAS REPLACED ARE NOT SALVAGEABLE AND WILL REQUIRE REPLACEMENT AS WELL IN ORDER TO REPLACE THE REAR AXLE HOUSING. *TR

TL*THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT STATED THAT DUE TO THE DRIVER'S HEIGHT, SHE WAS UNABLE TO LATCH THE DRIVER'S SIDE SEAT BELT PROPERLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE. UPDATED 4/6/15*CN UPDATED 04/09/15*JB

MY SON BORROWED MY 2004 TUNDRA TO HELP A FRIEND MOVE. WHEN HE ARRIVED, HE WALKED TO REAR OF TRUCK AND THE SPARE TIRE FELL TO THE GROUND. UPON CHECKING I FOUND THAT THE WINCH MECHANISM THAT HOLDS THE SPARE TIRE WAS ROTTED. THIS IS DEFINITELY A SAFETY HAZARD. I HAVE READ HORROR STORIES ABOUT TIRES FALLING OFF WHILE IN TRAFFIC AND SERIOUS INJURIES INCURRED. THERE SHOULD BE A RECALL ON THIS. *TR