2004 TOYOTA TUNDRA Complaints

TL-THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 10 MPH, THE VEHICLE STALLED WITHOUT WARNING AND THE FRONT PASSENGER'S SIDE TIRE DISLODGED FROM THE VEHICLE. THE VEHICLE WAS UNABLE TO RESTART. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE UPPER BALL JOINT, THE LOWER BALL JOINT, THE CONTROL ARM, THE ABS SPEED SENSOR, AND RT FRONT BRAKE LINE LEADING SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBERS: 07V013000 (SUSPENSION) AND 05V225000 (SUSPENSION). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 123,360. DJR

TL* THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT STATED THAT THERE WAS A STRONG FUEL ODOR COMING FROM INSIDE THE CABIN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 117,000. MAILED OUT 01/13/15*LJ ## VIN PASSED ## TOYOTA TUNDRA 2004 ##

TL* THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V655000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE VIN WAS NOT AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE DRIVING AT 15 MPH, THE FRONT DRIVER SIDE WHEEL DETACHED WITHOUT WARNING. THE VEHICLE WAS TOWED TO A DEALER. THE DEALER DIAGNOSED THAT THE BALL JOINT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 103,000.

I WENT OVER A SPEED BUMP IN A PARKING LOT AND THE FRONT DRIVERS SIDE WHEEL FELL OFF AND WAS WEDGED UNDER THE FENDER. THE MECHANIC AND TOW TRUCK DRIVE SAID THAT THE LOWER BALL JOINT FAILED. *TR

DEALER JUST INFORMED ME THAT MY ROTTED FRAME NEEDS TO BE REPLACED. DEALER INSISTING THAT TRUCK IS ?SAFE? AND IS SAFE TO DRIVE FOR THE NEXT 90 DAYS UNTIL THE FRAME PARTS ARRIVE. DEALER IS REFUSING TO PROVIDE ME WITH A SAFE LOANER FOR THESE 90 DAYS. DEALER IS REFUSING TO PROVIDE CRITERIA USED TO DETERMINE THE SAFETY OF MY FRAME AND TRUCK. DEALER ADMITTED VIA EMAIL THE BED OF THE TRUCK AS WELL AS THE SPARE TIRE CARRIER WAS ?NOT REMOVED DURING INSPECTION?. DEALER STATED (VIA EMAIL) THAT ?ONCE THE >10MM HOLE WAS DISCOVERED, THERE WAS NO NEED TO CONTINUE THE INSPECTION BECAUSE THE FRAME WOULD HAVE TO BE REPLACED.? DEALER IS REFUSING TO TELL ME WHAT CRITERIA WAS USED TO DETERMINE HOW SAFE THE VEHICLE WAS TO DRIVE. DEALER REFUSING TO PROVIDE THE FRAME INSPECTION REPORT AFTER MANY REQUESTS. SAYS ?IT DOESN'T EXIST?. DEALER REFUSED TO GIVE FRAME SAFETY INSPECTION CRITERIA USED TO DETERMINE A FRAMES SAFETY. CONTACTED CUSTOMER SERVICE AND ASKED FOR SAME CRITERIA. 1ST RESPONSE WAS ?ITS PROPRIETARY INFORMATION THAT I CANNOT GIVE YOU?. AFTER PUSHING THE ISSUE FARTHER, AND STATING THAT ALL I WANTED WAS A SAFE LOANER CAR TO DRIVE WHILE MY TRUCK IS WAITING ON A FRAME, THEY TOLD ME TO CONTACT DEALER FOR THE CRITERIA I AM REQUESTING BECAUSE THEY HAVE BEEN GIVEN THAT INFORMATION FROM TOYOTA. CONTACTED DEALER AGAIN, AFTER MULTIPLE EMAILS ASKING THE SAME THING, EVENTUALLY HIS RESPONSE WAS ?THERE IS NO CRITERIA?. I AM DENIED THE USE OF A SAFE LOANER BECAUSE THE DEALER IS SAYING THAT MY TRUCK IS SAFE TO DRIVE (BASED ON NON EXISTENT CRITERIA AS WELL AS AN INCOMPLETE FRAME INSPECTION). ACCORDING TO THE FLOWCHART, IF MY FRAME NEEDS TO BE REPLACED, A LOANER WILL BE PROVIDED FOR UP TO 60 DAYS (OR EVEN LONGER), IF PARTS AVAILABILITY IS CAUSING A DELAY. NOWHERE DOES IT STATE THAT I AM ONLY ENTITLED TO A LOANER IF AT MY DEALERS DISCRETION DEEMS IT AS "UNSAFE TO DRIVE". *TR

