2004 TOYOTA TUNDRA Complaints

VEHICLE FRAME HAS EXCESSIVE SURFACE RUST, ALSO ON REAR AXLE CASING. FLAKING DELAMINATION OF FRAME/CROSS MEMBER WHERE CROSS MEMBER JOINS REAR FRAME. FRAME NOT PROTECTED CORRECTLY WHEN VEHICLE WAS MANUFACTURED. *TR

NOTICED THAT VEHICLE WAS PULLING TO LEFT. CHECK ALIGNMENT OK. NOTICED THAT SWAY BAR LINK HAD SNAPPED DUE TO CORROSION. REPLACED WITH TOYOTA PART AND CONDITION CORRECTED. *TR

TL* THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT STATED THAT THE BRAKE PEDAL TRAVELED ABNORMALLY TO THE FLOORBOARD. THE CONTACT DISCOVERED THAT THE BRAKE LINES WERE FRACTURED. THE DEALER STATED THAT THE BRAKE LINES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 63,000.

THE UNDERCARRIAGE OF THE TRUCK IS COMPLETELY CORRODED. CANNOT REMOVE THE SPARE TIRE, THE PARTS HOLDING IT WILL FALL OFF. THE TRUCK IS UNSAFE DUE TO THE POSSIBILITY OF THE UNDERCARRIAGE AND CROSSBARS FALLING OFF. SAME ISSUE AS THE RECALL OF THE 2003 THUNDEROUS. CALLED TOYOTA LOCAL, REGIONAL, AND US CUSTOMER SERVICE WHO KEEP TELLING ME THE TRUCK IS NOT PART OF THE RECALL THEREFORE THEY CANNOT HELP ME. THE TRUCK WAS PURCHASED IN RI, MOVED TO NC IN OCTOBER 2012. LOCAL TOYOTA DEALERSHIP ALSO CONTACTED CUSTOMER SERVICE WITH NO LUCK.

TL* THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V350000 (AIR BAGS); HOWEVER, THE PART NEEDED FOR THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

I HAVE A 2004 TOYOTA TUNDRA THAT HAS 52,400 MILES ON IT. THE FRAME IS COMPLETELY RUSTING OUT WITH HOLES FORMING IN THE FRAME . MAINLY ON THE DRIVERS SIDE FRONT AREA FRAME. EXHAUST IS ROTTED OFF AS WELL AS MANY BOLTS AND NUTS. *TR

I HAVE RECENTLY RECEIVED A FRAME RECALL NOTICE DUE TO EXCESSIVE CORROSION WHICH I ADDRESSED AT THE LOCAL DEALERSHIP. I WAS INFORMED THAT THE RUST HAD NOT PERFORATED THE FRAME AND THAT IT WOULD BE TREATED TO PREVENT FURTHER RUSTING. WHEN I PICKED UP THE TRUCK AT THE DEALERSHIP THE ASSOCIATE ADVISED ME THAT THE RECALL WAS DONE AND THAT A FULL SAFETY INSPECTION WAS COMPLETED WHICH REVEALED NO OTHER PROBLEMS. WHEN I RETURNED HOME I LOOKED UNDER THE TRUCK TO INSPECT THE FRAME AND NOTICED THAT BOTH SWAY BAR LINKS HAD CORRODED AND BROKEN OFF . I ALSO SUBSEQUENTLY TOOK THE VEHICLE TO AN ALIGNMENT SHOP BECAUSE I NOTICED THE STEERING WHEEL WAS NOT STRAIGHT AND WAS TOLD BY THE SHOP THAT THE TRUCK COULD NOT BE ALIGNED. I WAS TOLD THAT THE VEHICLE WAS VERY DANGEROUS TO DRIVE AND TO BRING IT TO THE DEALERSHIP IMMEDIATELY WHICH I DID. THE DEALERSHIP SERVICE DEPARTMENT DISCOVERED THAT THE STEERING SHAFT COUPLING WAS SO CORRODED THAT THEY NEEDED TO REPLACE IT AND DO A WHEEL ALIGNMENT. I AM CONCERNED THAT THIS MAY BECOME A COMMON SAFETY ISSUE WITH THE TUNDRA WHICH SEEMS SUSCEPTIBLE TO EXCESSIVE RUSTING AND AM REQUESTING THAT THIS ISSUE IS INVESTIGATED AN A RECALL ISSUED IF NECESSARY. *TR

REAR AXLE-HOUSING ROTTED THROUGH . DEALERSHIP KNEW THIS ON INSPECTION OF FRAME ON MAY 20 2014.CORPORATE OFFICE WAS MADE AWARE OF PROBLEM BUT REFUSES TO ADDRESS SITUATION. UPDATED 4/24/2015 *JS

RUST ALL OVER THE UNDERTRUCK, EVEN THE CATALYTIC CONVERTER IS RUSTED. I WAS PART OF THAT RECALL AND THE DEALER IS GOING TO SPRAY THE FRAME TO STOP THE CORROSION. CAN THE CORROSION PROCESS ENDS WITH THE SPRAYING? *TR

TL* THE CONTACT OWNS A 2004 TOYOTA TUNDRA. WHILE HAULING A CAMPER, THE POWER STEERING FAILED WHEN THE CONTACT ATTEMPTED TO PARK THE VEHICLE. THE CONTACT DISCOVERED THAT THE POWER STEERING STEEL LINE WAS CORRODED AND FRACTURED, WHICH CAUSED THE POWER STEERING FLUID TO LEAK. THE POWER STEERING STEEL LINE WAS REPLACED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 62,500. UPDATED 09/30/14*LJ UPDATED 02/25/2015 *JS