2004 TOYOTA TUNDRA Complaints

1) The newly installed rack & pinion rack locks up and tried to turn right when on a continuous or left turn followed closely by another left turn. 2) My safety and the other drivers near me were all in danger when the loss of steering control occurs. The problem makes the vehicle want to turn hard to the right and the hydraulics are too strong to control the steering. 3) The problem has not been confirmed by a dealer or independent service center, but the problem still exist and is repeatable for any needed inspection. 4) The vehicle has not been inspected by any outside entity, but is available for inspection. The problem still exist and can be confirmed. 5) There are no warning lights or symptoms. When it happens, all of the sudden the truck wants to make a hard right and there is nothing you can do to stop it, other than stop and let go the the steering wheel.

The contact owns a 2004 Toyota Tundra. The contact stated that the vehicle was Emissions tested, and rust was discovered on the driver’s and passenger’s side subframes. The dealer was notified of the issue, but the vehicle was not repaired. The manufacturer was notified of the failure. The contact related the failure to NHTSA Action Number: PE09049 (Service Brakes, Hydraulic, Tires, Fuel System, Gasoline, Structure). The failure mileage was 72,000.

The contact owns a 2004 Toyota Tundra. The contact stated that while driving approximately 40 MPH, there was an abnormal screeching sound coming from the vehicle. The contact then saw sparks coming from the rear driver’s side of the vehicle, and the driver’s side rear wheel was turned sideways. The vehicle was pulled over to the shoulder and was later towed back to the residence. The vehicle was taken to an independent mechanic, and the contact was informed that the ball joint, control arms, front suspension, and several other unknown parts needed to be replaced. The vehicle was repaired; however, the failure persisted. The independent mechanic made the contact aware of an unknown NHTSA Campaign Number; however, the VIN was not under recall. The manufacturer was notified of the failure. The failure mileage was approximately 200,000.

The contact owns a 2004 Toyota Tundra. The contact stated that after purchasing tires for replacement, the tire technician stated that the subframe was damaged from corrosion to the front frame, the side members, and the rear subframe. The contact was informed that the most severe corrosion was located on the driver's side front subframe behind the wheel well. The subframe was almost fully rusted through. The contact was referred to a welder by the tire shop. The vehicle was not repaired. The manufacturer was informed of the failure and issued a customer complaint report. The failure mileage was approximately 114,000.

The contact owns a 2004 Toyota Tundra. The contact stated that on several occasions, while driving at undisclosed speeds and then parking the vehicle, the contact observed oil leaking from the vehicle. The contact stated that on another occasion, while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was inspected, and the contact observed corrosion and holes on the frame of the vehicle, and the motor mounts were rusted, causing the engine to run abnormally low. The vehicle was towed to an independent mechanic to be diagnosed, and it was determined that the vehicle was flexing due to the holes throughout the frame of the vehicle. The mechanic was unable to lift the vehicle due to the excessive corrosion. The vehicle was deemed unsafe to drive. The manufacturer was notified of the failure. The failure mileage was approximately 150,000.

2004 Toyota Tundra. Left rear upper shock mount rotted away and the shock absorber is no longer connected. (rust) Auto Service report 12/30/2024. October 21, 2021 Toyota Dealership report: Recommends replace spare tire cross member. (rust perforation damage) Recall issued for rust and dealership performed a very limited service repair to this vehicle years ago. The recall repair consisted of rust proof paint applied to a very small limited area, not to frame, not to cross member, not to any shock mount) Concerned about rust currently causing the shock mount to fail and the cross member rust damage along with frame rust on the passenger side. 2 different dealerships told me this concern it is not under a recall. This Toyota Tundra truck is well maintained with regular scheduled auto service checks and appointments. It is never used for towing or off road use. I am the original owner, central New Jersey use only. The truck runs and looks good. The high amount of rust under the truck should not have occurred to the level of a shock mount rusting out and a cross member rusting out and frame rust.

The contact owns a 2004 Toyota Tundra. The contact stated that while the vehicle was parked, the contact became aware that the sub frame underneath the vehicle was rusted. The contact was concerned that the sub frame could collapse. The vehicle was taking to the dealer to be inspected. The contact was informed that the sub frame needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was 157,000.

I purchased 4 Cooper Adventurer 265/70R16 tires in 3-2022 from Pep Boys in Mobile, AL. I had a ASE Certified mechanic checked these tires and found there was a bulge on the tread of the passenger front & tread separation on the driver's rear tire. The tires have approx. 17K miles since purchase. Pep Boys refused to replace the 2 tires unless I paid a pro-rated fee which I refused due to the 2 defects out of 4 tires & the limited amount of miles on the tires. Also, I have rotated the tires 4 times since purchased. The mechanic that found the problems checked the shocks & struts and found no issues other that the 2 tires.

Frame is rusting out, only one bolt is holding left frame per tire dealership & Toyota dealer knows of rusting frame. Spare tire underneath fell out while turning on road, thankfully no cars following.

This truck has a frame that is rusting out. It has rust holes and is now unsafe to drive.