RUST ON EVERYTHING UNDER THE TRUCK AS WELL AS THE REAR BUMPER. PARTS THAT HAVE HAD TO BE REPLACED BECAUSE OF RUST AND/OR RUST PERFORATION OR NEED TO BE REPLACED: 1) ENTIRE FRAME ' PERFORATION GREATER THAN 10MM FOUND ON PASSENGER SIDERAIL 2) REAR DIFFERENTIAL (LEAKING FROM RUST PERFORATION) 3) BRAKE LINES 4) POWER STEERING LINE (LEAKING FROM RUST) 5) SKID PLATE (SUPPORT BRACKETS RUSTED - FELL OFF WHILE DRIVING) 6) BRAKE CALIPERS (MULTIPLE TIMES) 7) COIL SPRINGS 8) AXLES (FRONT AND BACK) 9) CONTROL ARMS 10) CV- JOINT 11) BOOTS 12) HITCH RECEIVER 13) EXHAUST 14) MUFFLER 15) CAMBER BOLT 16) MULTIPLE SETS OF TIRES (UNABLE TO ALIGN TIRES PROPERLY DUE TO RUSTED/SEIZED CAMBER BOLT) CAUSING PREMATURE TREAD WEAR. 17) BRAKE DRUMS (WARPED AND PITTED) 18) WHEEL BEARING 19) TRUCK TAILGATE SUPPORT WIRES ' WIRES RUSTED AND BROKE. TAILGATE WON'T OPEN/CLOSE WITHOUT EXTREME EFFORT BECAUSE IT IS NOT ALIGNED PROPERLY. 20) SHOCKS/STRUTS 21) SEALS, BRACKETS, NUTS AND BOLTS - THE PARTS LISTED ABOVE IS NOT COMPLETE. BASICALLY, EVERYTHING YOU SEE UNDER THE TRUCK IS SUFFERING FROM EXTREME RUST AND/OR PERFORATED. *TRUCK HAS HAD A HORRIBLE SHIMMY FOR YEARS THAT NO ONE HAS BEEN ABLE TO FIGURE OUT, PARTICULARLY BAD WHEN TOWING. STEERING WHEEL SHAKES VIOLENTLY AS WELL AS THE ENTIRE TRUCK. IMPROVED SLIGHTLY WHEN REAR DIFFERENTIAL AND AXLES WERE REPLACED. MOST LIKELY RELATED TO FRAME WARP OR INSTABILITY. *TRUCK HAS HAD ISSUES WITH GETTING IN AND OUT OF 4WD. INCONSISTENT WITH HOW LONG IT TAKES TO GET IN AND OUT OF 4WD. THERE IS A LOUD AND JARRING CLUNK WHEN ENGAGING OR DISENGAGING 4WD. *TRUCK FEELS LIKE IT IS ON THE VERGE OF GOING OUT OF CONTROL WHEN A HOLE OR BUMP IS HIT. THE TRUCK WILL LITERALLY JUMP SIDEWAYS. *TRACTION STABILITY CONTROL COMES ON RANDOMLY WHEN HITTING A BUMP OR HOLE. ANOTHER MYSTERY TO MECHANIC. *TR

TL* THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V350000 (AIR BAGS). HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT RECEIVED A NOTIFICATION FOR AN UNKNOWN MANUFACTURER RECALL. HOWEVER, THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCE A FAILURE.

ELECTRIC STABILITY CONTROL ENGAGES WHEN WE HIT A BUMP OR POTHOLE. NO ONE CAN EXPLAIN WHY THIS IS HAPPENING. POWER STEERING FLUID LINE HAD TO BE REPLACED BECAUSE OF EXCESSIVE RUST CAUSING IT TO LEAK. THIS PART ALONE COST OVER 600.00. PREMATURE TIRE REPLACEMENT BECAUSE OF THE INABILITY TO ALIGN PROPERLY DUE TO EXTREMELY RUSTED COMPONENTS THAT COULD NOT BE ADJUSTED PROPERLY. HORRIBLE STEERING WHEEL SHIMMY WHEN ON FREEWAY THAT ALSO CANNOT BE EXPLAINED OR FIXED (EVEN AFTER REPLACING THE REAR DIFFERENTIAL AND AXLE) TRUCK IS EXTREMELY "SQUIRRELLY" AND FEELS LIKE IT CAN GO OUT OF CONTROL, ESPECIALLY AFTER HITTING A HOLE OR BUMP. *TR